Ford Excursion :: Smoke Started Coming Out From Under The Hood - Trans Fluid Leaking
May 15, 2016
I have a 2000 2wd with the 5.4 in it. I tow a travel trailer and loaded is 6500lbs. Today leaving the campground I had to climb an extremely steep hill as soon as you left the campground. No time to build speed. The old Ex made it, but I was definitely worried. The truck ran fine the rest of the 2 hours home. I went to back my camper into its spot to store, and smoke started coming out from under the hood. When I crawled under it, tranny fluid was leaking on the ground. A pretty steady drip. I let it cool down, added fluid and drove around. Didn't leak anymore. Did the tranny just get hot and had to burp? The drip was coming from where the tranny connects to the motor.
View 8 Replies
Advertisement
A little background info...up until about 6 months ago my 01 Ex V10 was a grocery getter for the wife; only got a few thousand miles a year for the most part. Since we moved from Washington state to Texas it has turned into my daily driver (after a 2500 mile drive towing 8k trailer).
A couple of weeks ago we were running errands and after we got home there was smoke coming from under the hood, but I couldn't pin point it. I let it be because I figure it would let me know when something was really wrong. A few days later it did it again but this time I found the problem; transmission fluid was leaking out of the bell housing onto the y-pipe. I did my research and come to find out it is most likely the front pump seal that got soft from overheating. So my buddy and I drop the transmission and replace the seal. Put it all back together and everything seems great.
Another week goes by and we have driven the Ex fairly extensively around town and even took a couple short day trips and everything is great. Then as we are turning onto an on ramp to get on the highway I give it gas to speed up and all of a sudden the RPMs climb like it dropped into neutral. I had enough momentum that I got over onto the shoulder and started to check thing under the hood. Looked like I was low on trans fluid; ok so I added a quart. Put it in "D" and still nothing. Then I try "1", "2", "R" and they all work fine.
View 4 Replies
This line is rusted out on my V10 and leaking fluid.
How hard/expensive is this to fix?
I'm in the middle of doing my exhaust manifolds right now, so I'm hoping it's a simple bolt-on fix.
View 8 Replies
2000 Excursion 7.3 unk transmission
Quick run down on the situation. It has been terribly hot here bumping 105 degrees. I was told by a man he could see fluid leaking and it was trans fluid. I checked it and filled it up and got it to the shop.
Next day they said it was not leaking and that it probably overheated. They recommended an after market trans cooler. They put it in and off I went. 60 miles later I got fluid all over the rear of the truck. I filled it up again and got it home. Shop says I need a new trans.
View 9 Replies
I have a 2004 F150 4x4 super crew with te 5.4L in it. Truck has 200K plus miles on it and I went to start it after driving (it may have say for 10 min) the truck hesitated and didn't start and smoke started coming from under the hood. Looked like it was coming from the drivers side maybe mid fender or closer to the firewall. Look at it and nothing was on fire but something defiantly happened cause now its compensating for something. The rpms are up from what they usually are and the drivers information was cleared. Truck runs now but just worried
View 6 Replies
I have a 2001 nissan altima. About 4 weeks ago it started over heating, smoke coming from under the hood, not the gauge raising. I took it to my mechanic and he replaced the big hose going from the radiator to the engine. I got it back and about 2 days later it started again overheating again, smoke under the hood. Took it back and he said the radiator is leaking it was under a year old so he replaced it, i drove it home on a sunday and monday morning I drove to work 5 miles at 10 am break it had two puddles under it. He said it's the radiator again, replaced it and we went to pick it up and he said it blew again. Sounds odd to me He finally said they thought it was the fans. The gauge never ran hot only the smoke coming from under the hood. If your looking under the hood it was wet on the left side. Needless to say he has had my car for almost 2 weeks and it's still not fixed. My question is should I go get it and take it somewhere else. What damage will it do to drive it somewhere else?
View 19 Replies
I have a 2007 Honda Odyssey touring model. Recently I had it serviced at the Honda dealership. In addition to my requested front end alignment and oil and filter change, they talked me into a radiator flush, fuel inj. service, air filter replacements and battery service. I drove the car home after wards even filling up with gas before going home. This drive was about 55 miles. I never noticed any problems. The next day, I left for Montghomery AL towing a trailer with a motorcycle trike on it. We stopped for lunch and continued. The car suddenly started making a grinding noise from engine compartment and suddenly white smoke started coming out from the hood. I immediately pulled over and we got out of the car for fear of fire. This was the first time I had any indication of a problem.
After a short time, I opened the hood to see what was wrong and noticed that the radiator cap was sitting upside down next to opening. I had the vehicle towed to Chattanooga where I was told there was serious damage to the engine. I had them repair it (they were an AAA approved towing and repair shop). I also took pictures of the engine compartment. I went back to the dealership and asked to be reembursed for my expenses and the cost of repairs and the owner refused. He said he didn't believe they left the cap off and since he started out in the service department he didn't believe the car could even go that far without overheating. My question is: Is it possible for a 2007 Honda Odyssey to travel approximately 220 miles over two days before overheating and wrecking the engine if the radiator cap was left off and/or if no fluid was even added and the radiator cap was left off?
View 19 Replies
I have a 1997 Ford F-150 XLT 4x4 with the 4.6W and a 4R70W trans. For the past year is has been leaking trans fluid and has slowly got worse and worse. At first the truck would only leak at high speeds (when driving on the interstate for extended periods of time) and now It has gotten to the point where I am adding close to a quart of fluid a week. ( roughly about a quart every 300 miles!). I thought that it was the pan gasket leaking at first, so I flushed the trans fluid (dropped the pan and drained the TC and put on a new filter) put a new gasket on and torqued it all down and added some new Valvoline max life fluid. The first trip in the truck I noticed a puddle of fluid under the truck again.
The pan looked like it could have been a little warped, so I ordered a new pan and a new FoMoCo gasket (the one the came with the new filter was the cheap felt type). I thought I for sure had fixed the truck this time, but I drove it and once again it was still leaking. I checked all that I could before replacing the pan and gasket. I checked the trans cooler lines and fittings (no leaks) I pulled the inspection plug and it was dry (so I ruled out the front pump or TC leaking). The whole underside of the truck is covered with fluid so it is hard to pin point the leak, but most of the fluid drips down on the transmission cross member.
View 3 Replies
I'm pretty sure I have a blown head gasket. I have white smoke coming out of exhaust and the oil is brownish in color indicating radiator fluid is leaking into engine. The car has over 200K on it. I purchased Steel Seal. The guy I talked to from Steel Seal said if radiator fluid is dirty (which it is)than I should flush radiator before using product. I don't have money to replace the gasket and I don't have money for a new car right now. Can this be a fix that gets me through a couple months?
View 3 Replies
I have a 2004 f150 4x4 with a 5.4. i have been leaking some fluid for a few months now but when i check oil and transmission both fluid levels are fine. I crawled under and it looks like something is leaking near engine and trans meeting and fluid looks reddish making me think its trans. now this week I developed a whining sound when truck moves. Again I rechecked oil and trans fluid levels and are all good. i was going to check transfer case but it is way behind leak and dry.
View 9 Replies
I have a 2006 v6 ford mustang and just developed this problem yesterday.
When I drive the car, the temp guage stay right in the middle, but when I park I get white smoke come from under the hood. I popped the hood and saw coolant leaking from where the top radiator hose meets the engine block. This was producing the smoke. When I checked the hoses, the top hose was hot and hard, the bottom hose was cool and soft.
Extra info:1. I did not touch the radiator to see if there were cool or warm spots2. The overflow bottle looked empty or close to it, but the engine was still hot from driving to work
Thinking this could be one of the following:
1. bad thermostat
2. clogged radiator
3. Air bubble somewhere blocking the coolant flow
View 5 Replies
Took my '11 F350 CC 6.7 Lariat with 31k miles on it into the dealer to have the tranny fluid leak looked at. I noticed this leak a few weeks ago as the bell housing was damp with fluid and the bolts heads on the underside of the poly engine oil pan were pooled with fluid. It is a very slow leak as I have parked it for 3 days and there were no drips of fluid on the ground, just collecting on the grid like pattern on the oil pan. Checked Fluid level and it is also full.
Anyway, the dealer put dye in the tranny fluid and told me to drive it for a few days. I took it back in on Monday and called this morning for an update. The mechanic informed that they ordered a new torque converter and some other parts to be "proactive" because he believes the TC is the issue. I asked if the cab would have to be pulled and they informed that all the work could be done from underneath. Glad I noticed this before the B2B warranty expired because this would have been expensive. I will be THOROUGHLY inspecting the entire vehicle from top to bottom before I hit 36k.
View 11 Replies
I have a 2009 F150 that when I came home from Cabo Monday, had a big puddle of fluid under the truck. I took it to Ford and they said it was some type of bolt on the tranny that is nationally backordered for who knows how long. They topped off my fluid and told me I would be good to go till the part comes in.
View 14 Replies
I just got my 2003 excursion v-10 gas and its bad but when I'm towing my camper it weighs 8500 lbs empty and I'm trying to back it up on the beach the tranny ( when I'm in reverse ) starts spitting trans fluid out the vent on top ! went on fire twice ! the trans temp gauge never gets hot tho and other than that it works perfect, I was told this was a big problem?
View 14 Replies
Recently my 2003 Cadillac CTS has been leaking coolant at a faster pace than I could ignore. After noticing smoke barreling from under my hood, I decided to research the problem and attempt a DIY repair job by replacing the auxiliary coolant pump. After purchasing the part online and reviewing any forums I could find, I was determined to prove the naysayers wrong by undertaking the task over a free weekend. After a couple of hours I soon realized that this was a two man job. Still alone at the 4 hour mark, I was almost resigned to having it towed to a mechanic with all sorts of wire connections still unplugged. Resigning to give it one more college try I tempted the father-in-law over with the promise of all the beer he could drink. After another 4 & 1/2 hours 'without draining the coolant beforehand :)' we had successfully accomplished the mission (almost) impossible. So all in all, this chump (myself) spent almost 9 hours to perform this complex vehicular operation. My question is, for this part (an aux. coolant pump) how long would a certified, classically trained mechanic take to make the repair?
View 5 Replies
Is there an easy way to drain the tranny fluid in the power steering pump, or do I need to take all of the fittings for the pump, gearbox and cooler apart?
2000 7.3 Excursion with stuff ....
View 6 Replies
I have a peculiar problem. When auto crossing and driving the car hard, the lug bolts on only the front driver's side wheel have a tendency to loosen. I torque the bolts to 100 ft-lbs with a torque wrench, so I am confident they are tight before I start driving. The retaining screw holding the rotor in place loosens as well. The wheel has fallen off once already while driving.
I do notice in the transition from accelerating to decelerating (only sometimes) that there is a stuttering from the front driver's side (sounds a little like an out of balance wheel). When it happens, it's often at 55MPH in 5th and at lower speeds in lower gears. The car was leaking a little trans fluid too (.5qt), but I can't tell from where. It has since stopped.
View 18 Replies
Light film of white smoke from the right side of the hood wheel underneath the passenger wheel an slightly from the front no antifreeze in vehicle at the moment car parked an not driven since the altercation.
View 12 Replies
It's a '00 zr2, usually after 15-20mins driving I see smoke blowing out rear at highway speed. If I'm driving slow same results with smoke just rolls out from hood. Smells like trans fluid although doesn't seem like the level is any lower yet.... Guessing gasket when under pressure, I would guess passenger side hitting manifold but I haven't seen obvious leaks don't know where to start.
View 2 Replies
On my way home from work traveling at 65 miles an hour, all of a sudden the oil light came on and i got steam or smoke coming from under my hood, and had to be towed home, after it was towed home I tried to start it and and the engine makes this whining sound now.it sounds as if it is trying to turn over but with less of a cranking sound. is the engine gone in it or could there be another issue?
View 2 Replies
I have a windshield washer fluid leak. It's leaking onto the passenger side floor under the dash. Any have a good place to start looking or how to access the area it might be leaking at?
View 6 Replies
