GTI 337/20th Anniversary :: Coolant Leaking From The Water Pump
Jul 13, 2013
I replaced my timing belt, tensioner and water pump last weekend because I noticed I was leaking coolant from the water pump. The other day I popped my hood after driving and notice the reservoir bubbling a little bit because it sounded like the coolant was boiling and the line coming into the top of the reservoir felt hotter than normal. I opened the cap slowly and never heard any pressure release. I figured it was air in the line somewhere so I tried to work the air out. It sounded like the air came out and I took it for a drive and I finally heard pressure release after 3 different attempts. I opened the cap later when it was cool and noticed that the coolant was still at the original level.
Then the next day I was driving and came to a stop and noticed white smoke coming out when I gave it gas. It still drove fine though. I pulled over and opened the cap slowly but didn't hear any pressure release. I put in a little bit of radiator sealant and it seemed to do the trick.
The car has never overheated and there's no oil in the coolant or coolant in the oil. The heat also seems to be working correctly and my fans come.
View 6 Replies
Advertisement
my water pump broke they other day and then i was lifting up my seat and notcie it was wet. the whole left side of my car under the carpet is wet. why do you think there is water is only on th eleft side. could it be becuase the water pump broke??
View 19 Replies
Just want to make sure I'm naming the part correctly. It's a pump that between the radiator and the block. It stays on after the car is turned off. This is on a 2005 GLI 5 speed tip.
Lately, its not turning on. If it does, it's just for a brief moment and then turns off. After some searching, I've read post of other asking about by-passing it. Would that be a benefit? What's gained from that? I understand the pump is on while the engine is running, does it provide additional cooling? I'm planning on checking it out this weekend and wondering if it could be rebuilt? Could you guys indicate which vendor on the web has the best price?
View 2 Replies
I've got a 07 LS460 with 95,000 on the ODO and took it in for a harsh ride. The tech called back and said the upper and lower control arm bushings are bad along with a water pump leak.
If the water pump is leaking, shouldn't I have known? I haven't had any low coolant issues, smells or fluid on the ground.
I'm covered by an extended service plan, but would like to have known (otherwise I could have gone bust!)
View 12 Replies
I have a 05 gli and leaking water from drive side visor towards the sun roof. Would the drain be clogged from the sunroof. My seat is getting wet....
View 7 Replies
Bought a 04 GLI had the bad engine, had the engine installed sat at the shop for nearly a year. Towed car to my house to finish it and now I am running into their lack of knowledge and fixing their crap. Now the current issue...On the thermostat housing, a nipple that comes off the side has nothing connected and leaking coolant.
View 7 Replies
I just got my 337 a few days ago and I got out today after a short drive and smelled coolant. Immediately thought the worst but luckily I found this hose to be leaking. What hose this is its on the left side just about the throttle.
View 11 Replies
After researching this for weeks, I think I've found that the pollen filter seal is worn and that's why I'm having water leaking onto my front passenger side floor. My car alarm has been going off randomly too. Every time it rains the floor is soaked. It's not the sunroof drain plugs. I already tried that. I need to fix this ASAP!!! How do I fix a worn pollen filter seal? I have a caulk gun ready!
View 11 Replies
I've had the leak for a long time now possibly from when I've gotten it... anyway when I first bought it I drove it a lot, like 8k miles in 6 months. During that time I went through a qt of oil about every week and a half. Now the last 3 months I've been barely driving it due to life changes so I'm barely putting oil in I'll go weeks sometimes of checking the level and it'll be fine. This leak has to relate with how often its driven and maybe hot?
I've had the car up multiple times to try and find the spot all I know is it's behind the engine below the valve cover gasket and above or near the turbo area(I've only owned my first VW this 20th for less then a yr so I'm still learning)
View 8 Replies
I learned today there are at least two water pumps in my 2006 Prius, and that one of them is leaking. I had the recall done for the electric motor water pump in November. Now, during my scheduled maintenance, they tell me my second water pump has been leaking (slowly). My car has 132,000 miles.
View 19 Replies
A little less than a year ago I decided to change the timing belt & water pump on my then 61k miles '05 V8. I bought the BlauParts timing belt kit and rented the tools from them also. The install went without a hitch, the old water pump gasket came off nice and clean and I installed the new water pump gasket without any RTV as per the instructions.
A couple of weeks ago the Phaeton hit 65k miles so I did an oil change and while I had the belly pan off I noticed a small whitish pink spot on the belly pan, right below the crankshaft pulley. Looking closer I found coolant traces that came from the water pump area. I cleaned it all up and decided to drive it for a few weeks to see if it's an actual ongoing leak or if that was maybe just an old leak that might have happened just after the install. Unfortunately it's an actual leak ..
First I thought maybe it's leaking out at the gasket but closer investigation shows that the leak is actually right below the pulley at the bottom of what looks like a freeze plug at the front of the water pump. Is this a common area for a leak with this type of water pump? It's only been installed for 11 months and 4,500 miles. Btw, the pump in the kit is a Saleri model GD42107.
I'm really bummed about this because it's a lot of work to swap a water pump out and I'd hate going thru all that work again (and having to rent the tools again). Question is, can I swap the water pump out without putting the front bumper into the service position? From what I recall the only clearance issue might be finding a puller that is short enough to pop off the camshaft sprockets with the radiator that close.
Here are a few photos from when I found the leak:
This was after a 200 mile trip, fresh coolant:
This is were the leak is coming from:
View 15 Replies
I just got back from the dealer and was told my water pump was leaking. I was told it was a small leak and that it could only be seen by lifting the car. I opened the hood and noticed some pink crusty looking thing on what i believed to be the water pump. I took some pictures of the water pump, the radiator and overflow level. If you look closely you can see some of the pink crusty stuff around the pump. I poked it with a pencil and it broke apart pretty easy.
First of all if that pink crusty stuff is anything i should worry about? Also if the levels of the fluid in the radiator/overflow tank are good? Is there another sure way i can tell that i even have a water pump leak? I searched around the forum and it looks like the hardest part about replacing the water pump is getting the air out of the system and that the dealer quote is a rip-off.
View 19 Replies
my 2007 Camry LE I4 and I got an oil change at the dealer today. He tried to tell me my water pump was leaking and needed replacement.
Offered me a deal of "%50 off the price for $500" which I think is ridiculous. Took it to a family friend that is a mechanic and he said $266 to replace the whole thing.
Dealer said they would do a price match but I'm not sure what to do.
They said it would make it to Tennessee and back because it's in its infant stage.
My question is, when I refilled my low antifreeze, I accidentally overfilled a lot past the line. Would this have anything to do with this issue?
View 11 Replies
Alright, so upon starting my car earlier today, i was unable to get the fuel pump to turn on and send fuel to the motor, car will crank over and want to start, theres just no fuel getting to it. I'm going to replace the fuel pump relay and clean up the throttle body to cover the simple stuff. also i recently just installed a 3 inch down pipe, could have the o2 sensors shorted as a result of a bad knock?
View 2 Replies
I can't see where it's coming from but it's leaking onto my TIP. it's not a lot though.
View 4 Replies
So the other day i found a lake on the floor behind the drivers seat. Everywhere else is dry but there. A few days prior I got tapped by a ram enough to crack my rear bumper on the drivers side. I am wondering if the water came in through the crack? Everything is dry though under the spare tire . I know there's vents on the sides behind the bumper, but I don't think I got hit hard enough or at the right angle to bust a seal on the vents. I also blew air through the sunroof drains and they were all clear. Windows were closed and all doors were closed when it rained.
View 8 Replies
I have no clue where it came from but now my car smells like mildew. Where and how it came in? Also how to get rid of the smell? To make things worse I have monster mats so I never knew it was there until I smelled it then lifted the mat.
View 8 Replies
I noticed that my floors were wet. To the touch they weren't soaked or even a puddle. It was just a damp feeling. I took a moisture reader to the carpet and sure enough I was right. I used a space heater to dry out my carpet. I had it all dry and now some moisture is back and where it gets tricky. The floors that are wet, are in the middle of the foot well in the rear of the car. When I use the moisture reader, I try and follow a leak along the carpet but I can't not for the life of me figure where this water is coming in at. After a lot of teams each most issues seem to be leaky sun roof or leaky seal on windshield. I've cut the nipples off of my sun roof drains already. What can cause this water? have any way to test where it maybe leaking from? In the footwells there are frame bumps and the water is most wet in that location.
View 8 Replies
Well I first had a slow leak, which was happening because I had a bad O-ring for my coolant temperature sensor. I replaced the O-ring, and I also replaced the whole coolant flange for good measure. After that I added some coolant, and started her up. And before i knew it, there was a pool of coolant under my car. It seems like the hose coming downward from the flange is swelling up (look at the pictures). But I have no clue what this hose is, or what it does.
View 10 Replies
I was hearing some sounds from my engine and opened up the timing covers to determine where the sound was coming from. It sounds exactly like the Sienna with the same 3MZ engine in this video: YouTube ....
While I didn't find the source of the noise, I did find that my water-pump is leaking. My question is, is this water-pump leaking bad enough to be replaced? I do not notice any coolant loss and never had the need to top up.
It appears from this last photo that the pump is leaking through its pulley shaft and not at the interface with the engine:
The timing belt and water-pump were changed 3 years ago with the Gates timing belt kit from RockAuto. The pump at the time didn't look that great quality in its casting compared to an Aisin pump.
I could not feel any play or hear any abnormal sounds from the pump while it was running with the timing covers off.
This is on my 2005 Lexus ES330 with the 3MZ-FE 3.3L V6 engine, same motor as the Gen 5 Camry SE V6.
View 7 Replies
My ICE failed to start on a wooded forest road -- after the car had sat under a fir tree for a day or three it ended up starting and all the warning lights went away. I ended up taking it to the dealer though and while they replaced a leaking water pump, never found any cause for the ICE failure.
View 2 Replies
