Ford F-150 (2004-2008) :: Front 4x4 Hub Binding / Squealing From Driver Side


Oct 14, 2012

I have an 07 f150 base model truck, manual 4x4 no push button. It seems something is binding in the hub once in awhile. I am driving down the road and all of a sudden i hear a loud squealing from the front drivers side. I slow down and then something seems to engage when I am almost stopped. I did a little research and have come up with the actuator might be bad. I just don't wanna throw parts at it that it don't need. Here's a lil more info. Last winter I put it in 4 wheel drive and the passenger side was making the same noise with the 4x4 not working when I hit the gas. I am thinking actuators need replacing on both sides.

View 5 Replies

Advertisement

Ford F-150 (2004-2008) :: Driver Side Wheel Bearing Squealing Pretty Bad

I just replaced my drivers side wheel bearing that was squealing pretty bad. After replacing it I now have the same noise only consistent where before it was only when I turned the wheel to the right. I noticed the teeth in the cv shaft where a little warn down when I changed the hub. Now also along with that noise I'm getting a clunking sound. Should I just change the cv shaft or is there something else I need to be looking at?

View 1 Replies

Ford F-150 (2004-2008) :: 2005 - Squealing Sound Coming From Front Passenger Side Area

My 05 Supercrew 4X4 with 172k miles started making a horrible noise these last couple days. It sounds like its coming from the front passenger side area. The best I can describe is that it sounds like an electric tool motor with bad bearings. I'll be driving along at 45mph or above and every now and then I'll hear a really bad bearing squeal. It's bad enough that I can feel the extra friction caused by the squeal start to slow my truck down. It's vehicle speed related. I know what a bad wheel bearing sounds like and this is nothing like that. It's gotten bad enough I'm nervous to drive anywhere.

View 4 Replies

Prius (2004-09) :: High Pitched Squealing Noise From Front Driver Side At Above 30 MPH In Cold Weather

When it is cold (below 30 degrees) and above about 30mph, there is a loud high pitched squeal (rather like the pitch of a squealing hearing aide)that seems to come form the front drivers side. The colder it is, the louder it is.

When I am able to take it in it is too warm to hear it. What might be causing the noise and will they be able to figure it out if it isn't making the sound?

View 4 Replies

Ford F-150 (2004-2008) :: Squeaking In Driver Side Front Shock Only

How to stop a squeaking front shock. It's my drivers side front shock only. The shocks are fine as far as wear and ride, it's just this squeaking (very noticeable in parking lots) that's about to drive me crazy!!

View 14 Replies

Ford F-150 (2004-2008) :: Clicking Sound On The Driver Side Front Tire

I have a clicking sound on the driver side front tire. It only makes the noise when I am in motion and have the wheel turned. It does it reverse and forward. The CV axle is not turning, and it does it with 4x4 engaged and the cv axle turning. I had the front end apart not to long ago replacing the IWE Integrated wheel hub, and the bearing isn't to terrible old, and its a timken.

It didn't wobble when the wheel was up in the air, and seemed solid. All the other front end pieces have also been replaced. I also hear a rubbing noise when I am driving on that side. For awhile before I replaced my IWE Hub I thought it was the cv axle just turning ( I had the lined unplugged so it was engaged to prevent damage), well after fixing the IWE Hub it still makes the sound and the cv axle is not turning as it was before.

Wondering if the bearing is maybe on its way out? One thing I did notice is tie rod end I just replaced along with all my new front end parts (upper control arms, and lower ball joints) the boot is severed completely all the way around. However the tie rod appeared to be in good shape, just the boot has been cut or split some how. Which I plan to fix, but I don't see how that would cause a clicking sound. I have inspected to make sure no lines or vac hoses are rubbing, and they are not.

View 13 Replies

Ford F-150 (2004-2008) :: Grinding Sound From The Front Driver Side Hub Area

About 3 months ago I started having a grinding sound from the front driver side hub area. I replaced it and it fixed the problem. I read where you should do both because he other one is soon behind it but I waited. Now I started hearing it from the passenger side too. So I replaced it today and all was good until I tested it from 4 wheel back to 2 wheel. Once I went back to 2 wheel the clicking that sounds like bearings going out to me, was back. What is it?

View 1 Replies

Ford F-150 (2004-2008) :: Humming With Rhythmic Vibration Coming From Driver Side Front Wheel

2008 2wd 4.6L 98K miles F150 for the past few weeks has been humming with a rhythmic vibration which feels like it is coming from driver's side front wheel. It doesn't do it constantly, nor at all speeds. Once I hit about 25mph, you can start to hear a humming. At 35, slight vibration. Between 50-60, heavier vibration. Sometimes at 65+, it subsides quite a bit. Both front rotor assemblies are newer, and I put in a brand new left because I thought it was a bad bearing.

View 5 Replies

Ford F-150 (2004-2008) :: 2007 - Creaking Sound Coming From Driver Side Front Wheel Area?

MY '07 SuperCab just started making a strange rhythmic sound as I drive. It is coming from the drivers side front wheel area. It is like a short creaking sound. It stays the same if I am turning the tires. Seems to go away if I put the brakes on hard, but I slow down so much I am not sure. Front CV Joint?

View 1 Replies

Elantra MD (2010-15) :: Squealing Noise From Front Driver Side Wheel Area

About 6 weeks ago I noticed a noise coming from the front driver side wheel area. We had just gotten the tire rotated and once at freeway speed it was like a squealing noise, just like when you have worn brakes. Since then the squealing noise is gone and now it's a faint (hard to describe over text) "whomp whomp" noise as if I have off-road tires. I notice it more on freeways I supposed because it's a smoother straighter surface. On a particular right bending street by our house it's louder. What it might be? Car has 36k miles.

View 8 Replies

Prius (2004-09) :: 2008 - Rattling Noise From Driver Side Front Wheel?

First issue started a few weeks ago. When turning left at a speed > 20mph or when turning wheel quickly I get a rattling noise, which is more prominent with the driver window down, so it sounds like it comes from the driver side front wheel, but not quite sure. It is fairly loud as I have had pedestrians look at my car when turning because they can hear the rattle.

Second issue started this morning but has persisted every time since. When the car is cooling down, we get that whirring noise, which I presume is thr coolant pump. That noise also happens now when I enter the car, and it is accompanied by a knocking noise as if somebody is hitting the outside of the car repeatedly. This is quite unnerving as it sounds like something is hitting the bodywork of the car. It stops immediately when the normal whirring stops.

I had the steering and water pump recall done in november last year, could this be related to that? Forgot ti add the car has done 49000miles....

View 14 Replies

Ford F-150 (2004-2008) :: Driveline NOT Binding In 4WD?

I've had occasional issues the last year getting my 04 into 4WD, but at 270K on the original IWE actuators, that's probably to be expected.

I had new actuators ready to install, but took the truck out for a drive before doing the job. On a gravel road the back tires spun easily in 2WD, I switched over to 4wd and it was much harder to spin the tires- you could tell it was in 4WD- or at least seemed that way. I left it in 4WD and tried turning on a tar road and it didn't seem like it was binding at all. (I have an open diff in the rear, assume the front is the same?)

Anyway, I installed new actuators last night and took it out for another drive afterwords. I put it in 4WD and could IMMEDIATELY feel the binding when turning.

What I cant figure out is why I could NOT feel binding while in 4WD prior to the install. Could I have been in 3WD somehow? (04 Super Crew, Automatic, 4.6L, XLT- pretty basic pickup...)...

View 2 Replies

Ford F-150 (2004-2008) :: Transmission Binding Especially In Reverse

Well it seems the transmissions POOCHED. It feels like its binding especially in reverse, and makes a whining sound in park/neutral. I guess, I will take it to the trans shop tomorrow and hope for the best....

View 7 Replies

Ford Super Duty (1999-2016) :: 2008 - Front DS Wheel Binding When Turning And Loose Seals?

I have a 2008 F-450 Lariat 6.4 4x4. I recently started noticing the front driver side wheel (best I can tell) wheel makes a noise as though it's binding uo when turning either direction, and I can feel it as well. 4wd is not activated and the hubs are in auto. When the front end is off the ground, I rotated the wheels and they spun independently unless the hubs were locked. I noticed what appear to be seals on both the driver and passenger side hanging loose (see pics). What this might be? I recently used the 4wd when we visited White Sands National Monument while pulling a 5th wheel RV.

View 9 Replies

Ford F-150 (2004-2008) :: Driver Side Headlight Comes On / Shines But Very Dim

I recently bought a 06 F150 Lariat scab 4x2 with a 5.4L. I am having a problem with the driver side head light. It comes on but not all the way on (shines but VERY dim). The low beam works correctly sporadically. I haven't done any trouble shooting yet because I haven't had a day off. I did replace the bulbs today thinking I had a loose filament maybe. Don't usually do shotgun maintenance but wanted to put xenon's in anyway.

View 2 Replies

Ford F-150 (2004-2008) :: Driver Side Window Squeal When Going Up Or Down

My '04 driver window would squeal when going up or down....dealer replaced entire window track/molding around door window opening. Fixed the squeal, but the new rubber molding looked like crap from wrinkle, stretching, etc.

Now, to today. My '07 is now doing the same squeal on both sides! I do not want 'new' trim/tracks installed because I'm convinced they can't do it like 'factory'. It's worse when it hot and sunny out...vs...rainy or dew.

My next step is to remove my door panels and 'q-tip' some clear silicone into the tracks on the window edges...as I believe the problem is simply 'dry rubber' which is rubbing the window edges. Rain or high humidity offers just enough 'lube' to prevent all but the slightest squeaks.

View 14 Replies

Ford F-150 (2004-2008) :: Driver Side Seat Wearing Out

Looking for recommendations for a well fitting seat cover for this series of trucks? My driver's side is tearing (12 years of people dragging their rear ends across it will do that) and the foam cushion is starting to lose small pieces. I try to stand on the running board when getting in/out to minimize wear on the seat, but I'm just delaying the inevitable, not preventing it. I bought a set at Autozone, but it's going back because it doesn't fit properly and that makes it look, well, kind of tacky.

​​​I've tried a few local scrap yards, but nobody has a matching seat in my interior color that isn't already wearing out. Autozone or any other retailer just carry universal fit covers, which don't fit well enough to look appealing. My only other option is to have it re-upholstered, but I have a feeling that might be on the spendy side.

View 5 Replies

Ford F-150 (2004-2008) :: Driver Side Brake Has Been Dragging And Getting Really Hot

I have a 2004 xlt xtracab F150 and for the last week my drivers side brake has been dragging and the first time it happened it got REAL HOT and after I let it cool down it did release and then 2 days later it did it again but with a one mile slow drive to work did not get that hot. I am assuming that I will have to replace the caliper but is there anything else I may have to change?

View 5 Replies

Touareg :: 2008 - Driver Side Front And Rear Speakers Going In And Out

Having issues in the T2 with driver side front and rear speakers going in and out. Comes back on when going over bumps or making left turns. right turns and they shut off again. also seams to happen more when listening to factory installed sirius than the iPod...

I've been doing car audio installs for years and this started shortly after i put an iPod adapter and amp/sub in. the head unit was never pulled out and i checked all the connections where i tied in with the rear speakers for the sub. I really don't think it's install related.

What would cause one side to go out front and rear?

View 3 Replies

Ford F-150 (2004-2008) :: Water On Floor Boards On Driver Side

OK for the past few weeks I have been notice water on my floor boards on the DRIVER's SIDE. Now I just did some cab lights and thought ok maybe that's it. About a week ago while it was raining out I dropped the headliner and it was dry as a bone. So I eliminated that as a possibility.

Then I thought well maybe its my 3rd light and the water wasn't showing up until there. So that's been replaced and sealed tight. Now it has been cool here and has not rained in about a week now so everything should of dried out by now.

I left the floor mat out all of yesterday and last night and came out this morning to a dry floor area. I put the mat back in and drove the 15 minutes to my office and pulled the mat back out and the floor was wet again. I have not run my heat or A/C in 4-5 days and have not had any weather other then sun since last Saturday. The water shows up on the back of the floor mat more as like a heavy condensation then anything else. So my question is where is this water coming from?

View 14 Replies

Ford Excursion :: 2004 - Rattling Noise Coming From Front Driver Side?

I'm new to the forum and Excursion ownership but was hoping someone could save me some time and aggravation chasing a rattle in my 2004 2wd 6.0 PS. It seems to be coming from the front driver's side since I can feel it through the steering wheel. As of now, it's nothing major since it doesn't seem to affect tracking but I'm afraid it's getting worse.

I'm thinking it's a worn bushing but as I'm less familiar with the vehicle as y'all are, maybe you can point out the weak points that may be causing my issue. I plan on jacking up the front end tomorrow and inspecting for play. I'll let you know what (if anything) I find. Are there any known issues I should be aware of?

View 11 Replies





Copyrights 2005-15 www.bigresource.org, All rights reserved