Golf IV / Jetta IV :: Sunroof Would Open But Not Closing
Feb 12, 2016
Trouble shooting my sunroof. When I first go the car the sunroof would open but not close, even when I pushed in the button to reset.
I have replace/ and calibrated replace the switch now I get the fallowing.
When I put it to open all the way, it goes in to vent mode ( the back opens up), ( when i put it close it closes fine).
When i put in vent the sunroof slide back 1/4 of the way. when I try to close it closes and opens back to 1/4 open. I have to close it and press the button in to close it.
View 2 Replies
Advertisement
I have a weird situation, when I open the sunroof then try to close it, it slides to the middle then opens again. After four trials the sunroof switches to manual then I close it manually.
View 3 Replies
When I open my sunroof and then later on go to close it, it will come in half way and then stop and go back in to open.
View 5 Replies
2004 GLI ... Venting opens but when I turn the knob to open the sunroof completely, I can hear and see that it wants to open but it stays neutral and wont open up. I attempted the manual crank. Again, I can get it to vent manually, but when I turn the allan key the other way to fully open the roof, it will go as far as moving just below the roof line, but it will not continue to open. I'm concerned if I crank on it too hard, something will break.
View 2 Replies
I have a few different rattles going on that I am not sure how to fix. I did a quick search and didn't find exactly what I was looking for.
1) Sunroof sunshade - about a week ago, the sunshade on the sunroof has started to rattle when the sunroof is open. If I lightly push up on the sunshade the rattle stops. The rattle goes away when the sunroof is closed.
2) Armrest - I get a rattle when driving over anything but super smooth roads if the armrest is any position but all the way down and pushed in. When armrest is extended, if I put any weight on it, the rattle pretty much goes away.
3) Driver side dash vent - again over anything but super smooth roads, the driver's side vent on the dash (next to the top of the drivers door) will rattle. If I push on the vent, the rattle is reduced but doesn't go away completely.
View 10 Replies
I'm experiencing noise when sunroof is open. This is happening at lower speeds and at last couple of sunroof positions. I guess it's vibrations or some weird effect. (Golf MKVI 2.5)
View 13 Replies
My sunroof will vent open and close by its self randomly while driving. Same problem occurs with my girlfriends 08 Passat. She said the dealership couldn't duplicate the issue, and when asked me about it I just laughed, shrugged my shoulders and said its probably just loose wiring.
View 2 Replies
Is this something that can be done with the remote? Does it have to be activated by the dealer? I can open/close windows/sunroof with the key but not with my remote.
View 8 Replies
Earlier today I went out to give a family friend a ride and as the temperature had climbed, elected to close the sunroof and windows and use the A/C. While out, I noticed an abnormal amount of wind noise coming from the sunroof and double-checked to make sure it was actually closed. It didn't budge when I pushed it towards the 'closed' position so I figured it was just my imagination.
Well cut to getting home about 20 minutes later and sure enough, the sunroof is ever so slightly down at the back, even when stopped in the 'closed' position. In order to get a proper seal, I have to tap the tilt switch up ever so briefly.
I'm hoping that the sunroof control unit has simply lost its bearings and needs to be reset and though I've got an appointment set up with my dealer for next Tuesday (the soonest they have available), I tried my own solution for the night. I put the roof in as close to the properly closed position as possible and disconnected the negative battery terminal. I plan on leaving it this way for at least 8 or 9 hours and shall report back.
View 6 Replies
So recently, on steep inclines or declines, the sunroof will tilt open to the first notch, all on its own. Sometimes it goes back, sometimes I have to turn it open and close it again. Nothing has changed, it just randomly started doing it in my driveway a few weeks ago (relatively steep driveway) I was parked on the slope with the car on, and it was just opening and closing and opening and closing.
View 3 Replies
Out of nowhere began the horrendous screeching wind noise after closing my sunroof during this morning's commute. The sunroof had been dead-quiet all the years I've owned the car. This was not a gradual event, but quite sudden, and occurred after the third closure within 20 minutes. I cycled the sunroof open and closed several times, but to no avail. After arriving at work, I inspected the channels for debris, the rubber seal for failure, and the general appearance and alignment of the glass to the opening. Everything appeared normal. The only thing that alleviated the noise was slightly opening the driver side window, but this in not an acceptable solution.
View 2 Replies
So I want to remove a sunroof cover from a GTi that's being parted out but the problems are there is no power in the car. I know that you need to be able to tilt the sunroof up in order to remove the cover. So, is there any way to do this without power?
View 6 Replies
So I bought my 03 golf 2.slow about 10 years ago used and it came with a moonroof... not a sunroof. I never really thought about it and just assumed it was a option from the factory but the seals have been leaking lately and I was looking for a replacement seal and could not find anything only sunroof parts. Is this an aftermarket moonroof where they cut a hole in the roof and added this?..I really hope not. Or did someone take the sunroof assembly out and put this in its place.
View 3 Replies
Have a sunroof that rattles when closed while going over bumps? I use my fingers to lift up on it and its barely budging, also floors are soaked....
View 3 Replies
last weekend I was closing my sunroof and it went all the way shut, then started going back, just like your garage door does if you leave some stuff blocking the door. I stuck my hand in there and whisked around to see if there was anything blocking it but found nothing just dust. I didn't look closer because I was going down the highway 75mph at the time. Them the issue went away by itself and I left it shut.
View 6 Replies
My 2003 Jetta sunroof drains aren't clogged. Nor are they simply cracked. They don't seem to be connected. I tried snaking them out with trimmer line- the thing took like 15 ft of line without resistance, from either end. I suspect they had a mechanic who tried to use compressed air to blow them out, and may have blow the line off its nipple instead.
So I can't install a new, smaller line inside the old one. There's no way to fish the line from one end to the other.
I'm doing the headliner anyways. I can replace them, but I need to know what type of tubing is actually used. Plus, how that tubing would go down the A-pillars and meet up with the rubber nipple? Can that thing be pulled out from the outside of the door jamb?
View 8 Replies
I own a 2002 GTI and my sunroof was damaged beyond repair.
A local headliner shop had a used 2004 Jetta sunroof which he sold to me. The shop owner said everything was in working order with the sunroof except the wire harness that runs to the sunroof was missing the plug since it was cut. He recommended just taking the plug from my GTI sunroof motor and soldering it onto the Jetta motor since it may throw off the "timing" of the sunroof motor and would need to be recalibrated if removed. Keep in mind he is an authorized Webasco dealer so I took him at his word.
I cut my plug off of my GTI sunroof motor harness and began to solder it onto the Jetta sunroof.
I quickly noticed the Jetta sunroof motor had one extra wire (Brown). I didn't think it would be a big deal since my GTI doesn't have 6 wires and only requires 5 so I mounted the new sunroof with the Jetta motor onto the car.
The sunroof retracted back into the "fully open" position and would close but would not go into the "vent" position. Each time I would turn the dial to the "vent" position, the sunroof would slide back into the "fully open" position.
I thought this was a bit strange and now I am beginning to wonder if I need to swap the GTI sunroof motor on my car due to it not have the extra wire or is the Jetta sunroof motor going to work fine but another issue is causing this to happen?
Below are the differences in the two sunroof motors. Both are Bosch products.
Jetta Sunroof Motor - Part Number : GDO 849 696 564
This part has 6 wires that connect to it.
White, Green, Gray, Blue, Purple, and Brown
Where as the GTI has only 5 wires on it.
GTI Sunroof Motor - Part Number : GDO 849 696 566
White, Green, Gray, Blue, and Purple
The difference between the two is the additional BROWN found in the Jetta sunroof motor.
View 4 Replies
Fiancee's 04.5 GLI is leaking from the sunroof drain into the front passenger footwell.
The Tubes are clear, but the front passenger drain is leaking from the upper portion of the tube. I pour water down the drain and 90-95% comes out the door nipple. The other 5-10% comes down the Pillar, and then out the bottom of the glove box.
I know its coming out of the top of the drain, not the nipple at the door because I can visually see water drops inside of the pillar.
What if I make a small plug to close off the 1 corner of the drain? I understand the correct solution is to pull the headliner and reconnect it.
BUT with the holidays and chaos of this week, would a temporary solution be to close off the 1 hole? I'd do a small delrin or aluminum plug with an oring on a lathe real quic so its a water proof seal
OR if I plug it, will the water level rise too fast inside the sunroof and pour into the car? I don't know.I think the plug would be a safe solution.....
View 2 Replies
My sunroof opens and closes correctly. but when in the closed position it will be sunken into the cabin of the car a few MM not sealing to the body of the car tightly. how do I fine tune the sunroof to sit flush with the body when closed? some kind of adjustment screws?
View 4 Replies
Winter is here and its the first winter i've had my 2006 Passat 3.6l. After a long night of freezing weather i attempt to open the door. After getting it loose, It wont seal close. When i shut the door it will just bounce off and open again.
My temp solution is to hold the door closed and press the lock key. The door then partially locks closed and then i have to pull it hard to make the seal close completely.
View 5 Replies
I have a 2008 Hyundai Azera and out of nowhere the moonroof quit working. It is almost closed - only 1/2 inch open - so I can live with it but would like to fix it. My mechanic said that the problem was software that only the dealer could fix. Called my 2 local dealers and they were absolutely clueless.
View 8 Replies
