Subaru - Forester :: 2001 - Burning Oil Smell After Replacing Head Gasket
Feb 5, 2014
Had the head gasket replaced and metal machined due to HG failure. 2001 Forester, 120K miles. After I got it back, a bad oil smell. Cleaned and sprayed it, still there, though less; seems to be on drivers side. Comes into cabin from the air vents below windshield when stopped.
Could it be the line from manifold vacuum to brake master cylinder ie servo amplifier? Or something else?Should I worry? The car seems to get about 15 mpg, used to get 18 mpg, and the check engine MIL is on.
View 1 Replies
Advertisement
I got a 98 Subi Forester L, stick, 130k mi.
I've been thinking about what gs ragtop & tester mentioned about the silicate stuff and I'm ready to take the chance, but there's one thing bothering me: If that stuff is supposed to be drawn into the combustion chamber where the silicate comes in contact with the super hot temps that solidify it, thereby sealing the leak, that assumes coolant is going into the combustion chamber, right? Well, I've been driving this car with a blown hg for at least 2yrs maybe 3, (that in itself amazes me), and I've never seen any sign of coolant in the exhaust, no smoke, nor any rough starting issues to speak of.
So, my question is simply, HOW THE HECK DOES THAT HAPPEN!! How in the world can I lift the hood and watch exhaust gases bubbling up in the radiator, yet when I park on a hot, 95 degree August day with a fully pressurized cooling system, the next time it's started there is no sign of coolant. The physics of that defy me! I mean, it says that the head gasket magically blew a "one-way" valve in itself? What do you think? Am I missing something?
View 19 Replies
I have a 1998 Subaru Forester that is leaking oil through the head gasket. Repairs for the head gasket seem to be in high range, which is at or above the value of the car. Is trying any of the head gasket sealant products such as Blue Devil worth trying? Do they have the potential to do more damage than good? I love the car, but I'm also not sure if it is worth getting if fixed or if I should be looking to sell it for parts and buy a different used car.
View 15 Replies
I have a 2007 Subaru Forester X Sport Model. I just passed 86,000 miles - much of that open road driving. My head gaskets need to be replaced. This seems somewhat early. I recently switched from using regular motor oil to a synthetic blend that the dealership suggested. Is there any history suggesting that switching lubricants might cause the head gaskets to deteriorate?
View 10 Replies
I have a 2006 Subaru Forester (auto trans) with 97,000 miles on it. It's behaving badly, and here are its symptoms:1. It is getting worse gas mileage now than it has in the past 5 years I've owned it. Up until the last few months, I've been able to get about 26 mpg on average. Since Sept. or Oct., I've only been getting about 21 mpg.2. It shifts rough on a cold start when it shifts into 3rd and/or 4th. No rough shifting is noticed when the car is started on a moderate or warm day (roughly 35 degrees outside or warmer).3. When doing mountain driving (specifically u to a hill at highway speeds that is about 10 miles long and a sustained 7%-10% grade), the engine temp rises to about 2/3 according to the gauge on the dash. (Under normal driving conditions it sits at about 1/3.)
I took the car to my mechanic and here's what they said:
1. The gas mileage on Subaru Foresters frequently isn't much higher than 22 mpg, so for the first 5 years, I owned the car I was just lucky.
2. The fluids need to be flushed and changed: differential, transmission, etc. - approximate cost $400
3. He's almost certain that the cause of the 3rd problem is blown head gaskets, and the cost of that is about $3000.
If the head gaskets are truly the culprit, is it a repair that needs immediate attention or is it something I can delay for a while?
View 8 Replies
My mechanic told me that the burning smell I've been getting in my '02 Forester when I'm idling is a leaking head gasket. It seems to be a slow oil leak. If I keep an eye on my oil level can I continue to drive the car without doing further damage or having to worry about breaking down?
View 4 Replies
I have a 2004 Turbo Forester. It's been maintained since purchased new at the same dealer with oil changes every 3500 miles or so and all the "big" required/recommended maintenance every 15000 miles. After the 75000 mile check, I kept smelling a burning oil smell, especially when car was idling. I had it back to the dealer several times but they couldn't find anything wrong. The car did not seem to be using excess oil, there were no "puddles" under the car where it was parked. Today I brought the car in for routine oil change (78400 miles). On the way in, started smelling the burning smell again and saw smoke around the turbo charger.
The mechanic saw "Moisture" (oil?) around a lower bolt on the heat shield around the turbo charger. He said it was likely a failing turbo charger causing oil to leak on making that bolt wet? The engine is not making any noise, nor is the turbocharger, and there was no "check engine light" illuminated. I'm scared now to take the care elsewhere for a second opinion...don't really want to drive it and trash the engine. It's out of warranty now, and this is a painfully expensive fix that couldn't have come at a worse time on a car that's been maintained "by the book". I'm reading a lot about this "banjo bolt screen" problem. Would that be something to find out about on a 2004 Forester? Is there anything else that could be causing the problem (mechanic couldn't think of anything).
View 10 Replies
I have a 1990 legacy and just replaced the water pump gasket and now it is leaking out of an upper bolt head on the pump and how to cure this....
View 1 Replies
While waiting at a stop light my car totally died, there were no warning lights, the car is a 2011 Subaru forester with 52,000 km. I had it pushed off the road, tried to restart it with jump cables but it would not turn over. I noticed an odd burning smell when I opened the hood. There were rat tracks on top of the engine area. I had the battery pulled out and replaced with another fully charged but it did not make a difference.
After sitting for two days, I restarted the car and the engine managed to turn over but very very rough, a mechanic thought there was something loose in the engine. I currently live in Mexico and closest subaru dealership is 5 hours away. I will need to get it towed there but I would like to have some idea of what it may be, my thought is somehow a wire got chewed off but I had driven it about 20 miles that morning and then it just stopped dead.
View 3 Replies
I recently moved to Pittsburgh where I constantly use my parking brake from Rochester, NY where I rarely ever used it. After I've moved to Pittsburgh (7 months after I've owned this 2004 Subaru Forester). After I drive for a significant amount of time (30+ minutes) and come off the freeway and stop or even slow down, the cabin of the car has a distinct, but faint burning smell. I am wondering if this could be the parking brake rubbing just slightly and when I slow down the smell stays in the cabin or if it is possible that the brakes are smelling (or something entirely different). Keep in mind that the smell doesn't happen when I only take a short drive, which is often. And of course, no I haven't taken this into an auto mechanic yet.
View 9 Replies
So I've replaced my head gasket on my 5SFE. But after putting my car back together, my car didn't want start. This is how it sounds like (click on the video to watch it).
So I suspected that my timing was off, so I took off the valve cover to check the timing marks on the camshafts. So the two timing punches lined up like so (I only took picture of one of them)
Though I'm not too sure what the two dots mean on the exhaust camshaft since there are not two similar dots on the intake camshaft.
So I'll assume that I have my camshafts lined up properly But how do I know that it is in time with the pistons?
Could it be the distributor? I am not too sure if I installed it correctly, but I did follow instructions in the Chilton manual.
On the other end, there were two vacuum lines that I'm not sure if I installed correctly. I'm positive that the left two pipes are correct; however, I'm not too sure about the two on the right. This is mounted on the cylinder head.
View 10 Replies
Recently the timing belt slipped and in turn shot several valves. After replacing the head and gaskets there is a small oil leak between the head and block. Can i tighten that head bolt a little? What is the best solution?
View 1 Replies
I've never replaced a car stereo and have no clue what to look for as far as compatibility goes. My '09 Forester has a am/fm/sat. radio hookup/ 6 cd changer. Do I have to look for a specific stereo head other than it being a 2-DIN?
I'd like to be able to continue using the aux port that is in my center console, and I would like a USB port that I can plug a Galaxy S4 into.
View 7 Replies
My Subaru dealer just told me that my 2004 outback with 88k miles has developed a head gasket leak. I haven't noticed any symptoms, and the leak started sometime between now and my last major service 10k miles ago. How serious is this? They want to charge me for it? If so, when? Is disaster imminent?
View 7 Replies
A family member has a 2002 Subaru Outback. Possible blown head gasket per dealership. Should we just get rid of it or fix it? I feel the car had problems when we bought it a couple years ago due to dishonest salesperson. I hate to keep putting money into it. It seems to use a lot of oil also. Fix it then sell? Or just get rid of it?
View 6 Replies
I recently had an issue with my head gasket. It was repaired but then learned the real issue was that I had diesel gas in my engine. (Long story, fuel hauler put wrong gas in tank and service station sold the gas to us unsuspecting drivers.) After head gasket was fixed, tried to leave service shop but car still had issues - turned around and went back. O2 sensor and other fuel trim numbers were off. But couldn't diagnose problem completely so told me to drive home (30 miles) and come back next day.
That's when I found out about the diesel gas issue. My car got drained of bad gas and cleaned. Got car back but now is leaking oil. My husband thinks it is either from the valve covers or from head gasket. Can diesel gas in your engine damage the head gasket? Could I have done more damage by driving the 30 miles home with the bad gas? Or did the shop just do a bad head gasket repair? I only bought this car 6 months ago - used. It now has 88K miles.
View 6 Replies
my friends mechanic is telling him his 2000 outback (2.5 4 cyl) has a blown head gasket. there is NO water leaking/seeping out from anywhere outside the motor AND there is NO water in the crankcase motor oil. the thermostat has been replaced. the cooling fans work. I'm inclined to say it's a plugged radiator. he is considering replacing the head gasket (to the tune of $1500+) on advice of his mechanic. is it possible to have a blown head gasket and not be leaking coolant?
View 10 Replies
I bought this Subaru outback with 100,000 miles- clean car fax, etc, did the timing belt, water pump, thermostat at 102,000. Now at 116,000, the head gasket is leaking ($2,200 estimate) so the repair shop is working on that and they called today to say the #2 cylinder is scored and the engine needs to be rebuilt. ($4,000 estimate). I'm not sure if I should have them proceed with he work- that's a bunch of money or look for another engine, or what to do !! Its a great little car- but geez- what to do-
View 5 Replies
2000 Subaru Outback. The head gaskets have begun to leak slightly (oil and coolant), even though I brought it in for the recall at 80K and the dealer put in the additive. I recently (111,000 miles) put in another bottle of the additive coolant conditioner and the leak seems to have at least slowed to a trickle. Is it really essential to have the head gaskets replaced? Or could I just keep an eye on the oil and coolant levels and put a bit of kitty litter in my garage? Some of the information I googled indicates that the recall of this car is for an OUT leak and not an INNER leak--which would be worse. Is it true that an OUT leak is not as worrisome?
View 5 Replies
I brought my Outback to one mechanic due to overheating and a strange skipping feeling when accelerating. First mechanic said head gaskets needed to be replaced, I wasn't surprised since I have about 142k miles on it and it has been leaking oil, quoted between $1800 and $2000. I took it to another shop, recommended by a friend, and they agreed the gaskets needed to be replaced and there was also a misfire due to the spark plugs. This shop quoted me at $2200-2600 for the head gaskets, spark plugs, all wires and timing belt, all other engine gaskets, thermostat, engine oil and coolant. I still owe a good bit on this car (parents bought on the fly from a less than stellar used lot and now it is my problem), and my thinking is I do not want to bring on more debt by attempting to trade this one in and go for a new car. My question is, do I go with the second mechanic that wants to basically rebuild to top of my engine, or would I be ok limiting the repairs to the head gaskets and spark plugs?
View 11 Replies
My 2004 Subaru Outback has had the head gasket replaced, the O2 sensor replaced, spark plugs replaced. Still I cannot go up big hills anywhere near the speed limit. I think it may be the catalytic converter is bad from driving it with a leaky head gasket.
View 5 Replies
