Camry :: 2006 SE Lost Electrical Power After Replacing Catalytic Converter
Jun 2, 2013
06 Camry SE I4
I had to replace my catalytic converter because of the code I was getting. It wasn't difficult to do, but took me a while because I had to transfer the thread rods to the new CAT. Once the new CAT was installed, I went to test her out, but noticed that the car all of a sudden, has no electrical power. Nothing at all. I checked all fuses and nothing is blown. The only electrical I messed with on the car was the O2 sensor.
Car has a brand new battery from yesterday. The only thing I didn't do is install a support bracket on one side, because it was missing a bolt and one thread rod was stuck in the old CAT, i couldn't remove it.
A friend suggested that the missing bracket may be causing a ground issue. Is this true?
View 7 Replies
Advertisement
Chk engine light is on. Checked it at Advance Auto and indicated either cat or the O2 sensor (rear). So, I went to replace the O2 sensor and learned the hard way that you can't just unscrew the nut. I torqued off the stud to which the O2 sensor attaches. Muffler shop told me you need to heat up the stud/nut first to remove it. Oh well, lesson learned. So, I'm looking at replacing the pipe with the catalytic converter attached since I can't seem to fix the broken stud (or actually get the one I didn't break off). The problem is, my car is apparently a CA model and has the special cat on it. I live in VA. What sort of problems might I run into if I replaced the cat with a non-CA version? They are significantly less expensive. This is for a 2003 Toyota Siienna
View 1 Replies
My wife and I have a 1997 Honda Accord, roughly 260k miles. A few months back the Check Engine light came on, diagnostic came back with P0420, typically indicating the catalytic converter is shot. Who am I to argue, it was an factory part. So we replaced that with an inexpensive Magnaflow converter. (don't have the part number on me); this was 5 days ago. Today my wife takes the car in for inspection. Check Engine is still on with the same code. The guy at the testing station begins laughing at my wife when she says we only spent about 200 in parts and labour on the new converter. I'm inclined to think that since we already replaced the converter that I should be looking somewhere else (O2 sensor maybe). But I also don't want to just start throwing parts at it. Do I have a case here? I would really prefer not to spend $1000 on a car that old with that many miles on it just to pass inspection.
View 4 Replies
Heard a funny intermittent rattle and my mechanic told me that my check engine light should be going on any time now as my cat converter is bad. The part is about a thousand bucks! Looked on line and see some aftermarket ones from walker and some other retailers. My car has 103K miles on it,.
View 17 Replies
I have some serious work that needs to be done on my car. The catalytic converter needs replacing, and the valve cover gasket and cam adjuster seals need to be replaced. This work falls under their respective warranties. However, I'm wondering if I should have the water pump and timing belt done at the same time as I have 77000+ miles on my car. Is there anything else that would be good to do at the same time as this work. I would be going back to the VW service center for these repairs. Would it save me any money to do this all together?
View 4 Replies
My 2003 Camry XLE 4-cyl has a serious intermittent problem.
Occasionally, when I insert the key into the ignition switch and turn to ON position, the whole car has no electrical power - including radio, fan, windows, and the whole dashboard just went black ! Starter won't turn. At this point if I just tap slightly on the brake pedal once, electrical power would instantly come back and everything works normal again (car starts, radio, fan working again). This problem would continue to persist randomly. I found that every time when this happens, if I clean the positive battery post/clamp, the problem goes away for 1-2 months then it come back again. I have been repeating this routine for over a year until recently I replaced the battery and the new positive clamp.
The problem has not come back until now (about 9 months since battery change). This time, the problem became a real safety issue. It happened while driving ! Engine just died, everything blackout inside the car. I had to put it in neutral and let it cruise, tapped on the brake pedal slightly to get electrical power back, then started the car and go again.
View 14 Replies
I just took my 2005 Camry to get smogged and it failed. The reading said that my evaporator and my catalytic converter failed. I reset and drove her for almost 200 miles to get the reading settled, but that did not work. I checked all my fuses and the smog-guy and I have no clue what the issue could be. I don't think that the catalytic converter needs replacing since she only has 60,000 miles on her, but what could be the problem that it keeps saying 'fail'.
View 6 Replies
We have a 2006 impreza, that we've been told the Catalytic converter is going out. We cannot seem to determine if there are one or two converters on this car, and want to know if this is something that we could do ourselves once we find out where everything is at?
View 18 Replies
I needed to replace the same (rear) catalytic converter of my 2006 Honda Pilot LX (2WD) in less than 16 months. The first time it happened in October 2014 when the vehicle had 160K miles (Car's service code was P0420), and the second time it happened this month (same code P0420), when the vehicle had 184K miles. I have it replaced at Honda Service both times.
When it happened for a second time so quick (160k miles wth first converter vs 24K miles with the second converter), I asked Honda Service for a free warranty replacement, but they said it only has 12K miles, and 12 month warranty on repairs, they called Honda corporate to see if they would do anything extra (they did not), but Lute Riley gave a discount to do it at their part & labor cost only ($800 first time vs $550 second time).
What could be the cause of the second catalytic converter to go bad so quick? I have been the owner and only driver of the vehicle since i purchased it new and my driving habits have not changed.
View 17 Replies
I have a 2003 Toyota Camry with 207K miles on it. I recently replaced the catalytic converter on it in order to fix the P0420 code. I drove the car to work the next day and the test came back under the max specs. I drove back home and everything was fine. No more CEL.
Now I have the problem where the car starts normal when its cooled down, but if I drive it for a few minutes and turn it off and back on again it stalls. If I let it cool down for a minute it will turn on but idle really rough like at 400 RPMs. At times it will stall back again.
The only other thing I did differently was pump a full tank of gas at a different gas station than I normally do. Before I changed the CAT I had no problems like this.
View 2 Replies
I had my local garage do their electronic check when my check engine light came on. They said the code they got indicated a failed catalytic converter and quoted me $720.00 for a California compliant replacement, including labor. I live in Connecticut. I'd like to take a few days to get a second opinion and second quote, but the garage manager said that driving it in this condition would risk fouling the oxygen sensor, which I recently replaced for a couple hundred bucks.
Should I be concerned about fouling the oxygen sensor by continuing to drive the car? 2000 Toyota Camry...
I looked under the car and the rear attachment bolts to the converter are rusted beyond recognition. I'm tempted to try replacing it myself but it may be a bit beyond my skills.
View 7 Replies
I have noticed lately, when the car is hot, while pulling into my quiet garage, and even when the car is in park, engine running --- hearing some clicking / ticking coming from, or near the Catalytic Converter.... It sounds as if a small piece of metal is rattling inside with the flow of air... It stops clicking once the engine is turned off.
View 5 Replies
I wanted to get some input about lowering my 2010 Corolla LE. I wanted to go about 3 inches, but have been told i will need to replace some extra parts. Not sure where to begin, but i'm not afraid to ask questions or get dirty. I hear a lot of different things and i'm on over load with info.
View 7 Replies
I have a 2006 Jeep Liberty with 135,000 miles. My check engine light is mostly on. Sometimes it is off. One mechanic tested the car and said the catalytic converter is bad. Another mechanic said that test can often be false positive and it might only be the O2 sensor. The difference between the two is about $1,000. Which mechanic is correct? My car is registered in a state that doesn't do car inspections.
View 19 Replies
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 Replies
Looking for a used catalytic converter that is bad ? I want to hollow it out. I have a couple of these trucks so I thought about just hollowing one and swapping it back and forth for smog testing but my luck i will hollow the one that is going to fail next year.
View 12 Replies
What are the symptoms of a bad catalytic converter? I have noticed for a while now, that my car has lost power. I changed the wires and spark plugs thinking that, that was my problem. I don't have the engine light on, would a clogged cat turn my engine light on. I have a 2005 gp.
View 5 Replies
My 1999 Ford Ranger XLT, 6 cylinder, auto trans, with 134K miles has an electric problem. When I turn the key to the 'on' position, all dash lights show normal, headlights work, radio plays, etc. But when I turn the key to the 'start' position, all electric power is lost. The power remains lost until I disconnect and reconnect the battery ground wire. After reconnecting, I again have power until the key is turned to the 'start' position. I was able to jump start the truck, so I assumed I needed a new battery. I bought one a week ago, and was back to normal until today. The truck started, I drove 4 miles to the grocery store, and then I found myself back to square 1 (i.e., the no-start situation).
View 3 Replies
I have a 2001 Mercury Sable with 114k miles. Just bought it and it ran fine for the most part until one day while coming home from work. It was still running but lost a lot of power and wouldn't go fast at all. I took it to my mechanic and he told me that this car has 3 converters on the exhaust system. First of all, I think having 3 is overkill and secondly, I am wondering why these things are so expensive. The one up front that mounts to my manifold is $350 just for the part. The one in the back can be bypassed (legally) but why did they make this system so complex and what are my options at this point? If I found a Sable that was being parted out, could I use the converters from that? Would it have to be the same year?
View 15 Replies
I have a 2006 Toyota Solara V-6. I was driving down the street with no indication of what was about to happen. All of the sudden my check engine light came on and the car lost all power. I had the car towed home and had a mechanic look at it he put his scanner on it and I'm not sure what codes if any came up but he decided it was the ECM so he found a used one with a warranty and ordered it, he put it in and it did the same thing it turns over but wont start. What could it be ?
View 13 Replies
I recently had my catalytic converter replaced with a non-OEM cat. The check engine light came on and a different shop (different from the shop that replaced the cat) said that it will keep coming on because I had the cat replaced with a non-OEM cat.
View 3 Replies
