Santa FE SM (2001-06) :: Impossible To Put Back Blower Motor
Aug 18, 2012
2005 Santa Fe - 3.5L w/ Auto a/c controls (it matters for price on the resistor. boo!)
I find myself having a really hard time sliding the motor back in. It was difficult to pull out before and now it's nearly impossible to put back in.
The Fan wheel measures 5 3/4"
I believe the issue has to do with prefab installation and a very large wheel causing this to be too difficult to push in at an angle.
I see different dimensions for fan wheels and I'm thinking that may be the key.
I already have to replace the blower motor.
View 3 Replies
Advertisement
Today i had my ac running and switched the speed from 3 down to 1, then poof totally went off and will not come back on at all. I tried replacing the resistor, still nothing. Next tried the blower motor, still nothing. Then replaced all the fuses, still nothing. The compressor is kicking on. Can here the click under the passengers side when turning ac on, but the blower motor is not coming on.
View 1 Replies
I have an 02 Santa Fe and last night while driving the fan would not turn off. It also started switching speed by itself.
View 2 Replies
How hard is it to change the A/C/Heater blower motor. I know about the switch problems but this is the blower motor. I'll probably clean it out and spray something in it before I replace it but I just wondered how hard it is to get to. On another note, this 4 wheel drive Santa Fe rocks in the snow! I can't believe what good traction it has!
View 3 Replies
I have an 04 Hyundai Santa Fe 3.5L V6 AWD with climate control. All other trucks this year I've only seen with manual HVAC controls. My blower motor is constantly running anytime the key is turned on. It feels like it is blowing 3/4 strong all the time and I can turn it up, what feels like one setting higher. Even if the climate control is turned off it keeps blowing. I can control the temp and AC and defroster, I just cannot control the actual airflow pressure from the vents. On an older car this seems like a resistor issue. Is this a common issue? If so, what can I do to try to rectify this?
View 4 Replies
I replaced blower switch last year a couple of years ago. I recently starting to get clicking noise from blower relay, and fan turns off then comes back on.
Question:
1- Problem more likely to be from the relay or the fan switch? Should I just replace the relay?
2- I can see and touch the fan relay, but how do I get to it to replace it? What dis-assembly is required?
View 1 Replies
2005 Jetta.
I had the AC on and after an hour or so the fan made this dieing noise and crapped out. I shut it off and turned it back on and almost no air came out - even when the AC was not engaged - it just made a weak whining noise.
10 min later I turned it back on and it worked fine, then did the same thing 20 min later. This cycle keeps happening now, what could be causing it? (The compressor is brand new, just had it replaced a week ago, so I don't think it's that).
View 4 Replies
12 Santa Fe, I decided I better give it the once over. I found the cabin air filter was pretty bad and that surprised me because I don't drive in dusty areas etc and usually don't drive much at all any more since I got a company car but anyway....to the question: AFTER I changed the filter, making sure the airflow arrow was correct, I noticed that the blower motor is much noisier than before especially when set on the higher fan speeds. The sound is much like a off balance fan with a bit of a thump to it. Could I have dropped some of the dead bugs into the fan when I changed the filter? I was careful and didn't see anything fall into the fan area but the noise is annoying as heck. Is this something that would be covered under Hyundai's warranty? Headed to the Florida Keys Saturday and not looking forward to hearing that racket all the way down there.
View 3 Replies
I have a 2001 GMC Jimmy and I am having an issue with the blower motor. Speeds 1 and 2 do not seem to work. Speeds 3 and 4 work fine. This is the manual climate control not the automatic. I searched and it seems everyone usually has a problem with the high speeds & not the low speeds...
View 9 Replies
Like the title says; I have a 2001 F350 with No blower Motor and Just Defrost, it is actually a friends, he is building a fence, and I am looking into the truck problem. The just defrost is probably a vacuum issue, but I do not have any book for this truck, so I have no vacuum or wiring diagrams. As far as the blower motor, I am thinking switch or motor, fuse has been checked? Is there any other "control" box involved with this year/model? Also any dash tear-out instructions, to make the access easier?
View 1 Replies
2001 f350 blower motor for (A/C - Heater) works sometimes and sometimes does not.
View 5 Replies
I replaced the blower relay around this time last year. I noticed this morning idling that the vents weren't blowing then when i was moving i heard it tick back on and would blow normally. This happens when driving too but more noticeable when idling. The AC light also flickers and goes on/off.
I can go ahead and replace it again but this seems to have gone through this brand new relay pretty fast. What I can fix to stop going through relays?
View 8 Replies
I have strange issue with my a/c fan, its running continues even will the a/c switch is off.
I cant stop it. So I have to remove the fuse to stop it. My ac panel is automatic.
View 2 Replies
How to remove center panel in order to replace faulty blower switch?
View 1 Replies
Blower only works on high speed. From what I have read the problem is either the switch or the motor resistor. I am leaning toward the resistor which is behind the glove box. Where can I find directions for removing the Glove box?
View 1 Replies
I have a 2005 Hyundai Santa Fe 3.5 litre 4wd and am having a crazy problem. It has the automatic heating and air conditioning module (digital). The heater fan comes on as soon as i start the engine and runs in the 2nd highest speed. I can adjust it so it goes one speed higher but never lower than the one it comes on at and cannot shut it off. It operates the same under heat OR A/C modes. The temperatures adjust o.k. but it is always on. Where would i find the a/c control module? Could it be the transistor or resistor and where are they located?
View 2 Replies
I just purchased a 2006 Santa Fe Limited with the 3.5l for a great deal. It has a huge coolant leak though that needs fixed. It is coming from the top of the motor on the left side by the timing belt. It is really a small flood, when you fill the coolant and turn on the motor it runs across the top of the motor toward the drivers side. There isn't oil in the coolant and it doesn't smoke. I had it dropped off at my mechanic though. Does the motor really need pulled in these to do the head? I heard that there is a overflow channel from the water pump that comes out right about there as well. Could that maybe be it? Any other options if it is the head gasket to reduce the cost any?
View 17 Replies
I have had the Santa Fe back and forth to the garage no power. We where driving it and all a sudden dropped power can't rev motor over 3000 rpm. Garage said they fixed it with dry gas and more gasoline b/c it was "low" between 1/4 and empty?
View 12 Replies
I have a 2002 santa fe 2.7. I just had the transmission rebuilt and since then have noticed a clunking sound when I shift into drive or reverse. It seems to be the lower motor mount is making noise from the motor moving the mount. I look at the mount and it appears to look good, but was wondering how I can really tell if a motor mount needs replacing or not.
View 3 Replies
I have a 2001 Santa Fe 2.7l automatic. I recently changed out the automatic transmission (transaxle) as the old one had died. Now the starter motor plunger is not disengaging quick enough on start up and a screaming noise is made as flywheel turns as engine first turns over. I have just put a new starter motor in with exactly the same (screaming) result. The flywheel looks to be in reasonable condition as I inspected it when being put in, no teeth mangled and all teeth there. The transmission replacement was from a wrecked vehicle, I was told from same model vehicle but maybe a 2003 Santa Fe.
View 1 Replies
I have an 03 Santa Fe, 2.7 l AWD. Recently I've begun to notice a whining almost electric motor like sound coming from the rear of the engine. It get more noticeable the longer the trip. The weird thing is that it seems to respond to throttle input more than speed. If I'm cruising at say 65 I can ease off the throttle, reapply the throttle enough to increase RPM but not speed and hear it. I've had the differential, brakes, bearings checked. My mechanic has had it in the air 4 times and has spent atleast 4 hours on two occasions trying to find it. He can hear it. My thoughts are that it could be the Fuel Pump, or the exhaust.
View 11 Replies
