Prius (Gen 2) :: 2006 HV Battery Died - Warning Lights With Code Came On
Aug 17, 2015
Gen II Prius, 151000 miles, HV battery died (rapid charging / discharging, cooling fan on high constantly, etc) Installed remanufactured HV battery. Connect it all back up, test drive, get the triangle of death, VSC, amber (!), and MIL on MFD. Car continues to drive normally until shutdown, upon next startup lights still present and won't shift into D or R only N. Pull codes, POAA6 is showing.
Code doesn't reset with car in ign on (not ready) after 60 seconds, make car ready and shift immediately to N. Code resets after 30 sec. Have done this trouble shooting 4 times and code always resets with ready on and in N. This points to the HV 'leak' being either in the wiring harness or the inverter. What I can do next in order to figure out which one?
View 5 Replies
Advertisement
I have my 2004 Prius in the shop for a replacement of the HV battery pack. The car has approx. 120,00 miles on it.
The battery failed with all the lights, warning symbols etc. I just got a call from the dealership that its going to take longer than expected to get the car back to me. They have the battery pack replacement, but when doing the replacement, they noticed that the cables were "corroded." The cables for the battery need to be replaced before they will complete the repair. But the cables need to be ordered and won't be in soon.
Is this common? for these cables to corrode? Would this problem have caused the HV battery failure?
View 8 Replies
2006 Toyota Prius 93000 miles
On 3/8/13 my Prius would not start. I read some information online and came to the conclusion I needed a new battery.
I started the car, and it immediately started up. I drove it for a very short time and parked it in the garage.
Today I started the car and drove it for about 5 minutes to a restaurant. I did some shopping and about 3 hours later I started the car and A Big Red Triangle appeared along with a yellow circle with an exclamation point in the center and the check engine light.
I immediately drove it to the Toyota Dealer 5 blocks away.
View 3 Replies
Battery died and car (LS 460) was jumped started. Every warning light is on how do I turn them off. Car was running perfectly until battery was drained.
View 3 Replies
I bought a 2006 Prius with a diagnosed bad battery and tons of warning lights lit on the dash. Toyota had diagnosed a bad hybrid batt and ECU. (I have not replaced the ECU). The car was driving and running fine otherwise.
View 12 Replies
I've got a 2006 Prius that was a model car--no problems at all--until it turned 4 years and 1 week old in April 2010. Then my aux battery died on 22 April, with just 31,583 miles on the car, and was replaced at Downtown Toyota in Oakland, CA. My dashboard lighted up after hours, and since my regular mechanic (Art's Automotive) was already closed for the evening, I had it towed to downtown Toyota. No huge deal, except for the cost of the battery/labor. The codes were: C2318, b1421, b1200, b1207, and b1271.
4 weeks later, on 22 May, I pulled into my driveway, and 4 lights came on: the MIL, the VSC, the yellow ! inside the circle, and the Hybrid System Failure icon on the MFD.
View 19 Replies
My master warnIng lIght came on In my car.I took my car into Hooman Toyota in Long Beach, California. They did a diagnostic test and performed their MPI WORLD CLASS INSPECTION. While I was getting it tested they said the invert water pump was under recall. No biggie. Nothing was found in the diagnostic and the recall was fixed.
Two days later I took my car to Palms Springs. While I was driving out there the master warning light came on. I started to lose power but it seemed like the computer would reset and it would be ok for about 15 minutes. I even lost power in the engine. I finally made it out there and figured it just needed to rest. 6 hours later I took off for home. 10 minutes into it the lights on the dashboard came on. The car lost all power and I was stranded off the freeway. My battery was down to 1 bar. I left it there overnight and had it towed to the nearest Toyota dealer. They said I need a new battery and that theirs bad gas. They wanted to replace the fuel tank. I replaced the battery.
The next day they said that wasn't it and was going to continue searching. I ended up towing it to my mechanic. He said there was no coolant and the headers are blown. He said I was better off getting a new engine. Let me take you back two days when that WORLD CLASS MPI INSPECTION was done. There was an 8 page report specifying what was passed on the inspection. The battery, coolant levels along with other fluids passed. Not to mention hoses and clamps and about 30 other things. I feel something was missed in that WORLD CLASS INSPECTION. I feel they are responsible for the car ending up the way it was.
View 19 Replies
My Prius' battery died this week after a respectable 163731 miles. I barely got it to the dealership . It was sluggish, engine racing, one purple bar and the battery fan was going full blast. It totally freaked me out.
21 working days for battery from Japan. I've been expecting it. I figure I can then drive the car for another couple of years.
View 1 Replies
Got the triangle of death after letting the car set during my 2 week vacation. P0A80 and Battery block is 14.17V all the rest above 15.35. That's a lot of money to repair a car. Not sure if I want to cut my losses and move on or replace it and drive as long as I can.
View 19 Replies
Tonight I was driving home and the warning light came on. Thursday I was driving and noticed that the power lurched a few times. I switched over to see the energy usage and noticed that the battery was at the lowest bar. It stayed there for about 10 minutes. I called the dealer and started to head there. As I was talking the bars began to rise. It has seemed fine for the last few days until the lights came on tonight. I had just put gas in it. However, the car seems to run just fine and the traction battery seems to be charging just fine. There was no loss of power. Here in Texas it has been over 100 degrees for many days. I had an oil change at the dealer 10 days ago.
View 4 Replies
I have replaced the Traction battery AND the 12volt battery. I clear all codes by disconnecting the 12 volt battery for a short period of time. I reconnect 12v battery and no warning lights. I drive for 10 miles and RED TRIANGLE, Check Engine and the Brake lights also come on the dash. 2006 Prius 130K miles.
View 16 Replies
I have a 2007 Prius with 92000 miles. All dashboard warning lights lit up the other day. Had it towed to the Toyota dealer and they first replaced the HV ECU. Now they are saying the traction battery needs to be replaced. They have had the car several days but they put me in a free rental.
View 3 Replies
2005 Prius I picked up a few weeks ago decided to eat both of it's batteries for lunch and leave me high and dry. I replaced the aux battery yesterday which I was lucky to get at cost at the toyota dealer since the aux battery was original. Put it in and all was well with the car for the rest of the day. Got in it today and headed out and was welcomed with the big stupid "!" triangle, the regen brake warning, check engine light, "PROBLEM" written on the display with a picture of a "!" inside a car outline, and some severely reduced performance. So I looked online and found a place with a bunch of low mileage batteries out of smashed up 2009's.
View 19 Replies
I have a 2007 Prius. We left for vacation for 2 weeks. Came home. Started the car and then all the lights came home. I thought the battery must have drained. But the lights are all on with a new battery. Is there a way to clear all these?
View 8 Replies
My 2007 Prius suddenly lost power and all lights on the dash board light up. I had a "problem" error as well. Eventually a message came up stating there was a transmission P lock mechanism problem.
Long story short, realized the 12volt was dead and replaced it. However, the car is still not running after replacing the battery. It went once around the block fine, and then the same thing happened with all the lights (check engine, VSC, brake system, and !) and P lock mechanism warning. Disconnected the battery for 15 minutes and tried again. No luck.
View 15 Replies
A year and a half ago, I had the hybrid battery warning lights come on and had it towed to the dealer. After given the option of replacing the battery for $4300, I took it home and did a single cell replacement (all cells ~8V, one at 6.6V which I replaced), which seemed to be all good until yesterday. Back with the warning lights and blower fan, I jumped to the conclusion that I have a similar situation, removed the battery and all cells are 8.04V +/- .05V except for 1 cell at 7.92. I am not convinced that this cell is really the culprit.
View 11 Replies
I had noticed a drop in MPG in the last month (more than normal this time of year), so I started searching on PC. That lead me to testing my 12V battery 4 days ago, with the following results:
No load: 11.8V
Load: 11.5V
Charge: 14.2V
Car started and ran fine, but since the battery is the original on my 2006 with just under 130,000 miles on it, I figured I'd get a new 12V the next time there was a good deal at Advance Auto. No other symptoms until today. After driving around 150 miles on Saturday, the car sat for 3-1/2 days in 25-40 degree temperatures. Started and ran fine today. Did a 5 mile trip, followed by a 1/2 mile trip, followed by a 5 mile trip home.
On the way home, the car lit up like a Christmas tree (appropriate for this time of year). Master warning light, brake system light (yellow; not red), check engine light, VSC light, hybrid system light (no ABS light). Turned it off and restarted and the VSC wasn't lit, but everything else still was.
More info... I finally got around to disabling the back-up beep, and the driver side seat belt warning yesterday, which may have run the 12V down even more.
View 19 Replies
Well all the lights are on for mine as well as of 2 days ago... checked the 12v, was at 11.8v, tested under accessories load (without engine on) and went to 11.4v then tested with the car on and we're at 14.2v
So just to be safe I went ahead and got a NEW 12v and installed it yesterday. All the lights went away immediately. Drove 30 minutes to the town over after the install... fine.... it sat off for about 1 hour.... drove it back home another 30... perfectly fine.
This morning the wife takes it to work, starts the car, all the lights on again... turns it off completely, then turns it back on and all the lights are off and then drove it to work just fine.
View 10 Replies
I own a 2005 Prius with 233K miles. I got the terrible red triangle of death and several other warning lights. Had the codes checked out at Toyota and confirmed a bad HV battery. I am kinda handy and I replaced it myself. No big job, it took about two hours, most of which was spent removing the interior panels, etc. Test drove the car and all looked well. Thirty or so miles later, BAMMM, lots of warning lights. At this point I took it to my mechanic to have it checked out. They found nothing you wouldn't expect when you've disconnected the two batteries.
They cleared the codes and off I went. Again about thirty miles out the lights went on again. Back to the garage once again. What they found was a corroded connector running to the fan, located under the rain gutter of the hatch, passenger side. Hmmm, how'd that get corroded?? Two years ago I remember drain the sump where the spare's located of 6 inches of water, how'd that get in there??? My mechanic confirmed he has seen that before in the Prius. So now I am wondering, did the initial battery fail because the fan may have failed??? Perhaps we need a warning light.....
View 9 Replies
My 2007 Prius with 176k had the warning lights on the dash. I finally got the code read and it is the P0A80 code. The 12 volt battery seems good, it is about a year and a half old or so. That was the only code.
View 10 Replies
Some years back my "farm" '05 prius when a host of bells and whistles went off, cooling fan ran more than normal, and I lost power a couple of times. Turned out this farm prius had an accumulation of dirt, dog hair, hay and other debris that needed to be cleaned out. You got me through the whole process, and the car's run fine until.... . Fast forward a couple of years to 200,003 miles. Now the cooling fan is running pretty constantly, the red triangle stays lit, the check engine light comes on, the (!) is on, and the VSC light is on. Haven't hooked it up to check codes, but did check cooling fan and it's clean. Would it possibly possibly better to change the 12 volt battery?
View 19 Replies
