Passat (B5) :: 2002 Won't Start After Heater Core Replacement
Apr 24, 2013
I just put a heater core in a friends passat that was running just fine, drove it into the shop. I pulled the dash and replaced the heater core and put it all back together. Everything works, starter turns over and all but wont fire. I went over everything numerous times to find anything unplugged but all looks fine. Says something about an airbag fault when you turn on the key. Would this prevent startup? what can I do?
View 6 Replies
Advertisement
Have a '02 f150 and thinking the heater core slowly dieing. Have noticed for several weeks a nice line of water leaking onto the passenger side floor. Do you have to take off the entire dash to get to it? Will be doing replacement myself as the dealer or shop would probably kill me on labor.
View 12 Replies
2002 F150 5.4... I thought that I saw on here before a link that explained how to replace the heater core without removing the entire dash console. Looking for a link for this or get some good directions on how to replace the heater core?
View 1 Replies
I have an 02 passat with about 85K and the other day my windows would not clear up and a faint smell of antifreeze. also when temp control is in cool and you move the temp control to warm steam comes out of vents. I need to know if i could change this myself and if any procedure on how to do it.
View 3 Replies
I may have to replace the heater core on my 1990 Celebrity. Done from under the hood, or inside the car, under the dash? How difficult is this?
View 8 Replies
I have a 2008 Hyundai Santa Fe . Since January 2013 I have had the heater core replaced 3 times. The repair shop has done the last 2 at no charge to me. The dealership ran a diagnostic and could find no reason for the repeated heater core failures. I feel there has to be something going on with the car that is causing the heater cores to keep failing. When the original one started leaking I had around 70,000 miles on my car. I bought it new.
View 6 Replies
How to replace the heater core?
View 13 Replies
I have a 2001 F150 with a 4.6L.. Do I need discharge the AC lines when replacing the heater core? How difficult is it to replace the heater core?
View 5 Replies
I recently replaced my heater core on 2001 F250. Would be a simple job if it weren't for the quick connects on the hoses. Any tool to take these apart on the truck where space is limited?
View 1 Replies
Started to attempt to replace the heater core in my 08 SD 6.4. Didn't know the entire plenum has to come out in order to replace it. How to remove the plenum? My buddy is a Ford tech but I just am not getting what he is telling me and there is next to nothing coming up when I try to search.
View 2 Replies
Ford dealership is having problems with heater core repair. 2002 Ford F150 Supercrew. Problem is antifreeze (or early on just smell) in the cabin. 4 heater core replacements in 2 years. A hose (?) replaced. Electrolysis kit replaced. 4th heater core replacment finished yesterday. I know that I need to let the dripped antifreeze work out of the system, but I am smelling mild antifreeze this AM. Usually gets worse over 2-3 days then I have to take it in. What might be being missed here?
View 5 Replies
Plastic coupling between core and hose, is there a specialty to needed to remove from heater core?
View 1 Replies
I purchased a 2002 Dakota and have had a hard time ridding it. I thought that the heater core was leaking and getting the passenger side floor wet, but it's the overflow for the evaporator under the dash. The drain must be plugged. Will I have to remove the dash to pull the heater unit down far enough to clean it. I don't think I can do much from under the hood...too tight.
View 4 Replies
I thought the air will be flushed out from the heater core over time. Heater works ok, but can hear a sloshing sound.
Does pressing the rubber heater hoses going to the firewall? Other methods? Take coolant tank cap off once in a while?
View 1 Replies
95 jimmy change the heater core now won't start...
View 6 Replies
I have changed the compressor for my lumina LTZ 2001... After that a noisy sound start to appear ... And cooling stopped after a while((around a week)) they told me to change the heater core. And I changed it.After that similar sound start to appear again ... And the cooling start to be reduced gradually ...and then no more cold air..The sound appears infront of the next to driver seat.
View 5 Replies
Last week I got a hole in my lower heater coolant line and I did a quick fix and added G12 to get the car home but I got to thinking, the way I'm using this car now, I'm not so sure I need the heater.
View 6 Replies
I have a 2010 GMC 3500 Savanah van with 6.0 motor. No heat in van. Engine operating temp is normal. Heater hose into core is hot. Hose coming out is barely warm. I am of course hoping for another explanation other then blocked heater core. The truck only has 45k miles. I am ready to backflush , but wondering if there can be any other explanation. A/C works normal.
View 1 Replies
The subjects say's it all, is there a DIY for bypassing the heater core? I already search i couldn't find it...
View 3 Replies
I have a 2000 F-150 5.4L 4x4. I am currently deployed and my wife has the truck. Just yesterday she told me my heater core went out again the only way she knows this is its the 4th time in just over a year. What would cause a heater core to go out so many times in a short period? What should I have my wife do? I do not want to get rid of my truck and I wont be back for another few months.
View 2 Replies
2005 Ford E Series heater core is "always on"?
That is, coolant always circulate through the core, there is no "valve" that turns it on or off.
The HOT / COLD dial opens and closes a door (vacuum operated) that allow air to enter the heater core area?
View 9 Replies
