Prius (2004-09) :: Check Engine / Triangle And Hybrid Warning Light Came On
May 6, 2015
Possible hybrid battery failure in my 2004 Prius (96K miles).
Sunday before last, the check engine light, warning triangle, and hybrid warning light came on when I started my car at the grocery store.
Because I was close to home, I drove home and the car functioned completely normally. The next morning, when I started the car, the same warning lights appeared. However, when I tried starting my car with the headlights off (I always leave them on), no warning lights appeared.
I took my car to an independent mechanic. This is their written report:
"Found multiple check engine codes, P3000, sub code 123, V0100 sub code 211/330. These codes are set when high voltage control detects a malfunction in battery pack/ECU assembly. To check battery pack we took vehicle out on a test drive while monitoring the cells in the battery pack. Found that they are all weak and drop fast when battery is put under a load. Code C2318 is a low voltage error/power supply malfunction code with the auxiliary battery. The voltage spec for setting the code is 9.3 volts, this battery is less than 9.2 volts."
In conversation, the mechanic also told me there was significant voltage variation across the cells in the hybrid battery.
I then took my car to the dealer to try to confirm this analysis. They were unable to read any codes because the independent shop apparently cleared them. The dealer was unable/unwilling to do more than read the codes to diagnose the problem. (Indeed, they seemed surprised that the independent mechanic could monitor the cells in the pack.) All they did was to drive the car around some more to see if the check engine light would come on. It did not.
The car has been driven 80 miles since the warning lights last appeared and appears to be behaving normally. From your perspective, does the report from the independent mechanic make sense and is it believable? And is their test under load definitive of a hybrid battery problem? Could the results be affected by the low auxiliary battery? Also, if I do have a hybrid battery problem, what are the chances of being suddenly thrown into limp mode while driving it?
View 5 Replies
Advertisement
I have a 2007 prius. I was driving home all a sudden I get a big red triangle warning and the engine logo came on. On the display screen its show a logo of the car at the corner in red with exclamation mark. I use the car obdII scanner but no error code came up. I decide to check the engine oil. When I remove the cap, I notice inside the engine it look weird like a gold color and some blackish. The engine cap inside look like it have stains on it too. The hole where you pour the motor oil down I notice that piece inside don't go down for the funnel to stick in. I attach some pictures. I have no clue what's wrong with it and I don't wanna drive it to make it worse. The prius only have 90k miles on it.
View 19 Replies
I have been using it since last 10 months and was totally in love with this car.. But recently, an error showed up on MFD as well as the engine checklight came on. all this happened after a while, when i started the car one fine the morning..
car stats:
model: 2008
mileage: 123300Km
bought at 92000Km and was trouble free till now..
View 5 Replies
This afternoon, after driving about 150 miles, I came home and shut off my 2001 Prius. It was sitting for about 20 minutes before I turned it back on to drive off. Almost immediately, the hybrid warning light came on on the MFD, the red exclamation mark light illuminated, as well as the check engine light, and the motor shut off. I popped the hood, and could hear a high pitched squeal coming from near the inverter. I called my dealer to ask the service department what I should do, and they just told me to bring it in and they will take a look at it. I live over an hour away, so I don't want to bring it there if I can avoid it. I then shut it off and let it sit for a few hours.
After reading about the possibility of the auxiliary battery being bad, I went and turned the Prius on, and then shut it off several times to reset the hybrid warning light (I had to do so in order to access the aux battery information through the MFD). It turned on without incident, and shut off fine, and after being reset the hybrid warning light shut off, as well as the red triangle light. Then, I went through the process of pulling up the battery voltage information through the MFD.
With the car off, and the lights and fans off, the battery voltage read about 10.0-10.5 V. With the lights and fan on, the voltage dropped to about 9.5 V. After getting those readings, I drove it down the road a little ways, just going about 20 mph. It seemed to work fine. The check engine light is still illuminated. With the motor running, the voltage reading was 13.2 V, and then when I got back from my test drive and shut it off, the voltage hovered at 10.6 V with the lights and fan on.
View 19 Replies
Stopped at ATM when heard a thump under seat and all the above appeared on control panel. Waiting on computer code reader to test vehicle. Any clues to what all this means. Vehicle 2006 with 101K. Recent service as scheduled with coolant and inverter coolant and belt replacement done. No other issues to date with vehicle.
View 13 Replies
My wife and I own a 2006 Toyota Prius that we bought used 2 years ago. a couple of days ago, the master warning light (red triangle exclamation point) and check engine light came on. I took it into the dealer and of course, our hybrid battery was dead - battery and a new ECU required.
Our car is at 99,000 and 32 days out of warranty. Went down the road to atlanta hybrid repair. they were incredibly nice, and said that my computer was fine, but the battery would need to be replaced.
View 20 Replies
A few days ago I was driving my 2005 Prius aggressively up a mountain road and all at once the hybrid system warning light, the triangle with the exclamation point, and the regenerative brake system warning lights came on.
After about 2 minutes parked, I restarted the car and the regenerative brake system warning light went off, but the other two were still on. I still drove it twenty miles home, over another substantial mountain gap (about 1000 ft up and another 1500 down), without any problems.
I checked the voltage of the 12v battery, which seemed to be on the low end, but OK. (I think the lowest reading was 11.9). There seemed also to be some turbulence in the inverter coolant reservoir.
I brought it into the electronic vehicle specialist in town here today, who pulled my codes and said that the hybrid battery was dead.
View 5 Replies
I was driving last night and my car Triangle Warning Light and Check Engine Light Went on along with on the nav screen a car with a ! mark in it came on. On The info screen the battery level was changing fast from fully charged to just about empty. The car lost almost all power going about 42 miles an hour. I was able to pull to the side and i waited 10 minutes then tried to turn the car on again. I was able to drive home and the warning lights were still on but at least my car had power. What could possible be wrong?
View 19 Replies
First off I have a 2010 with about 11,000 miles and it has been running great since I got it. This morning I was greeted with the "Yellow triangle" and the "check hybrid system warning". The car started fine and I pulled out of the garage under battery as usual and then the engine kicked in also as usual, everything seemed normal except for the warning lights. Since I have a long commute I just took my wife's car and got to work and did a forum search on this issue. I called my wife and had her turn the car on and off three times and she said it cleared the yellow triangle and check hybrid system but it still had the check engine light on. She also said the car seemed to be running fine and shes driving around town in it. I couldn't find anything on the check engine light. Is it ok to drive it?
View 3 Replies
My 2005 Prius with 116K on it has been having some uneven acceleration lately and today the Triangle warning light, the check engine light and the brake light came on at the same time. I had about 1/2 mile to go, so I proceeded slowly and called the dealership which had performed a routine oil chg two days ago. They said that if the lights weren't flashing then I could drive it. They recommended that I take it to AUTO ZONE and put it on the analyzer. This elicited these codes: P3019: no definition and P0A80: replace Hybrid Battery.
I have an appointment in 2 days and I'm wondering about a salvage HV battery since the car is 7 yrs old and over 116K miles.
View 4 Replies
I have a problem with my 2002 prius. I was driving home from work when all of a sudden my Hybrid Warning light came on with the check engine light on. On the screen, it gives me a (PS, Battery, and ! ) and the "!" was the one lighting up. The engine was roughing up sounds like it was gonna stop itself so I pulled over to the side and it turned off by itself without me doing anything except to put it on park. Then, i took out my keys and tried restarting it and all i heard was the "Ready" beep but not the engine and it won't move when i step on the pedal. After waiting for 10 mins., i tried restarting it and it worked i drove away and got home safely with all the warning lights i mentioned earlier still on. (Note: i was driving w/ the A/C on because it was hot outside..around 90s, also it was not overheating nor it was any battery problem because all the electrical were working properly.)
View 11 Replies
The last few weeks I've been noticing that, upon start, the hybrid battery is showing at 1 line. It's been really hot in SO cal and the air con has been blasting, so I've been letting it charge up a bit before driving. Once I'm on the road, the battery charges fine and seems to hold a charge.
View 10 Replies
I bought a 2006 Prius. A few days ago the car was driving along just fine when the red triangle appeared together with the 'problem' message followed by the red oil warning displaying in the top left corner of the screen. A few seconds later, the yellow engine light lit up and I drove the remaining mile or so back home (very slowly and carefully). I should point out that the car didn't drive any differently after these warnings appeared and I haven't noticed any strange sounds or anything like that.
I've been out to the car on a few occasions since. It goes into ready mode just fine and drives perfectly in EV mode. The triangle and oil warning reappear shortly after the engine cuts in every time it's started. The hybrid battery charges and discharges on the display when it's left at idle as normal. A friend of mine has a cheap and cheerful diagnostic machine that he brought over and that pulled the P0340 code which relates to the camshaft position sensor. That sensor has been replaced for a brand new one and the fault codes cleared but the code is still showing.
View 9 Replies
My wife has a '03 that has been great. No issues. I am a excellent mechanic, on conventional cars and motors. Here's my story:
Bought the car used and working last week. Put in a new 12v Group 26 battery w/conversion. I verified the 12v battery was at 12.8v and when engine was running, 13.6v to charge the battery. Car was starting and driving wonderful for about 600 miles. No shuttering, no shaky starts. Mileage was about 38.6. Anyway, yesterday was driving and all of a sudden the warning Triangle comes on, Hybrid system icon comes up and the engine goes off. I was able to drive the car about 1/2 mile on the traction battery back to my work.
It happened to have a code reader handy and it reads a P3125, Inverter. I realize there are sub codes that further diagnose the issue, but I don't have that type of OBDII reader although mine is a very expensive model. Anyway, I reset the code and got the car to start. Motor begins to go up in RPM and throws the code again. I shut it off, reset the code, try to start the car and I feel it slightly jump forward, engine does not start, then throws the warning code again. I did notice the traction battery is at 25%. I do this two more times trying to get the engine to start before I call the tow company. BTW, the car rolled easy, so I don't think its the MG2 is bad, although correct me if i'm wrong but doesn't Mg1 start the engine?
Oh, incidentally, also the ignition key does not release either. The key release solenoid is energized unless I unplug the 12v battery, then I can get my key out.
View 19 Replies
During a highway trip three months ago, my 2004 Prius suddenly lost engine power, the red triangle Master Warning light came on accompanied by a warning sound, and then the Hybrid System Warning sign appeared on the Multifunction Display. I pulled off to the side of the road and stopped. I turned the car off and then tried turning it on again. Engine power was restored although the warning lights remained. We took a chance and carried on with our trip. The same sequence of events reoccurred about 10 times on our 1,300 km journey. I took the car to a Toyota dealer where they found a C2318 DTC. They checked the battery and the HEV fuse but could not locate the problem.
We returned home and on the way the same thing happened a few more times. My service manual noted that the description for C2318 is Low Voltage Error (Power Supply Malfunction) and the trouble areas are HEV fuse, IGCT relay, Wire harness or connector, or Auxiliary battery. Since the car was nearly 7 years old I thought I had nothing to lose by replacing the battery, which I did. However, on a short 150 km trip last week the problem appeared again, once while approaching our destination and once when we were almost home. There seems to be a pattern in that the problem appears every 150 km or so of highway driving. It has never done it while driving in the city.
View 19 Replies
This Prius is an '04 with 156k and it will only start with a jump box. I went into the display and found the 12 volt battery reading 12.2 volts after sitting for 4 hours. When driving stop and go around town I will get the red triangle of death and vsc lights but NO check engine light comes on. Using a Scangauge it shows no codes, system ready. I look into pending codes and there is nothing. However when I force clear pending codes the triangle goes away.
It's strange there are no codes associated with this fault. I'm thinking to drive it and not force clear the pending codes and maybe a code will show up eventually but I'm not sure.
View 4 Replies
My beloved 2006 Prius with about 117,000 miles on it needs to go to the shop (I'm not a DIY mechanic). As I was driving home yesterday from work, all of the sudden the red triangle, VSC, check engine and a little car with an exclamation point on it on the display came on about 2 miles from home. There also appeared a kind of wind sound from the passenger rear area when this happened.
I drove it home and pulled into the driveway. Lights, radio, etc all work. I stopped it for about 30 minutes and then started it up again to pull it in the garage (all warning lights still on).
My question is can I drive it safely to my wonderful mechanic's shop about 10-15 miles from my house (assuming it starts)? I don't want to further damage anything.
View 19 Replies
2006, 2G, 43000K. This has happened twice now. Both times on an extended trip of 3+ hours in hot weather: Cruising along at about 70 MPH, the engine just quits. RED Triangle; check engine light; and vcs light. Turned everything off. Car would not restart right away, but after waiting 15 minutes or so, the car restarts and runs fine. All warning lights off except check engine light.
Immediately drove to a Toyota dealership where the following codes were found: P0AOF info 204 (Engine failed to start); and P3190 (poor engine power). The Tech checked the EFI relay; checked for oil puddled in intake; and checked for a contaminated MAF sensor. "No problems found"!
View 7 Replies
I got my oil changed today and thought everything (10 am) was fine with my car. I drove it straight home after the oil change. About 4pm I drove it to work and no problems still. Finally tonight on my way home right as I turned on to my street the car at first seem to hesitate. Slow a bit and I pushed the accelerator. Then suddenly as I pulled in my drive way the engine began to shake as though I was about to stall and the check Engine light came on as well as the big red triangle.
This has happened before. The display being lit up like a christmas tree so but this time the engine shook. I turned the car off, check the oil, which is full and the coolant which is full. The engine has not shook yet ( but I wont leave the car on for a long time to see if it happens again) the Red Triangle has turned off and now only the check engine light remains.
I am going to call Firestone, that is where I got the oil change all I know is that they did a routine check up (unauthorized by me) and told me I needed a new water pump drive belt and tires and a air filter..... So I am hoping they didn't touch something by mistake. I told the man that I would much rather have that done by the dealership.
View 19 Replies
2008 Prius. I just passed by 5K oil change by a 50 miles or so, so my maintenance light was on, but when I was driving it on the expressway today suddenly the red triangle light and check engine light came on, I immediately pulled over onto the shoulder and had it towed. These are the error codes that were showing up:
View 1 Replies
I'm guessing that I need to repair or replace the HV battery. But I'm not sure.
Today I drove for about 20 minutes with no issue. 10 minutes later, I got back in the car to drive again. This time, after about 20 seconds into the drive, a string of dash lights came on; Red triangle, VSC, Check engine.
The VSC light went away. But the red triangle and check engine light are still on. So, I had the trouble codes pulled by a mechanic, and the code P0A80 was returned along with a statement reading 'replace hybrid battery'.
Should I take this at face value? Or look for something else first?
2007 Prius - 150,000 miles
View 5 Replies
