Ford F-150 - 1997-2003 :: Overheating / Temp Gauge Climbs And Then Truck Goes Into Limp Mode
Mar 30, 2013
I am looking at a 1997 F150 with a 5.4 in it, guy who owns it says if you drive it down the street the temp gauge climbs and then the truck goes into limp mode but if you check the engine temp under hood it is nowhere near overheating. Where I should start to look for a problem here? If this is too complicated I will pass on the truck, its not worth it to me to get this truck if it is going to be a nightmare. I have a 2000 with a 4.6 that runs great so this would just be a spare for me, but would like to have it because its in such nice shape.
View 1 Replies
Advertisement
My F250 with V10 has developed an overheating problem. While driving, the temp gauge suddenly shoots to max, and the truck goes into limp mode. Turning off the truck and ignition, waiting a few minutes, and all seems to be well again - sometimes for only a minute, sometimes for several days. No steam leaking, the water in the reservoir seems to be normal temperature, the radiator is not overly hot, and the AC keeps on blowing ice cold. Me thinks it is not really overheating, it just thinks it is. So where to start? Change the temp sensor first, or the thermostat? It seems the hoses are fairly firm, I don't believe they are collapsing from suction.
View 14 Replies
Truck runs cool when driving around town about 177. Get on the highway and the temp goes to about 195, go up a mountain pass she climbs to about 210 and I feel that If I dont back off the gas the truck will overheat because the temp just keeps climbing. Go down the highway again on a flat stretch of highway and it drops to 195, get into town temp drops to 177 and even lower when i just let the truck idle.
Truck has a brand new 195 thermostat, fan clutch is only a month old, water pump is about 2 years old, this truck has had head gasket issues in the past but every year I put in the bars stuff and have not had a problem with it since, I started doing the bars stuff about 4 years ago. This is the stuff you flush the system first with not the pour in stuff. 1997 f150 4.6l
View 8 Replies
1998 f150 4.6 4x4 auto 180k .... Runs 100% other than a strange and inconsistent overheating issue.
On cold startup truck will warm up. Then the temp gauge drops to practically 0. After 15-20 seconds gauge shoots up to max and then falls back to normal after 15-20 seconds. Then it'll go back to driving normally. At some point it pukes.
View 6 Replies
I have a 95 s10 4.3L V6 auto with 92k miles.
This all started when one day on my way to work the temp gauge got to 260 then quickly fell. It has not gotten that hot since then.
When I start the truck cold and start driving, the gauge climbs to about 215-230 within 10 minutes of driving. Once the gauge hits what ever is the magic mark for the day it quickly falls (10 seconds or less) to about 170-180. Sometimes it will "cycle" up again to 200 or so then fall back to 170-180. Once it is done moving around it stays low and will not move much as I am driving.
I bought an IR thermometer and measured the temperature at various points in the cooling system. The top of the thermostat housing is about 195 or 200 right after it climbs and drops. If I drive for a while around town then check it, the housing reads hotter, about 220 max.
There does not seem to be enough temperature drop across the radiator, I have measured about 15 degrees difference max between the hoses and on some days only 10 degrees difference.
I have replaced the fan clutch (was bad or going bad), the thermostat, and the radiator cap.
After none of this fixed it, I took it to a mechanic who did a "block test" at my request and said it was fine. He thought what it was doing, climbing and falling was normal.
If I run it without the radiator cap on I do not see much if any flow when I look down into the radiator.
Right now I am thinking of doing the water pump and flushing the radiator this weekend.
View 17 Replies
2005 Hyundai Tiburon Keeps Overheating
I live in Washington State and have a 2005 Hyundai Tiburon with less than 110,000 miles. I have had it for 5 years, and have not had any issues with the car until recently (last 2-3 months). My car overheated on me back in May while out running work related errands. I was able to leave it parked downtown while my husband took a break from his job to come pick me up. Since then, it has continued to overheat every time I drive it.
The temperature gauge climbs into, or dangerously close to, the “red Zone” within the first 10 minutes of driving. The first couple of times the car overheated, if I was using the air conditioner, it would start blowing hot air instead of cold air and the air would stay hot. Now when I drive the car with the air conditioner on and it over heats, it continues to blow cold air (if that matters at all).
My super handy husband (a certified motorcycle mechanic) has done the following in an attempt to fix the car:
•Checked coolant levels
•Topped off coolant
•Bled coolant system and added yet more coolant
•Replaced the thermostat
•Replaced the radiator cap
•Water pump was replaced November 2012 (not even a year old yet)
The radiator cap was the most recent fix. It was replaced on a Wednesday evening after testing it and finding that the existing one was not maintaining the proper PSI. The car drove great around town for two whole days without any issues (Thursday & Friday). Saturday, I decided to take it on a longer drive out of town to see if my good luck would hold…it didn’t. I drove a total of 30 miles round trip and my car started overheating after about 20. I limped back into town and barely made it back to our apartment.
My car continues to overheat!! What is going on?! So confused and frustrated I’m hesitant about taking it to a mechanic who, my husband is convinced, will just charge me to check all of the things he has already fixed.
View 7 Replies
I have a 2002 Lincoln LS 3.9L. Intermittently the temp. gauge will go up near hot, the fan will come on and gauge will drop back to normal. Car will go into limp mode when this happens. Fan and thermostat were replaced several months ago to eliminate this problem but it is back. Mechanic had trouble getting air out of the cooling system at the time.
View 2 Replies
I was towing a fairly heavy trailer yesterday (around 10k) and laying into the throttle to gain some speed before a big hill when I completely lost power. It slowed me down to about 10 MPH.
I was able to drive home at very slow speeds and the only way to get over 10 MPH (only up to about 20MPH was to very lightly accelerate up to speed. Any hard acceleration and it cut me off to 10 MPH. No warning lights of any kind going off...
Truck has a Hypertech Max Energy programmer on stage 2.
View 7 Replies
I have a 2004 Grand Prix and it is displaying the symptoms of overheating but the temp gauge is not going above normal operating temp. I replaced the thermostat twice, and after driving for about 10-20 mins coolant comes out of the overflow. I'm at a loss, I'm thinking temp sensor(?) But I don't want to keep throwing unnecessary money into it. The fans work fine, the heater blows as it should.
View 8 Replies
Just fully rebuilt transmissin 4r75 replaced all planet gears clutches etc. Now with it all back together the speedo does not work on truck goes into limp mode. I replaced the vss sensor an no luck
View 8 Replies
Problem: The exterior temp. gauge is blank.
It used to fade in and out and I discovered if I pushed the button that switches from degrees F. to degrees C. it wold come on for a bit, but no more. It's just blank.
I think I've seen a thread on here about similar issues but I was unable to find it. I'm also not sure how to take the overhead console off yet. The console consists of ext. temp gauge, sun glasses compartment, and compartment for a garage door opener.
Some truck specs:
Year: 2001
Model: F150 Super-crew
Motor: 4.6L
Mileage: 250,000
Color: Silver
Original motor, second transmission.
View 9 Replies
I have a 2002 supercrew 5.4 triton. My coolant temp gauge is acting up. When it starts up its obviously in the cold range but when the truck begins to get up to temp, the gauge only goes up 1/4 full. What it can be?
View 4 Replies
What the problem is with my F-350 6.0. I have an intermittent problem with my Speedo reading zero while I'm doing 70mph on the fwy. since the speedo won't work the truck goes into limp mode, the turbo will not function at optimum level. I have replaced the diff. sensor, the trani sensor, the a.b.s.sensors, the instrument cluster to a reman cluster. Then when I had a local mechanic plug a laptop dianostic program on it as he was running through the system inadvertently the radio cut out, so I found that who ever installed the after market stereo they cut a few wires to the harness, I went to the junk yard found the harness end and replaced the end. so with all that said and done no one knows what is causing this speedo not to work and limp mode. about 4 years ago the oil pump stopped working and ruined the turbo so the whole front end of that glorious 6.0 was rebuilt the problem started about a year after that.
View 2 Replies
I just bought a 97 f-150 from my dad, there are some electrical issue's but the main one seems to be battery drain.
I have noticed with the truck off key in my pocket, the a/c doors keep trying to move and the a/c head has power to it.
I know the engine has been replaced, with about 20k on it.
The temp gauge pegs w/o getting hot, and it even turned over once while we were getting in the truck. Again key in pocket.
View 1 Replies
97 f250 4.6l engine pegs the temp gauge after start-up. the oil pressure light comes on then after a few miles down the road anti-freeze blows out the pressure cap (15LB) then the temp goes down ,the oil light goes off and everything is normal. no its not the thermostat, i changed that and it still does it. whats up with that?
View 14 Replies
I recently bought a h&s tuner and installed a dpf delete kit. Everything works great when the truck is not plugged in to the tuner although when I do plug it in, the truck keeps throwing a communications code and goes into a limp mode until I delete the code. I believe it was p0073 but i maye be mistaken. Regardless it has to do with communicating through the obd2 port. I sent the tuner in to get checked out and it turns out its something to do with the truck. I've checked all the fuses and tried to check for broken wires. Where to look next?
View 4 Replies
My '97 F250 5.4L is pumping coolant on to the top of the motor which is burning off causing it to smoke like it's overheated but the temp gauge is operating in normal range. I'm losing coolant but can't see where. It's not going to the ground. It just pools up on the top of the motor. I've already replaced the water pump in the last 2 weeks because of the same issue. It stopped for a few days but now it's back again. Bad water pump from O'Reily's or is there some other issue here? I've checked while the motor's running and can't see where the coolant is coming from and there's no coolant coming out of the bleed hole in the top of the new water pump. I need this truck up and running.
View 7 Replies
My son bought his first truck, 1998 Ford F150 Supercab 4.6L Auto. (Proud of Him)
Salvage Flood Title, looks like engine been replaced. (Not so proud of him).
Anyway, vehicle seems to run and drive fine, however, failed emissions test.
P0125 Code pops up, Temp Gauge is not working, pegs all the way hot after truck is running, changed out Both ECT's in front of engine, one is right beside the other, I guess one goes to PCM and other to Gauge.
Now Gauge is reading all the way cold, let run for over 30 minutes and still shows nothing on Gauge...
View 11 Replies
I've got a 2001 F150 and lately, since the weather has warmed up, I've had a problem. After a few minutes on the road, the engine seems to be lacking power and is running hard. It also seems to shake a bit too. It's not overheating and the gauges don't show signs of high temp. My drive to work is 40 minutes and by the last 10 or 15 minutes it seems to be OK. ... A month or so ago when the weather was cold, I had problems keeping coolant due to leaks but that problem seems to have diminished. I don't know if any of that is connected to the original problem or not.
View 7 Replies
I own a 1997 ford f150 V6 engine and I have problems with the electrics. I turn the key on and the engine starts up runs great but I then look at the gauges and not one moves at all the. No fuel when i have just filled up,no tep,no oil,no battery all read nil. I went a drive and the speedo reads 0 it does not move but the truck drives great. Could it be a fuse, does a fuse control the gauges, which one it could be. I have lifted the hood and under the hood on the drivers side there is a box with small and larger fuses.There is one that is very small and the colour is white that's blown. Would you no what that fuse is for.
View 1 Replies
The truck I'm working on is a 2003 f550 with a 6.0, and 382000 kilometers. My service truck died on me couple days ago, while running. As I rolled to a stop, I noticed that my temp gauge on the dash dropped to cold. (Truck was hot). Tried starting, and I have a crank, no start situation.
After towing it to my shop at work, I hooked it up to my scanner, and found that the pcm will not communicate with the scanner (otc genisis). I have no injector buzz with key on, wait to start light comes on for an abnormally long time. I have 48.3 volts on the ficm,(4 screw), and haven't been able to find any chafed wires as of yet.
View 1 Replies
