Santa FE SM (2001-06) :: Burning Electrical Smell And Smoke - Alternator?
Jun 1, 2014
2002 Santa Fe V6
Ran the AC yesterday for the first time after a long cold winter. Seemed fine for about 15 miles but then I came to a stop and all of the sudden smelled burning plastic/electrical... white smoke started blowing out of the vents. Pulled over, popped the hood. The smoke appeared to be coming from the passenger/rear side of the engine.
Drove it another 15 miles home (had to) but with no AC or even fan on... made it and noticed the smell and smoke but only very little.
This morning I started it up .. got under the hood and clearly can smell it coming from the same area. That is the alternator at the back of the engine passenger side right? Voltages read fine... seems to be charging ok as well.
The only indicator that it is going bad is of course the smell and smoke... I can feel it is getting very hot.. too hot to touch after only a few minutes running. Spun bearings in it maybe? Just thought I'd put that out there before I start tearing it apart.
View 9 Replies
Advertisement
I have a 2002 SantaFe, V6 DOHC 4 dr, 117000 miles, that I bought in 2002 with 12000 miles on it. A couple days ago, I smelled an electrical burn smell coming in my interior air vents (no smoke).
From the top rear of the engine, closest to the firewall, was about a 6 inch wide plum of white/gray smoke, just enough to see through. I looked under the car and there wasn't smoke coming out underneath ( no wind that day). No Warning lights, engine light, etc.
I have always taken car of my SantaFe, Bud, regular oils changes, trans oil, air pressure, etc.
Since about 2007, during a couple of oil changes I have been told that there was an oil leak on the top of the engine, probably a gasket. I figured since there were not spots on my drive and it never needed topping off before the next oil chng, I would keep my money for the other bills.
What can cause smoking like this considering where it looks like its coming from? Could it be from more oil pooling over time? Can engine oil smell like "electrical" burning smell?
View 3 Replies
I turned on my AC in my 94 ford f250 and it made a squealing noise then I started to smell smoke or more like electrical burning. I turned off the AC and the squealing and burning stopped. I found that the compressor was the problem and after pulling the pulley and clutch assembly off I found that the coil had melted or got really really hot and smelled lie it had burned. My pulley and surpentine belt were still spinning fine so what happened? My AC had worked fine a few weeks before this.
View 2 Replies
We have a 2015 Santa Fe Sport AWD (without turbo). It has about 4,200 miles on it. Recently my wife complained about a burning smell that she hadn't noticed previously.
I drove it and noticed the smell. Pulled into our garage and left the engine running and noticed a minor, but noticeable amount of smoke coming out from the hood on the passenger side. When I opened the hood it appeared the smoke was coming from the lower, back side of the engine.
I later went out and started the car and let it idle for a bit. Didn't notice any burning smell or smoke. Later drove it again and noticed the smell and a little smoke. So it seems like it occurs when the car has been driven rather than simply started and not driven.
View 9 Replies
I have a 2001 Pathfinder w/ ~190K mile on it. It has been used regularly until this past winter. It has been sitting for about 3.5 months and I'm just now getting it back on the road. The battery has been draining due to non-use but I charge it and the car will start. Today I started it and after running for about 2 minutes the engine quit. When I got in the car I noticed the strong smell of electrical burning but no smoke. I did not notice this outside of the car. Upon trying to restart the car the engine just cranks with no sign of trying to start (as if there's no spark). I suspect something (probably electrical) has failed while it was idling but what it could be.
View 8 Replies
Resurrecting this 2001 2.7l, I noticed the horrible gas mileage.
I'm thinking o2 sensor, but it doesn't throw a code... Anywhere else I should look? I've changed Crank Position Sensor, Fuel Pressure Regulator, plugs, and brakes.
One note, when the a/c is turned on, I can smell a burning kinda smell. Maybe the clutch on the compressor is going out, causing some parasitic type of power loss? idk. Car seems pretty peppy now that it has a new CPS.
View 9 Replies
I was driving around running errands when my AC stopped blowing cool air, a funny kind of "metallic" burning smell was coming from the engine, and there was a slight knocking noise that was apparently coming from the engine and would go faster as I accelerated.
My car is still under warranty so I know stuff will be covered. My question is : what the heck is going on with my Santa Fe? I need to know whether I should call into work or drive it anyways.
View 1 Replies
Vehicle:
01 Santa Fe LX 2.7 AWD w/112k miles
Symptoms:
- Slow Start (when cranking takes 2 full seconds before it will turn over and you can hear the engine cranking slower, use to turn over right away)
- Very Strong Burning Rubber Smell
History:
Last January it got down to -20 here in Albuquerque and I would have to go to work at that time. About a week later (when it was still getting down to about 0) I was driving home from work when I smelled a slight smell of burning rubber. I thought it was the car in front of me. The next day I had the same thing. It continued for about a month till the temps rose a bit and then went away. I could never find the cause. I then went all spring, summer, and fall without any problems on my Santa Fe.
As the temps begun to drop over the past 6 weeks we started to smell the burning rubber again, at first only when I would start the car till it warmed up. About 2 weeks ago the car started cranking slower and would take longer to turn over and within the past week I can smell the burning rubber smell even when I had the engine at temp. There's not any idiot lights on. The car is running fine except for what was mentioned, gets up to temp and stays there (a little below the middle on the gauge like normal). I pop the hood and looked at the belt, looked good (no cracks). Checked all the fluids and the only thing that's low is the coolant.
View 4 Replies
Well, I have the dreaded transfer case leak on my 112000 mile 03 2.7 santa fe. I have just returned from a 12,000 mile trip through Canada, Alaska and then back to Colorado. During that trip I was smelling a burning oil smell and after I came back I traced it to the transfer case. I think it is leaking both from where it mates to the drive train and a one inch seam along the transfer case plate.
It has leaked there for some time(and I had been diligent about filling it up), but this extended trip it has has been more bothersome. I called the local Hyundai shop and they want $1100 and won't guarantee a fix. Is there some product I could use on that one inch seam externally to stop the leak (I know that wouldn't seal the circular seam around the drive shaft)? I kept very accurate gas records and averaged 25.6 MPG for the whole 12k trip running from 55 to 65 MPH.
View 20 Replies
I have a 99 B5 v6 Passat TIP. Was doing a lot of driving around today, in & out of stores. Last store of the day go get in the Passat and now it wont start. I did smell a brief electrical burn but was unable to locate the source.
When I try & start the car nothing happens, no crank. The windows locks radio all function.
I am able to lock the car and unlock the car with the key in the door. The alarm arms & disarms without issue.
I have checked the fuses as well as the relays and they seem fine. I have replaced the ignition switch and still the same issue.
I have tried starting the car in neutral as well and no luck there either.
What is the best way to test the switch to make sure my new one isnt bad. Any way to use a jumper wire to attempt to start the car?
View 2 Replies
Today, when I returned to my parked car from grocery shopping, I noticed a strong interior electrical burning smell. Like wires burning or similar. When starting the car the yellow warning triangle came on and the hybrid warning message to pull over and park the car. What could cause this? Want to mentioned today was a very hot day 105. Up until today the car drove flawless.
View 12 Replies
So I had been smelling an electrical/rubber burning smell on the Ex about a month ago. After a week or so I popped the hood and poked around. This is what I found!
Now I had a no start in May. The shop that I had it towed to checked the wiring harness, replaced the cam sensor, scratched the truck up and ran through 2 tanks of fuel.
I repaired the harness and all is good. What the 3 wires run/go to.
One was solid Gray with a white stripe.
One was solid Black with a yellow stripe.
One was Tan with a green strip.
View 10 Replies
I recently noticed that my car was starting to smell like oil burning off. Soon i realized that from time to time there would be a bit of smoke form under the hood I looked under the car and noticed that oil is dripping onto the cat but i am not sure from where. There is not alot of room in the back of these engines to see.
View 3 Replies
I don't know much about cars. I have a 99 Mercedes e-320 and I started smelling a burning, but when I opened the hood, there wasn't any smoke. What could it be and is it still safe to drive?
View 7 Replies
Took about a 200 mile trip this weekend, stopped at a rest area about halfway through and smelled burnt carbon, smelled like a burnt clutch almost. It was very strong and there was smoke coming from the engine. It wasn't a lot but it was cause for concern. I checked the oil, last oil change about 1500 miles ago but no problems there, temp gauge was in the middle. Let the car sit for a 10 mins or so and then headed of again. When I got home that night, couldn't smell it and there was no smoke. Car has 42K ... Also, I got an airbag fault light about 30 mins from my house.
View 8 Replies
So yesterday I was on my way home from work, and I had smelled a little burning and then I saw smoke from the steering column???? i pulled over and it had stopped no lights came up? the car is fine now..? I don't know whats going on?
View 4 Replies
So I took off today and my friend behind me in his ford ranger was telling me my car smelled like ish, and there was a lof of black smoke coming out my exhaust.....
View 1 Replies
Today was the first day I notice smoke from the wheel well, it wasn't heavy smoke but enough to caught my eye. The past few days I been smelling burning oil from that side of the car. I am not leaking oil from the motor because I check it everyday. Why it would smell and be smoking from the wheel well?
View 3 Replies
So I was sitting in my car, running, parked with the ac on and out of no where I got an electrical/burning smell coming from the vents. My volts were reading 12 with ac on at idle but once my rpms reach about 7-800 it goes back to 14. My question is what was that smell? I've had 2 alternators go on this car (power draining aftermarket accessories 3.3 v6) and have driven the car for about 2 hours collective time since the problem started (usually alternator goes quick) and haven't noticed any lights dimming, ac blows cold, system still plays full tilt. could a bad compressor be causing putting some stress on the car?
View 8 Replies
I can smell burning oil and when stopped see oil smoke coming from the right front area. Theres absolutely no fluid on the ground ever even after sitting for days. I cant visually see any oil leak on the engine but I cant see the back. Im guessing its a valve cover leaking just enough on top of the exhaust on that side. Ive seen the gasket/plug seal set from $25 to $80. Some include the timing chain area gaskets/seals. Is that necessary to change at same time? Also, is there a gasket where the intake manifold and valve cover meet needing changed along with?
2004 Passat 2.8l V6 GLX
View 5 Replies
Yesterday I made a 3 hour round trip with my car, and on the last leg coming back into town, I noticed my check engine light came on, and I saw white smoke coming from underneath the hood of my car, along with a burning smell. Luckily I was able to make it home just fine. I've googled this issue, some people have suggested coolant leak.
Also, I checked the oil levels today and they appeared to be slightly below the lowest level tick, which could be why it was having issues yesterday. Last time I got an oil change was November of 2015. I'm surprised it's this low considering I normally don't commute farther than a couple miles each day.
View 4 Replies
