Ford Super Duty (1999-2016) :: Battery Indicator Light Came On?
Feb 14, 2007
The manual just says it's a charging system problem.
View 8 Replies
Feb 14, 2007
Advertisement
Ford Super Duty (1999-2016) :: Brake Indicator Light Comes On When Turn On The Key
My '99 250 SD - Turn on the key and the brake indicator light comes on.
Start it and the indicator turns off, the E-brake is still on but no light.
It does have an aftermarket radio installed, by PO.
Ford Super Duty (1999-2016) :: 2004 F250 - High Beam Indicator Light Very Dimly Lit
I was cruising my truck down the road and noticed that my high beam indicator light was very dimly lit. I wondered why this would all of the sudden come on at all if the high beams were not on so I pulled over and took a walk to the front of my truck to check my headlights. Sure enough the passenger light was very dim. (I must assume the high beam indicator light being dimly lit is also an indicator for headlight malfunction/burn out)
I figured out the plug has a keeper piece that is supposed to hold it in the bulb base but it was broken off and missing.
I went to the auto parts store to find some kind of fix. To my surprise they have a replacement plug for my truck. The down side is it costs $95 and it still had to be shipped! I decided I could figure something else out.
After I pulled the four 5.5 millimeter screws out of the headlight housing. I noticed there is enough room on either side of the light contacts to drill a hole thru the plug and the bulb to allow a pin to be placed thru both of them which would keep the plug and bulb socket from coming apart.
These are the pins or keepers I used.
A 1/16" drill bit did the job. I put the new bulb/socket and the plug together and drilled a hole on each side of the plug right thru the socket at the same time far enough back and at a width to avoid the contacts of the bulb socket and plug. (there is a rubber gasket in the plug that should be avoided but if you still knick it as I did you can fill the plug or the socket with dielectric grease that most car parts stores have and it will keep any moisture out but not effect the electrical current, do not use silicone, one day you will have to take it back apart for a bulb replacement or something.)
This is the bulb socket with the holes already drilled and the plug removed. This is what it looks like with the bulb/socket and the plug together and the keepers in place. And the back of the composite headlight housing with the assembly installed.
Make sure you install the bulb/socket and plug with keepers on the housing before you bolt the housing to the truck because there is not enough room to get your hands behind the housing to install the keepers with the housing bolted to the truck.
Since I replaced the stock bulb with a Sylvania Silver star I had to replace the driver side too so I didn't end up with a headlight being brighter or "whiter" than the other. Even though I was incredibly careful I still broke the plug on the driver side too! So now both of my headlights now have this mod on them.
Ford Super Duty (1999-2016) :: Battery Light Won't Go Off
I've got a '03 F250 7.3L 4x4 (not sure how much info you need) with many many miles. My battery light came on a couple of months ago. Replaced a battery. Light went out for a day. Checked and replaced the alternator. Light went out for a couple days. Cleaned the battery terminals for better connection. The battery light is off when I first start the truck, but depending on what I've got turned on, lights, radio, AC, the battery light comes on with in 15 to 30 miles down the road. I had the batteries and the alternator rechecked yesterday and everything seems to be charged and charging.
- Should I replace the wiring to the alternator?
- Are there any fuses I should be looking at or for?
- The alternator is a rebuilt one from Autozone, should I get a new one?
Ford Super Duty (1999-2016) :: Battery Light Came On
Battery light came on today, I figured were in need of replacement so I got new ones. Light is still on, until I reach about 1800 rpm. It goes out until truck idles down. Can an alternator do this? I always thought when they went, they went.
View 14 RepliesFord Super Duty (1999-2016) :: Battery Light Is On When Running
The battery light is on when running. The light is dim at idle. Light is bright when driving with rpm's. The battery voltage is 12.8 per my older volt gauge. Alternator out put is 14 volts at idle and with rpm (2,000) +. I had the Alternator checked at AutoZone in there parking lot. Meter hooked up. The alternator passed all test.
View 4 RepliesFord Super Duty (1999-2016) :: Changed Alternator And Now Have Battery Light On
I put an O'reileys alternator in my truck today. Drove it most the day and did some plowing with it and it was fine. I just went out to run to the gas station and now the battery light is on. The voltage is still good.
View 14 RepliesFord Super Duty (1999-2016) :: Battery Light Comes On / Truck Started On 6th Try
2005 F-350 6L diesel .... Put new batteries in it a week ago.
Been running good then the radio quit a couple of times. It came back on after truck was restarted. This morning I go to town and the battery light comes on. I stopped and started about 5 times and on the 6th it wouldn't start.
I got a boost and started home it , started to try and quit when I was almost home. Was so dead the power windows wouldn't even work. Have it on the battery charger now and it starts right up but the battery light is still on and the ABS light is on.
Ford Super Duty (1999-2016) :: Battery Light Coming On Intermittently?
I have an 06 F350 with the 6.0 powerstroke. My battery light started coming on and will go out for a while, then come back on. Sometimes it flickers a little. I have checked/cleaned battery terminals (there was no corrosion). I have replaced the alternator. The batteries are just over a year old (10/12). I have not had any slow starting or any other symptoms other than the warning light. I am still having the same problems after replacing the alternator. I have checked with a voltage tester and it was reading 19+ when the light was off. When the warning light is on it was jumping from 12 - 15. This is an old tester so I'm not sure that it is working correctly. (not sure why I am getting the 19+). I'm going to go buy a new tester, but I was wondering if there is something else that could be causing the warning light. I know very little when it comes to electrical issues.
View 6 RepliesFord Super Duty (1999-2016) :: Battery Light On But Alternator Is Charging?
OK I have 14.04 volts at the batteries with the engine running but my battery light is on. I had the alternator checked off the engine and on the engine and it tests good. Shows good batteries and good charging. Is there something internal to the alternator that would make the light come on even though the alternator is charging ok? Or is there something else that would make the light come on. This is on a 1999 F250 Superduty Powerstroke 7.3.
View 14 RepliesFord Super Duty (1999-2016) :: Battery Light Comes On During Hard Acceleration
I started to notice my battery light comes on during a hard acceleration. So I have been keeping track of it. When the rpm's hit 3200 and above the light comes on bright but never at any other time. I put a volt meter on it and I have 13.4 volts at an idle, as the engine revs up the voltage climes to 13.9 then when it hits the 3200 mark voltage drops right off to 12.4. It seems like a regulator issue to me. The parts store says my 5.4 has an external regulator is that so or is it built right into the alternator?
View 7 RepliesFord Super Duty (1999-2016) :: 2003 - Battery Light Comes On At Startup?
Long story short: I bought my 2003 F-250 super duty 6.0 used back in January. It had one Ford OEM battery and one Walmart special. I had them tested and they were both completely flat. Replaced the set of batteries the next day. Since then, upon cranking the truck, the battery indicator will be illuminated while the truck is running. It will stay on for a length of time that varies based on the day. It will eventually turn off after driving a while, but will come back on if I kill the truck and crank it again (like when running to a store).
The batteries have been tested 4 times and test just fine. No problems with the batteries. The OBD 2 computer/monitor I have installed reads a voltage of around 13 when the truck is running. What to do to solve this problem. It isn't a major issue as the truck always cranks fine and the batteries are not damaged or anything, it is more of a annoying thing. It bugs the crap out of me.
Ford Super Duty (1999-2016) :: Battery Light Illuminated On Dash
The battery light is on on the dash. I checked both batteries with the ground wire removed, and they show 12.85 and 12.84 volts, they are clean and not in need of water. The battery light will go out after around 15 minutes on the highway, but not around town, and if I shut off the truck in town, the next start is at a very reduced amperage. Alternator packing it in?
View 1 RepliesFord Super Duty (1999-2016) :: Battery Light Came On - Alternator Quit
I have a 1999 f-350 V-10. My battery light came on, making me believe that my alt. has quit. I can't see the plaque on the alt so I can't tell the amps. Does my serial number on the truck tell the amps, or do i have to remove the alt to check the amps?
View 3 RepliesFord Super Duty (1999-2016) :: 2004 F250 V10 Battery Light Flickers
2004 F250 v10 xtl 260xxx. Started off by using my remote start, truck started up ran for about 5 sec then shut off, then restart itself and shut back off. When I manually started it, it ran fine. I noticed my battery light was on and as I was driving it would flicker. First thing I did when I got home was clean all my connections to see if that worked. Battery light still on, checked my volts on my battery and they were at about 11.8 with a slow but steady drop while truck was idling.then checked my alt, that too was at about 11.9 with a stead drop.
Alt was only about 7 months old and I had a warranty on it so I had it replaced at Napa and had them test it there. Good alt. Installed the new alt charged up my battery and turned it over. Battery light still on and flickering. Checked all my wires for corrosion, checked all my grounds. Everything checked out. Checked my battery again 12.4 with the truck off, cranked it over and it was back at 11.9 with a steady drop and almost the same reading with the alt. I replaced the battery as well yesterday, seeing how it was about 7 years old.
Ford Super Duty (1999-2016) :: 2004 F250 - Battery Light Came On Suddenly
I was driving and all of a sudden the radio died, battery light came on, Power windows and interior lights died, gauges died speedometer went all the way up to 100. The Head lights, turn signals and heater work. When I got home I opened the hood and the battery was boiling.
View 14 RepliesFord Super Duty (1999-2016) :: 2001 F350 - Battery Light Was Blinking
I currently am driving a 2001 F-350 V10 SuperDuty, and recently the battery light was blinking. I replaced the alternator in it, but it didn't work. I thought it was bad so I went and got another and it still didn't work. Turned out that the alternator wasn't big enough. I then went BACK and got a larger alternator, and it still won't work. Now the battery light is solid, and I'm getting absolutely no charge out of the alternator. I checked all the fuses and nothing is wrong. It seems like all the things you think could be wrong are running perfectly fine! What could be wrong. The truck will start, and idle, but will run off the battery only.
View 14 RepliesFord Super Duty (1999-2016) :: Alternator Quit Charging - Battery Light Came On
My alternator quit charging last night. Was pretty much a sudden onset as I was driving down the road and left off the accelerator the battery light came on and lights dimmed a bit. When I stepped on the accelerator again they bat. light went off and the lights came back up.
At idle I'm at 11.77v. I've pulled the plug on the back of the alternator and I'm getting voltage on both the red and green wires that go into the plug with the engine running. Is this correct?
Ford Super Duty (1999-2016) :: ABS Light Turns On When Alternator Is Not Charging Battery
Pretty much as the title says, I'm having an interesting electrical gremlin. Ford 7.3 super crew 2002 lariat LE.
I have batteries from 2015 that are losing their charge, both of them. It's like the alternator isn't charging them. Truck will struggle to start until jump started, then she's fine.
Symptoms are:
ABS light comes on when as best I can tell the batteries aren't getting charged. Not the battery indicator.
Now that the batteries are low enough, on the instrument cluster the little light the powers the mile LCD screen dims when it's not getting power (but it's fine when the batteries have charge.)
All accessories work when driving, but I haven't been able to drive a long while on the "not charging phase" to see how low they're go.
Batteries register dead (now) because they haven't gotten charge in a while.
When the alternator IS charging or "connected" I can leave the truck idle and she'll charge the batteries, truck will start just fine on the next run (no parasitic drain.)
Driving causes this to happen randomly, doesn't happen when I'm stationary, nor do I believe it CHANGES state (so if I'm idle it won't suddenly NOT charge if it was charging before.)
Narrowed down to 2 probable things.
Alternator
Bad alternator to battery cables
Ford Super Duty (1999-2016) :: Battery Light Came On - Truck Died On Highway
Driving down the highway, battery gauge read fine power, but battery light came on. In a remote Alaska situation so I couldn't diagnose, plus truck is new to me. Kept driving towards civilization. All gauge dropped. Then lights dimmed, then truck died. This was over about 15 miles. At night with lights on. Truck has a plow with plow lights, aftermarket cranking stereo which I was using, heater on (Alaska). It sits 70 miles up the highway from where I'm at getting ready to go back and work on it. So...
Of course first thought it is the alternator, not providing enough power for all this. Looked inside, it is a newer looking reman. Belt is fine. My question is, if not this, what else could it be? I'm hoping to haul the alternator and whatever else out there and get it going without having to drive back and forth for more stuff I need. I can always return stuff I don't use. Probably I'll throw a new battery in it as well. But after that, anything else I should be thinking/ready for?
Ford Super Duty (1999-2016) :: 2003 F250 - Battery Light Came On Intermittently?
I have a 2003 f250 super duty with a v10
i was towing a trailer up and down lots of hills and the battery light on the dash came on. there was no effect on the performance right away. as i kept driving into town i was starting to worry if i would make it.
as i pulled into the carls jr parking lot, the ABS light came on, all the gauges shut off and the truck died just as i pulled into a parking spot.
i figured it was the alternator, had it tested at AutoZone (failed twice) so i swapped it out for a lifetime warranty AutoZone one (very small town, nothing other than an AutoZone)
the truck started after being jumped but the battery light was still on. i figured that the bad alternator killed the battery. the battery was 4 years old and they usually only last 3 years in the AZ heat so i bought a new duralast gold.
the battery light was STILL on after that. the Autozone guy ran his test--- engine off- battery tested fine starting---he said something was wrong with the starter (but it cranked awesomely!) running--alternator tested fine
i just can figure out why when i drive down the road i dash light will turn on and off at random times. the truck seems to run fine. I've even been under the hood shaking the wire while i had someone watching the dash and i cant seem to make the light go on or off