I have a 2002 Echo with 185K miles on it and i have a 2003 Echo with 101K miles on it, Both have P0446 P0440 P0441 codes coming up on them, the 2002 I replaced the gas cap, VSV valve and the rubber hoses from the throttlebody to the hard plastic line in the engine bay, and the 2003 I only replaced the rubber lines in the engine bay.
View 14 RepliesI recently picked up a 2001 Prius to learn more about it. I've been trying to resolve the following codes: p0440, p0441, p0446. I used a new OEM gas cap & did a smoke test and smoke is coming out of the perimeter of the filler mouth and what seems to be a plastic ring with slots around the mouth.
My question is this:
1. Is this normal?
2. Does this indicate that the filler neck is bad?
3. Does this indicate that the charcoal canister is bad?
4. A bad VSV by charcoal canister?
5. Is it something else?
2003 Camry LE, 4 cyl, 165k miles – Got all of the above codes. Obviously checked gas cap and no issues there. Checked both VSV underhood and had clicking. Checked VSV at canister under vehicle and no clicking. Used a Dremel oscillating tool with flat metal blade to cut off rusted Philips head screw. Removed VSV and checked by jumpering to battery. No clicking, but did draw a tiny arc. That told me it was “trying” to actuate. Sprayed PB Blaster into hose fittings of VSV and mowed the lawn. Came back to VSV and it now actuated – but very slowly and delayed. Sprayed electrical contact cleaner in hose fittings with the VSV jumpered and open. Activated VSV several times and sprayed contact cleaner through the hose fittings several times – both directions. VSV began to active quickly. Put VSV back on vehicle. SES light went out by itself after it ran the EVAP test.
View 3 RepliesI have a 2000 Toyota Camry with 90,300 miles. Last week check engine light came on and mechanic said it was P0440 and charcoal canister needed replacement. Did the repairs and 20 miles and two days later CEL is on again. Take it back to mechanic and codes this time are P0441 and P0446. I'm told I need a new gas cap, so it's replaced with new one from dealer. 15 miles later, CEL comes back on and I return to mechanic. This time it's reading all three codes, but they can't find anything wrong. The only parts not replaced are the vacuum seal valves, which mechanic says test as good. They reset lights and 15 miles later, the check engine light is back on. My mechanic is baffled. What the problem could be or what they should check? Car drives fine, but light coming on is annoying.
View 16 RepliesI have a 130K+ 2002 SC430 in which I recently started to smell gas in the cabin when air vents were set to pull air from outside. Within two weeks, I got the check engine light with two codes, P0440 and P0446, which mean "Evap Emission Control System Malfunction".
In doing some research the check light light could be everything from a gas cap which is not tighened properly, to a bad "charcoal canister " (whatever exactly that is), to a cracked or disconnected "Evap Hose". The only other SC430 related thread I could find on this topic is [URL] ....
If it factors in, I only use 93 octane gas. Interestingly enough, the check engine light came on within 30 seconds of me using the window washer to clean the windshield (at highway speeds), likely a coincidence.
I recently had detected always misfire on those cylinders. Any relation between them?
View 1 RepliesBack in September '12, I was on the freeway and merging quickly into the fastlane/passing lane on the freeway-- third gear, near 80mph. Going for fourth gear was a brief misshift into second that apparently happens often with cars with the 1NZ-FE.
Because of that over-rev, I've since had an annoying tick that goes with the engine revs. It's been going strong regardless for over 10,000 miles, but it's frustrating nonetheless. Compression seems fine on all cylinders, and according to a shop I'm not primed to believe, the shims for the valves are fine and these engines "always sound like that." My video begs to differ.
For those who've maybe had the same sound, what's your take? I've heard of stretched timing chains/chain slack, water pump, clutch issues, etc., but want to narrow it down.
You get the contrast here, and toward the end I nearly over-lap the shots to hear them closer together. [URL] ....
Under the hood/car. [URL] ....
I've got error P0440 on my 2001 Echo about a week ago and cleared it, then I got it again today. It happened while driving, I was switching from 4th to 5th and the check engine lit up.
View 3 RepliesThe check engine light has been going on and off for a couple of months. I took it in to be looked at and the mechanic said they couldn't get a code, couldn't get a "good read" on what was wrong. They said I could take the car back (but they couldn't give me an inspection sticker) and drive it for a couple of days and if the light comes on, take it back to them. If the light doesn't come on after a few days, they will give me the sticker. I can't believe my car is going to act any differently than it has for the last few months -- light comes on sometimes, sometimes it doesn't. Shouldn't the mechanic be able to tell what's wrong.
have a 2005 Scion with about 60,000 miles.
Every time i put the key in the on position, the check engine light comes on, but not anymore and it wont start, wont make a clicking. Nothing What relay or fuse would this be.
View 3 RepliesIn January I had taken my car in for an oil change. About a Month later my check engine light comes on. I pull over and there is no oil cap. Why the light hadn't come on before then is beyond me. I also park on grass so didnt notice it. I took it to advanced auto to see what the code for the light was and it said that the engine was running lean. Is this connected? and if so how? I am driving a 2008 Toyota Yaris Hatchback
View 1 RepliesEarlier today, while waiting at a red light, the engine on my 2001 Echo stalled. It has automatic transmission, so it wasn't me manhandling the clutch...
I started the engine, and as soon as the A/C tried to engage, it stalled again. I turned the A/C off, restarted the car and moved on.
When I got home I tested again, and the engine stalls when I try to turn on the A/C. If the car is moving when I push the A/C button the engine coughs and the car buckles.
It sounds like the compressor is seized. How common is this? I've never had this happen before in any car.
It's a 2001 Echo with 205,000 miles (trouble free I might add, other than consumables I never had to fix anything).
I am looking to troubleshoot the problem I am having with my 2000 Toyota Echo Automatic with 253,000 Kms
Engine will at times bog down, loose power and skip, usually giving it more gas will straighten it out. Car is now stalling after driving and stopping unless you rev the rpms higher. The car will start in my driveway and idle with no problems however sometimes it will skip after a few minutes.
Codes I keep getting is P0171 Fuel too lean bank 1 and P0301 cylinder 1 misfire (for cylinder 3 before we cleared the codes)
Here is what I have done as I am lucky enough to have a 2000 Echo so we could switch some parts for testing:
Switched the coils, spark plugs and MAF sensor (didn't look dirty) What concerns us is when you unplug coil 1 from the engine there is no change in the idle (as there is a difference when unplugging the other coils)
We have checked for vacuum leaks but cannot find any.
Should also mention the engine is not overheating or burning oil.
I have a toyota yaris d4d (2002). My engine light comes on, I lose power on throttle but engine will still idle. I turn engine off for a few minutes, then restart, I then carry on driving as normal as if nothing has happened. This happens every 2 weeks. Error code is p1121(accelerator pedal position sensor range/performance problem). How to rectify it ...
View 1 RepliesI have a 2002 echo 1.3 vvti - will it has been running great and has 200000km on clock . However today i started it it ran for about 1 min then i heard a beeping from under the bonnet, the engine then stopped. The car will start and run for less than a sec then die. will not run no matter how much i play with the throttle .
View 2 RepliesI am buying a Toyota Echo that the engine shakes on Idle and the shaking increase a bit when the AC is On ....
View 2 RepliesI have a 2007 Yaris, 180,000 miles, The check engine light comes on. With a P0011 code. I know that that could mean either:
blocked oil passage
Mechanical timing fault
Camshaft position a timing over advance
Failed OCV
Or VVT controller assembly fault
Since it's been really cold out I figured maybe it was a blocked oil passage, but after an oil change and quick check - I no longer think that's the problem.
The car runs great and it doesn't seem anything is wrong at all ...
2001 Echo. I have a squeaky belt that gets louder when the engine fan goes on. What drives that fan and causes the noise?
View 3 RepliesI would like to do a coolant flush so finding the engine drain plug would be nice. Where it is or if there's a pic of it somewhere?
View 2 RepliesRecently changed a front pipe manifold on my Echo 2003 4doors Five spd.
Noise I was reporting ealier thread seems to have subsided somehow but I did not hit the high road again, since the repair.
But I have this check engine light that went off 3 days ago and stays on.
Tried 4 times to read the code of OBd II reader and it pulls nothing. As if everything was normal.
I changed the batteries but it acts like it does regularly and it shows like there is no code to pull out.
Could that be a Ghostly Check Engine. It is still on at the moment meaning every time I drive the car.
My great 2001 Echo is acting up for the first time in 11yrs!.. This weekend I decided to have my mechanic change the manual transmission fluid and do a general inspection of the vehicle. He found nothing wrong. I decided that before embarking on a long trip, that I would change the oil/filter, flush the radiator and put new antifreeze, change the airfilter, replace the alternator belt, added a small bottle of Lucas complete fuel system and a new battery.
I was proud of my DIY performance except that the next day the engine light came on! I took it to AutoZone where I purchase all the supplies and battery and they came up with CODE P1349 which I researched and found out about VVT(variable valve timing) malfunction. Some of the reasons for this malfunction are: low fuel pressure due to clogged or bad injectors..... Fuel pump regulator....camshaft malfunction or ECU (engine control unit) problem.
1.This morning the light was off then ten or fifteen minutes later it went on and at the same time the iddle got much faster for about two or three minutes, (in other words the engine was running faster even when I took my foot off the accelerator) and then came back to normal.
2. Later on the light was off again followed by the same sequence of events. Then at one point later I could tell that the the engine was running fast again for a couple of minutes.