Ford 6.7L Power Stroke Diesel :: Dry Wipers Won't Stop
May 15, 2017
I have rain sensitive wipers completely dry wipers wont stop?
View 1 Replies
May 15, 2017
Advertisement
Ford 6.0L Power Stroke Diesel :: No Wipers Or Washer Pumps
I replaced my injectors n ficm, truck runs great. Now my wipers dont work. Turn signals, hi beams work. Got power at both fuses and they have continuity but no wipers or washer pump. Looking for a diagram for this? Is the motor located under the front cowl?
View 1 RepliesFord 6.7L Power Stroke Diesel :: Wipers Come On Every Time When Start The Truck
Ok I have this issue that I noticed on my new 2011. May sound weird but the wipers come on when I start the truck every time. Not sure if this is normal but I thought maybe I was bumping the lever thing but it does it anyway. I don't like that doing it cause of snow laying on the windshield in the morning will be a pain.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Windshield Wipers Will Make One Swipe When Not Turned On
I've had my F350 SD for 6months now(21,000 mi) and have seen probably 20 times when I insert the key and turn the switch on the windshield wiper's will make one swipe when NOT turned on. Also have seen several times when starting the truck the radio comes on and it was not on when I turned the truck off. Yesterday when I finished work and was heading home I started the truck and the wipers came up about 1/3 of the way and stopped. I can't seem to duplicate the problem so I have not scheduled it in as of yet.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Wipers Not Working - Only A Click In The Cowl At Wiper Motor When Turn On
I have no wipers or windshield washer. when I turn on the wipers I can hear a click in the cowl at the wiper motor. fuses are good #106 30amp fuse and #33 15 amp fuse. I have 12volts at the wiring on the motor left side with key on and 4.5 volts on the green wire with key off. I replaced the wiper motor and same thing, just clicks when I try wipers. I connected a jumper wire to the ground and no luck.
View 11 RepliesFord 6.0L Power Stroke Diesel :: Power Steering Whine Does Not Stop
After my recent cooling system upgrade and power steering pump/HP hose replacement I am still hearing and feeling the power steering whine. I flushed the fluid and used Mercon V ATF fluid. I jacked the front end up with tires off the ground and cycled the steering lock to lock 100 times or more now and the whine does not stop. Do I need to put a vacuum on the system and try to purge it that way? There was no whine before but I just replaced the pump while I had room with everything out of the way and replaced the high pressure line because the fitting was leaking at the pump. This is very irritating because I thought replacing the pump would be beneficial.
View 2 RepliesFord 6.0L Power Stroke Diesel :: No Power When Takeoff From A Stop / Black Smoke Blown
So I am not sure exactly what is going on with my truck. It is a 2004 F250 has a 6.0 L. Sometimes when I take off from a stop the truck has no power and blows some black smoke. Then the turbo kicks in and all is fine. It comes and goes when it pleases no matter the temperature. What started happening is when I drive it a steady pace on the highway sometimes the turbo gets quieter and louder and quieter and louder sometimes when it gets quieter I see a little bit of black coming out of the tailpipe. Sometimes it doesn't do it at all. Also sometimes when I let off the gas the truck sounds like it's trying to laugh at me like a wastegate is fluttering.
View 10 RepliesFord 6.0L Power Stroke Diesel :: Cannot Get Over 40 MPH When Pulling Out Of A Stop Sign
A couple months back I blew an EGR cooler. My mechanic replaced it and oil cooler, when I got the truck back it was using coolant and on cold days below 35 degrees it wont start without a little shot of ether. I took it back and mechanic found a pinched o ring.T he coolant problem is ok but cold starts not. Now today truck was running fine then as I was pulling out of a stop sign I couldnt get over 40 mph, I pulled over and then tried to go but no throttle response,then died and wouldn't restart .I have no way of scanning, no dash lights came on. I am wondering if this is related another o ring or gasket,hpop ,fuel problem??? just replaced all the injectors and ficm a little over a year ago.where should I start?
View 14 RepliesFord 6.7L Power Stroke Diesel :: DFCM Won't Stop Draining
I am changing fuel filters for the first time. I started by draining the DFCM into a quart container, but after that filled up 6 times I switched to a bucket. So far I have drained over 2 gallons and it shows no signs of stopping. Initially the truck was on a slight incline. That's the way I have always done fuel filters, with the tank lower than the filter. After the first gallon came out, I rolled the truck down to level ground.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Way To Stop Bells And Chime?
There's a lot to love about the new diesel trucks, but the idiot bells and chimes are driving me nuts! I don't need to be reminded that my key is in the ignition, my brake is engaged, my belt is disconnected or my truck is in reverse. How can I disable all these incredibly irritating chimes and gongs? Man, I sure miss the simple idiot features of the early 80's. They were so easy to eliminate with one wire snip... This bothers us enough to make us regret buying the truck, especially when we're running lots of short errands, because we get to go through all the chime rituals every few minutes. We're not getting used to it.
View 9 RepliesFord 6.7L Power Stroke Diesel :: Truck Is Boosting While On Gear When At A Stop
My 2012 f250 is been acting weird, usually the truck is boosting while on gear when I'm at a stop (around 0.40) I think that's normal on a 6.7 because it's always done it, but since yesterday I noticed it sounds different and it's not on boost anymore it just vacuums while on gear at a stop (around -0.25) I'm thinking it's the wastegate solenoid but I'm not 100% sure, and the truck doesn't boost as fast as before but it drives fine and I'm actually getting better gas mileage since it doesn't boost as before, what it could be? It's tuned and deleted....
View 7 RepliesFord 6.0L Power Stroke Diesel :: Tachometer Went Below Zero When Got Off The Highway And Came To A Stop Light
2005 6.0L... Driving to work today, doing about 70mph looked down at the gauges and the tach was reading just above 1k the whole time. Even when I accelerated hard.
Got off the highway and came to a stop light and the tach went below zero (almost rested on top of the boost gauge) light turns green goes up to about 1k but no higher even though I stepped into it a bit.
Got to work and turned the truck off and then turned it back on and the tack started working again.
No mods to the truck other then a stereo system attached to the factory stereo wiring harness. I called the stealership and of course they want the truck to look at. I am curious if it is going to work or not on the way home.
Ford 6.7L Power Stroke Diesel :: 2014 - Hesitates From Dead Stop?
I have a 2014 F250 with the 3.55 rear end and 6500 miles and since new it has a hesitation from a dead stop that I cannot determine if it is normal or not. I took it into a dealer that specializes in diesels and they drove it and told me it is normal. Every time I see someone with the 6.7 I ask them if they have the same problem and I get all kinds of explanations from turbo lag to protecting the tranny. The hesitation I feel is when I throttle from a dead stop. It is a very slight hesitation, but very noticeable, almost like a little "dead spot." If I take my foot off the brake and let it take off on its own for just a second or two and then throttle smoothly it is not there at all. If this is not normal, I want to do everything I can to get it fixed. It is driving me nuts.
View 13 RepliesFord 6.7L Power Stroke Diesel :: Normal To Stop Regen When It Gets To 25% Or Should It Be Stopping At 0%
I know it seems like everyone's truck tends to have different tolerances when it comes to when it starts and stops regen when it comes to gpl but the last two times my truck has gone into regen it starts at 100% and finishes at 25%. Is it normal to stop regen when it gets to 25% or should it be stopping at 0%. Or could it be that the percentage in my truck is off and it's actually using the gpl to start and Stop? The only thing about that is that forscan says it's supposed to start at 100% which it does so if my percentage is off that would mean it was starting at 75% does it not?
View 14 RepliesFord 6.7L Power Stroke Diesel :: A/C Just Suddenly Stop Blowing Cold Sometimes
Blows cold, so not a freon issue, but it will sometimes just suddenly stop blowing cold as if I punched the "A/C" button disengaging the compressor. Sometimes if I just wait a while it will come back on by itself, sometimes I have to stop and shut the truck clear off and take the key out, then start it back up and all is well again and it blows cold again.
High pressure switch failing???
BCM issue???
Ford 6.0L Power Stroke Diesel :: 2004 - Misfire / Chugging Usually At A Stop Light?
I've got an '04 6.0 that's recently developed an engine performance issue and I was hoping to get some leads on what to chase down this weekend. The truck has 75,000 miles on it and has been trouble-free since new when it comes to the motor. Recently I've noticed that, usually at a stop light, the idle will occasionally get very rough and the normal diesel "clatter" noise becomes rather rough sounding- almost like every other "clatter" disappears if that makes any sense. Up until last night this was happening very infrequently and usually only for a couple of seconds. I wasn't really sure what the issue was then and would rev the truck in neutral and the issue would go away. This has happened a handful of times in the last month or so.
I drive a company car all week and the truck only gets used in the evenings and on the weekends, and last night my wife and I drove it to dinner. The truck cranked and started normally and was operating smoothly until we got out of our neighborhood (about a mile of driving), then the rough running condition described above surfaced and continued throughout the 7 or 8 mile drive. This was the first time that it ran like this for more than a few seconds. The truck was running bad enough that you could feel the misfire or 'chugging' at speed. When the truck would shift into overdrive and the torque converter went into full lock-up, you could really feel this as the engine was lugging. I tried to keep the truck out of overdrive because it was shaking the truck pretty badly. When we came out of the restaurant I thought maybe the issue would be gone but it did it all the way home as well. Throughout both drives the Check Engine Light did not come on.
When I got home I got my DiabloSport Predator because I remembered it has a code scanner in it. I have never checked for codes before so I do not know if these are fresh codes, but there is a P0282 Cyl 8 Injector Circuit Low and a P1000 OBD Systems Readiness Test Not Complete in there.
While I was in the driveway with the engine idling badly for a few minutes, the issue completely went away and the truck smoothed out for a few minutes. It was like someone flipped a switch and the truck instantly ran properly. After a couple of minutes however, the issue instantly returned. I tried to clear the codes with the Predator but they will not go away. I am not sure how solid of a scan tool the Predator is????
I did a lot of searching on here last night because this is bugging me, and the symptoms I saw on here about the ICP sensor make total sense based on what I am experiencing. People were describing to a 'T' what I am experiencing. However, I do not have an ICP sensor code and when I searched for the P0282 that I do have I read about FICM issues here.
The rundown on the truck- '04 F-250 CC 4x4, truck was bought 10-03 and I THINK I remember the build date as 9/03 (maybe 8/03). Automatic transmission, DiabloSport Predator with 60hp tune, MBRP turbo-back exhaust, everything else stock. Oil was changed about 4,000 miles ago, both fuel filters done about 2,500 miles ago.
A few questions:
Could the ICP be my issue even though there is no code for it? Could the P0282 be coming from an ICP issue?
I've read about early '04 trucks having '03 motors and something about an updated harness for the ICP- could I get more info?
Is my truck part of the affected group with the wire-chafing I read a little about? If so, could that be causing this and what should I look for?
Does the P0282 immediately point to a FICM issue?
Ford 6.0L Power Stroke Diesel :: 2005 - When Idling At A Stop Light It Might Go Down To 95 For A Few Seconds
My 05 has Glowshift gauges on the window pillar. All are analog except the digital fuel pressure gauge. It almost always reads 102 and that can't be right. Sometimes when idling at a stop light it might go down to 95 for a few seconds. Maybe wire grounding out from sensor?
View 8 RepliesFord 6.0L Power Stroke Diesel :: When Come To A Stop Sign And Slowing Down Truck Died
So about 3 days ago I made a long 9 hour drive. No problems at all but I did allow my fuel to get a little lower then I normally do. About eighth a tank had 30 miles left on the digital read out. Stopped and filled up at loves where I always get my fuel. And off I went drove it down to 3/4 a tank and made it to my stopping point. Got in to go about 7 miles down the road and come to a stop sign and slowing down the truck died. I thought crap I forgot to turn off the auto start but never done that before. Stopped and stared truck as normal. Made it to my stopping point again. Headed back to the house and doing on average 55mph and truck surges like it wants to die but doesn't.
Rpms drop below 500 and it keeps going I get to same stop sign and slowing down again doing maybe 25ish and truck dies again as I have my foot on the break. Put in nut and started it right up and drive on home. Today went about same distance. Only this time I started it with key and was doing down other things while letting it run it just dies start it back up and take off get to where I was going and it surged or hiccuped so to say. Again started it once I was getting ready to leave and let it run for about 5 min and it died had the heater on as it was chilly out by the lake. Got in and restarted it and it was blowing cold air and had a diesel smell to it. Wife asked me if truck was going to blow up. Backed out of area and put in drive and made it 80' or so and truck died again doing about 10mph
Checked so far
Batteries checked and both are good
No mods done to it
New ICP sensor and pigtail
New water pump
New injectors 20k miles ago
Oil changed 1100 miles ago
New filters upper sad lower
2003 Ford F-250 King Ranch 6.0
Ford 6.0L Power Stroke Diesel :: Delayed Shifting / Jumpy When Coming To A Stop
I brought my truck to ford because I thought I was having transmission issues, but they are telling me that my transmission is fine, that I need to replace my number 8 injector. None of these symptoms sound like injector issues:
-Shifting from park to reverse, takes a couple seconds to shift, then jumps.
-Coming to a very slow stop, truck is a little jumpy at around 2-3 mph
Ford 6.7L Power Stroke Diesel :: Transmission Shudder While Loaded When Accelerating From A Stop
While I am loving the fuel millage and ride of my new truck, I have my first concern. In the last few weeks i have hauled a truck bed full of dirt, and 3300 lbs of sod. both times i would use tow haul mode, and while the truck had plenty of power, it would shutter when accelerating from a stop. Mostly first gear 0-15 mph.
This is my truck with a fancy electronic controlled transmission, so on the old pickups this would be a torque converter slipping, but all the ford dealer wants to tell me is "its electrical and they want to reflash my transmission". I am at 26k miles and have less than 10k left on my warranty...
Ford 6.0L Power Stroke Diesel :: Rough Loud Clink Down Under Even When At A Stop Sign
Have a 2004 F250 crew cab with the notorious 6.0L.. ive noticed what i believe is my tranny or maybe torque converter.? What happens is when i back out the drive way and the go into drive, i hear and feel a rough loud clink down under even when im at a stop sign.. I am a first time truck and diesel owner due to my field of work. Also it has a rought time starting in the mornings or anytime the truck is completely cold. Then after it warms up it behaves like it should. also ill get on the throttle and when i come to a stop, the idle is rough and slowly comes back to normal. ...???
View 10 Replies