I have a 2006 Dodge Caravan that started experiencing engine whining and some leaking. I went to my local mechanic thinking it was the water pump and told them as such. They dutifully replaced the water pump but that didn't stop the whining.
I took it back after Sandy and Athena and they now say the steering rack needed to be replaced and was leaking badly as well.
I have a 2001dodge caravan that I can't seem to get the engine temp up on. I've replaced the thermostat and the coolant temp sensor and topped off the coolant. It raised the heat to the first line but once the vehicle is being driven the temp drops to 0 and heater blows cold. During the summer the vehicle runs at normal temp. Have disconnected the ambient temp sensor which did nothing to better or worsen the problem.
View 10 RepliesI was riding down the interstate this morning and had my cruise control set at 70mph. all of a sudden the cruise just turn off. I went to hit the gas pedal and there was nothing. No check engine light or anything, no spit, no sputter. I pulled off the side of the interstate and attempted to start the van. the engine turns over fine, but no start. all lights, radio work fine. car has fuel. it did not run hot.
View 1 RepliesI have a 2005 dodge caravan and today after taking my kids kids to school, I noticed white smoke coming from the hood of the engine. I managed to get home and check it out. With further inspection, smelled like some type of fluid is burning off I can't tell if it's oil or anti freeze. There seems to be some type of condensation in the inside of my van on the passenger windshield. I looked to check to see any leaks inside on the floor mat and underneath the van itself and nothing. What seems to be the issue?
View 6 RepliesI did a tune up on my 3.3L Dodge Grand Caravan only to find the engine is vibrating heavily. This tune up included a new coil pack, plugs and wires.
I did happen to notice a separate thing when looking at the Crankshaft Pulley that it seemed to be wobbling while the engine was running.
I have a 97 dodge caravan engine 3.0. When I start to accelerate my engine fuse 20amp blows. I does not occur every time but yesterday, it did it 6 times and is now getting looked at. I am just curious on what causes this. I did recently have my spark plugs changed so I am thinking something may be arching.
I do have codes that previously came up for my fuel injectors (P0203, p0206). Another code I have is p1294 idle speed performance.
I have an engine noise on my 2000 Dodge Caravan with the 3.3 engine. It sounds a lot like the grinding of a rotating part. It occurs at start up, momentarily, then goes away. If I drop it in gear and start doing low speed maneuvering in the driveway, it comes back. If I turn on the AC it comes back. In all cases, the noise goes away at around 1200 rpm.
The noise occurs again, when I shut the engine down.The engine performs and runs smooth and normal otherwise. No stalling, stumbling, or bad gas mileage to report.
I can "feel" the noise with my hand, when I put my hand on the ac compressor bracket, or the intake manifold, or the valve cover. I've tried the listening through the stick method, and it seems to be coming from the front area of the engine. But I can't be sure. It is something internal. Let me describe:
I thought it was my AC compressor or clutch going bad. The fact that my AC had stopped working well, and was making jet engine noises at high rpm supported me decide this. I replaced the compressor. The AC works great now, and the jet engine noises went away. But the grinding noise is still there. As described.
I wishfully thought it was the belt tensioner or idler pulley. I replaced both of those. Noise still was there. I pulled off the serpentine belt, and started the engine. It made the noise, very briefly as it started, then went away completely. It made the noise again briefly as I shut the motor off. So it's still there without any of the accessories turning.
The noise is loud and obnoxious at idle when under load. It just can't be good. I've read theories about similar sounding problems, saying they could be loose timing chain, bad oil pump, slapping pistons, crank journals, flexplate/flywheels cracked.
I'm going to try doing an oil system flush, and then I'll change it out with a little thicker oil. See if that makes any difference in the noise. Currently I'm running 5w-30 Mobile 1. I think. I'll let you know if it changes anything. I'm also thinking I want to make a short video of the car idling and making the noise for my video camera. I'll post that on youtube and link it here.
The "check engine soon" light appeared yesterday on this nice running 1997 van with 167K. An auto parts store code check indicated a problem with the oxygen sensor. Is this something I can replace myself--a lightweight shade tree mechanic? I never seem to have any luck asking questions on the Mopar website.
View 10 RepliesMy 2003 Dodge Caravan is shutting off while I am driving, starts up ok but goes a little and then shuts off, has to cool down all day and night to go about three miles, got a diagnostics done and it says I need an engine wiring harness and controller. My question is, is there a curtain part of the harness or wiring that could be bad that causes it to shut off, and what part would that be, can it be repaired instead of replacing the whole harness and wires?
View 11 RepliesBought this cheap 93 grand caravan 3.3 with about 350,000km about 750km ago and it had a bit of a whining sound from the start, thought it was normal for it's life. Last night I was taking my daughter and infant grand-daughter home when there was a terrible clunking, grinding and rattling sound coming from the engine. It was about -20 outside so I decided to just limp it home, but when I got a block from my daughters house I lost power steering. I checked under the hood an saw the belt on the left side with all the pulleys had come off and only one pulley near the bottom was spinning. after trying to spin the other pulleys i noticed one wouldn't spin ether way,and was really hot. thought it might have seized up and threw the belt. Is there a pulley in there that's not supposed to move freely, and if not what should I do now?
View 8 RepliesI have a 1998 Dodge Dakota in very good shape. I bought it from my brother who has owned it since 2000. I drove the truck from Reno, NV to southeast Alaska where I live, and all along the pacific coast. It rained a LOT and I noticed pooling of water on the floor at my feet, soaking the carpet completely and pooling up. I thought I was tracking water in the truck from my boots. BUt I have had it here in Alaska for 7 months now, and it is still HORRIBLE! It rains here all the time and I can't get rid of the puddles. There are no plugs in the floor for drainage and I can't figure out where it is coming in. The windshield looks good, and the door seals look good also. I cannot figure out where the water is getting in so I can stop it. THe truck is going to rot and rust if I can't fix it! And here's the thing, the water is pooling on BOTH sides of the floor-passenger and driver. I am baffled. No one ever sits on the passenger side so its not coming from boots! there is no way for water to flow from one side of the floor to the other.
View 2 RepliesSone water from the air conditioner drains on the carpet on the right side of the car. The drain hose is open and water in draining from it. Where could I look to find the problem? It is a 2003 caravan
View 1 RepliesWe recently had some oil leaks fixed on my wife's 2002 Dodge Caravan. The oil light comes on whenever she stops at a stoplight. It seems like it comes on when the RPM drops to about 600 or 700 RPM and then goes off when RPM increases. Is this something to worry about? If so what needs to be fixed?
View 8 RepliesI just had all 6 fuel injectors changed as they were rusted. But the 4 and 6 are still miss firing. I am going through gas more than I should. I had the EGR replaced as it was stuck open. I do not want to pour more big money into this thing. What can I do. Sea foam is not working. Could it be another problem. I am starting not to trust the mechanics.
View 12 RepliesI have a 2005 Dodge Caravan. I drive very little locally - usually just a couple of miles a week. But every couple of months I drive an hour and a half away to THE BIG CITY. Last week I took such a trip, and coming home I noticed my van was making a "jingley" noise. Just like the sleigh bells in the barn. With the windows open I can't tell where the noise is coming from. And it isn't associated with the a/c, since the a/c was off when the noise started.
Since then when I take my little local trips it only made the noise once - when I went over 35 mph. Usually drive slower locally. So, I don't know whether the problem is associated with length of drive time or speed, but I'm thinking it's associated with a higher speed.
Yes, I have an apt. with a mechanic, but I can't get in to see him until the middle of next week.
I've been fighting with these vehicle for months, and I've only been able to narrow down the list of possible issues. Tried replacing the ignition switch, battery terminals and cables, starter, and even a PCM since according to the dealership it was bad. I've checked all the fuses and relays, and they're all ok.
I'm getting fuel and spark, but no crank from the starter. The voltage going to the hot post on the starter is 12.7, but the voltage from the igniton wire is only reading around .5-.6, fluctuating a bit. Before I spend the money on taking it to a mechanic I wanted to know what your opinions were on what the next step is. I know a bit about electrical systems in cars but I'm no expert.
My van went from drive to 3rd gear while i was driving. and now its stuck in 3rd gear. its a 98 dodge caravan. i checked the transmission fluid it was full. how do i fix it?
View 7 RepliesI have a 1990 Dodge Caravan complete with collector plates. I bought new bulbs to replace the burnt out map reading lights, but how to open the enclosure for the lights. There are no screws and no obvious places to pry open.
View 1 RepliesMy front suspension has been making some noise for a while now, and lately has been getting worse. So I want to replace whatever the problem is, but having trouble figuring it out. Everything looks ok, and the methods I researched aren't giving any clues. The one question I Have is, should I be able to move any of the parts by hand? There are two that I can wiggle back and forth pretty easily, but I don't know if this is normal or not. One is a thin vertical piece parallel to the strut, the other is behind the wheel and low in the back (a tie rod?). Don't know the part names, have worked on my vehicles for a long time but never the suspension.
View 19 RepliesMy 96 caravan started misfiring and then it clears ..and then it misfires.. if I get on the highway it clears after a mile or so.. and stays running smooth till I stop and shut it of , thought i got water in the tank but that was 2000 Miles ago ....it's old but it's My work truck...
View 3 RepliesMy 1997 Caravan 3.0 acts as if the EGR Valve needs to be cleaned. Where is the EGR Valve?
View 3 Replies