Ford - Ranger :: 1993 - Suddenly Died - Engine Won't Engage?
Apr 26, 2011
My '93 Ford Ranger suddenly died while I was driving, no sputtering or bucking, it was just as though I had turned the key off. When i tried to restart, the engine would turn over but not engage. It's as though the engine is either getting no gas and/or spark. My shade-tree mechanic says he got a diagnostic code that was #539 followed by #1 seven times at two second intervals. he says he ran the test 6 times and got the same result every time. What this means?
View 10 Replies
Advertisement
My '93 Ford Ranger died on the road three days ago. The motor simply stopped. Battery is good. the engine will crank but it will not engage. Had it towed to my Shade-tree mechanic he is puzzled. Says that trouble code 5931111111 indicates an air conditioning problem but that doesn't make any sense. The truck is 4 cylinder 2WD.
View 1 Replies
My 2001 2.5 manual suddenly died. The starter turns the engine over, but I don't get a) fuel (changed the fuel pump) b) spark c) Engine check light. When I plug the OBDII reader in, it simply says "ERROR". No codes, no other language.
While trying to figure it out this morning, after trying to start it 50 times, it actually fired for a few seconds, but then died again.
I checked relays and fuses and nothing seemed bad. I swapped relays around too.
I unplugged the battery, then the computer, but nothing got it to fire again.
View 4 Replies
My Father in Law's 95 Ranger, 4 Cylinder, 5 Speed has started acting strange. It has, in the past 3 weeks just died suddenly, and won't restart. No action at all when you turn the key, as if the battery is disconnected. Wait for 45 minutes to an hour, and it starts back up again.
He has had it to a local shop twice, and the only thing they have done is let it idle for 5 hours at the shop. Of course, it never stopped.
Now they are saying it is the clutch, and depending on the type of clutch, (big or small).
I've been working on cars most of my life, and even had an 87 Ranger, and I've gotta call BS on this. He says it happens mostly when coming to a stop.
View 4 Replies
Ford Ranger 20012.5LManual Transmission4 Cylinder Engine4x2 Drivetrain~160K Miles
While driving home tonight, my truck suddenly lost power, as if I turned the key to turn off the motor. There was a beep, the one that goes off whenever I open the door while the key is in or the light is on, then the "Check Gauge" light came on (the one that warns me when my gas tank is near empty), following that the yellow Battery light came on and finally the orange "Check Engine" light came on.
I pulled out into an empty dirt lot, but that was pretty difficult as the power steering was gone (since the truck was off). After parking the truck, I turned the key to the actual "Off" position, pulled the key out and gave the truck a few moments. I put the key back in and tried to get my truck running again. Of course, it didn't work, but I figured it wasn't the battery because it lacked the sputtering motor turn. There's that and the battery is under two years old. The truck seemed like it really wanted to turn and start, but it lacked a certain something to get it up and over that last hill to vehicular movement. I don't think I was lacking gas, since it should have given me the red "Check Gauge" light and even if I was, I know I have another 5 miles before I have to fuel up (I would know since I've tested it to see how far it would go on that light). I was pretty low on gas when this happened, so the thought came to me that maybe my gauge was starting to get a bit wonky. Then a more realistic thought came to mind.
I've had this bad habit for a while, where I fill my gas tank to only about a quarter or a half at the most. Part of it stems from a paranoia of having somebody siphon gas out of my truck at night; yes, I could have fixed this by installing a lock on the gas cap (albeit, my counter-argument is that it's better to have them take the little bit of gas than have hundreds of dollars of body damage from an aggressive thief). Anyway, I've heard that this habit of filling the tank below half can speed up fuel pump failures. Despite this, I've had no other symptoms of a fuel pump failure coming, as I haven't experienced any issues with surging/bucking.
So here are my questions:
1) Am I right in assuming it's a fuel pump failure?
2) Are these instructions to fuel pump replacement accurate? (Yes, I know the DIY Matrix provides every reason on why I should avoid doing this myself, but my wallet I'm itching for a project.
3) If it's not a fuel pump failure, what could it be?
View 12 Replies
This morning, I started my truck to go somewhere and less than a minute into my drive, the engine suddenly died. I tried cranking it again to which it started but less than a second later it quit again. That's when I noticed my FMP on my SGII was at 0v. When I got it back into a parking spot, I pulled the FICM and tested the connectors as well as the relays and they all were normal.
I decided I will be pulling the FICM again tomorrow and I will be sending it back to FICM repair.com for them to look at as I got a new one from them about 8 months ago. However if it is in case the wiring harness, where is a good place to look. I don't think it is the wiring harness as it seems to have voltage at the connectors.
Also this may be related but earlier this week, my Scangauge froze and I unplugged it and plugged it back in and it didn't connect to the PCM until I reset the SGII to factory settings. I wonder if this is related?
View 14 Replies
2004 F-250. 6.0 I was driving down the road when the engine dies. It was like I had turned off the key. When I tried to restart it, it was no click, no starter sound, nothing. The glow plug light remained on, even while turning the key over. What could cause this?
View 10 Replies
I have a 99 F450 bucket truck. I was up in the bucket when the engine died suddenly. It turns over but won't fire. I have no dash warning lights now either but everything else seems to be working. Lights, radio, annoying beeping sound from the key left in the ignition, etc. There are roughly 5 or 6 fuses in the panel to the lower left of the steering column that don't have power to them. Are they all supposed to have power when the ignition is on? I checked the fuse panel under the hood and all of the fuses that have 12V to them are good. There are a few small ones that don't have power to them but I don't think they do all the time.
View 9 Replies
When I turned the key to start my car, I got zero activity from it. No ticking, no lights, nothing. So I tried to do a push start, and the engine wouldn't engage. I took the key out, and suddenly my dome light popped on (though it was dim). I put my key back in and turned it, and dash lights looked normal and at full power, but as soon as I pressed the clutch down and tried to turn the key, everything went dead. I took the key out, put it back in, and turned it, but got nothing.
I pushed my truck up to the top of an incline, and turned the key. All the lights looked normal, so I thought I may be able to push start it. Key was in proper position, clutch was engaged, and gear shift was sitting in first. I got a decent speed, released the clutch... and everything went dead.
I can't decide if it's my starter or my ignition system, though I suppose it could be the wiring, or even something else.
View 9 Replies
So here's the scenario: Driving home. Traffic is pretty heavy, I'm not traveling more than 20 MPH. When I go to change lanes the engine suddenly dies; I have no more power and can barely steer the car off the highway. I had enough momentum to roll to the shoulder. Try to restart the car, but all I hear is a high-pitched whine.
Get towed to the dealer. The mechanic took a look and said the timing belt snapped and bent the valves. But he also thinks there might be additional damage to the engine. We're gonna get a better assessment of what's going on on Monday when the service department's boss comes back from vacation.
My question is: if the car is indeed dead, can I expect to get anything from VW? Will they reimburse me the value of the car towards a new car? Should I see how much to get the car fixed? (They say a new engine might be needed.)
Specifics on the car: 1999 Passat, 1.8 turbo, a little over 86k miles. Car is in great condition, aside from what just happened.
View 9 Replies
1993 ranger, 3.0 V6 203,000 miles. As engine warms up coolant in blown into over flow and spills out. At that point system is low and truck runs hotter than norman, 3/4 way across gage. What would be causing overflow to overfill from engine. Could it be a bad rad. cap? Just replaced head gaskets at 200,000 miles. Truck runs good. No oil in water, no sign of visible leakes other than overflow tank overfilling and loosing coolant.
View 10 Replies
Sometimes the check engine light comes on and truck will not start, the fuel pump runs non-stop.. when check engine light goes off,the fuel pump runs for a few seconds and stops,truck will start.... driving down the road check engine light will come on and truck runs bad.... 1993 ford ranger .....
View 1 Replies
I was driving down the highway when I lost all oil pressure soon after I lost power steering and the engine died. I have checked the radiator and it is still full of fluid pulled the starter off and try to crank it it still turns the cannot get the engine to turn over it clicks but wont turn over there are no oil leaks underneath the vehicle that I can see. I'm just not sure where to go or what to do from here
View 19 Replies
Sometimes the check engine light comes on and truck will not start,the fuel pump runs non-stop.. when check engine light goes off,the fuel pump runs for a few seconds and stops,truck will start.... driving down the road check engine light will come on and truck runs bad....
View 2 Replies
Factory fog lights worked fine, had body off for the head studs recently, they worked fine after. One day they just don't work. Fog light indicator light still comes on. Fuse is good. High beam indicator still works. Where to troubleshoot next?
View 6 Replies
Once again back to the ol' 92 GMC C1500 V6. Had my Ford Escort air assembly disassembled to clean something and received an emergency phone call, the truck seems to start just fine so I took it to get where I needed to go. Ran fine no issues even took it on the highway, ran just like she used to. On the way back I stopped at a gas station, when I went to start it she wouldn't start (towed it home again).
Checked ignition system and it was fine, removed the top of air filter housing and filter and looked down into the fuel injection system and had a person crank the engine and once again no fuel was squirting out. Took out the injectors and they both tested good and the same, 1.7 ohms each, going out to rent noid light again but doubting it will do any good to test again but who knows at this point.
View 19 Replies
I am a cummins owner who just got a 2002 7.3 last week. It drove great for 200 miles then suddenly died last night going 60 mph. It sat overnight then started up and drove 10 miles then died again. I changed the cps and still no start. I changed the oil and let it sit overnight and it started this morning and idled for 5 minutes then died again. I have tried unplugging the ipc and still same no start situation. I plan to check the hpop level today to verify it is full. I also checked the nut on the ipr and it's electrical connection.
I am just a shade tree at best and would love some direction on where to look. I don't have any scan equipment to check pressures. Am I correct in thinking it is a bad ipr?
View 13 Replies
I just got a 2004 F-150 XLT. 200k miles AT. The problem is that it won't start. The previous owner was driving it when it suddenly died and wouldn't crank over. He was told by an auto shop it neded a new engine.
I don't think it needs a new engine because it stopped while driving. I may be wrong. I put a new battery in it. When I turn the key to start it, it just makes one loud click and doesn't do anything else. The oil and coolant look fine. What may be wrong with it or how to see if the engine is bad?
View 14 Replies
I jump started my wife's mini Cooper using my aerostar van 3.0l cargo. Her battery was so dead we had no luck after running my van for 8-10 min. There were a couple of attempts. My van suddenly died when she wasn't cranking the mini. It won't restart.
About one week prior I had a no start situation. I thought I had solved the problem. The first thing I did was listen for fuel pump engagement. I didn't hear it. I pulled the fuel pump relay and cleaned the connections. I put it back and the van started. I drove all week and then I get the call to jump start the mini.
So back to today. Fuel pump is engaging. I checked for spark at #4 cylinder with fuel relay disconnected so as not to flood the engine. I have spark. Battery is strong. I put a new fuel pump relay in place even though it appeared to be working properly. I had my wife crank the engine and the pink/blue wire at the fuel pump relay which goes to the pump lit up my voltage tester. Power appears to be present when cranking and not just initial engagement.
I'm thinking the original no start had nothing to do with the wire connections which I cleaned and it was just coincidence that it started and ran again for a week. The connections are now clean with a new relay attached and not starting. I'm thinking if I have spark and a fuel pump engaging then injectors may not be firing???
View 3 Replies
Last week, my 2005 FX4 Screw died suddenly, and would immediately lose all power to the gauges as soon as the jump leads were disconnected, not to mention the engine would eventually die shortly after that. After a bit of logical thinking, a buddy and I determined that it was likely the alternator, so we pulled it and replaced it. We also had the alternator tested, and it failed every single test, so it was pretty clearly the culprit. The good news is that the truck starts and runs/stays running again. The bad news is that my audio and 4x4 systems are both offline.
As far as audio goes, I'm guessing it's an easy fix because it's probably a fuse somewhere that got toasted. But the 4x4 is a little more of a problem. I tested the vacuum lines by pulling them from the hubs, and neither had any suction. Okay, the solenoid isn't getting power, probably another fried fuse, right? Well, here's where I'm getting confused.
My understanding of this 4wd system is that it works like this: When in 2wd, the solenoid engages the vacuum and pulls the part of the hub that locks in the wheels (not sure what specifically to call it) out, therefore disengaging the front 2 wheels. When 4wd is turned on, the vacuum disengages and that part of the hub pops into place, locking out the front wheels into 4wd.
So, by that rationale, if the 4wd solenoid isn't working due to an electrical issue, then my truck should automatically just be locking itself into 4wd, right? Because without the vacuum to disengage that part of the hub, it should just pop into place and keep the truck locked into 4wd. So if I'm correct in my understanding, then I have another problem because my truck is still operating very much in 2wd.
I did the classic 4wd tests: tight circle to feel the front end gripping/pulling, gun it from a dead stop to see if all 4 tires engaged. But I turned in a much tighter circle than 4wd would ever allow, didn't feel the front end grip/pull at all, and the "peel out" test only showed my 2 rear tires as launching me forward. I also tried shifting into 4-Low, but the truck never shifted into low gear either. -I know that's probably just electrical, but I'm just trying to be thorough in my testing/explanation.
View 4 Replies
I have a 2003 f350 v-10 drove it yesterday to get fuel, went to start it after fueling. No start, no lights dash was gauged was acting odd, and clicking under the dash from behind fuse box. did get it to start after a while, put my foot on the brake to go into drive, never made it ... truck died I do have remote start system thought it was that with the brake pedal issue. disconnected complete system. no change Had it towed, home now no nothing, connect the battery and just clicking from under dash no start ? not a battery, won't even jump Battery is good, the power to starter, Posted this also in light-duty trucks wrong place think this is the better place. Gauges pinned to right with key off
View 7 Replies
