Ford Super Duty (1999-2016) :: Battery Light Has Been Coming On For Few Minutes Then Going Off At Random Intervals
Jan 23, 2016
2004 f350 w 125000 miles.
I had diagnostic done at Autozone and no problems from check or OBD. The battery light has been coming on for a few minutes then going off at random intervals. Today I was towing trailer and quads, around 3500 lbs, to go riding and it was on most of the time running on interstate and highways.
Seems like the serpentine belt doesn't have as much tension as I would expect. Is there an easy way to change the serpentine? That looks to be a real pita.
View 14 Replies
Advertisement
I have an 06 F350 with the 6.0 powerstroke. My battery light started coming on and will go out for a while, then come back on. Sometimes it flickers a little. I have checked/cleaned battery terminals (there was no corrosion). I have replaced the alternator. The batteries are just over a year old (10/12). I have not had any slow starting or any other symptoms other than the warning light. I am still having the same problems after replacing the alternator. I have checked with a voltage tester and it was reading 19+ when the light was off. When the warning light is on it was jumping from 12 - 15. This is an old tester so I'm not sure that it is working correctly. (not sure why I am getting the 19+). I'm going to go buy a new tester, but I was wondering if there is something else that could be causing the warning light. I know very little when it comes to electrical issues.
View 6 Replies
my 2014 low fuel light comes on at random milage some times 27, 23 19 no set time it is a diesel dealer says its normal ?
View 1 Replies
I have a 99 f450 4X4 I'm having brake problems. Without warning when I go to stop my peddle will go right to the floor and I can't stop, at other times I go to stop and the peddle is stiff and I have to put all I have in to it to stop. The abs light comes on and off occasionally at random but as the brake failure has become more and more frequent so has the abs light. Also my steering does seem a bit off, a little tough N jerky and the power steering pump is whining.
View 6 Replies
driving my '06 f250 last night, i noticed a couple random dots and dashes of orange on the warning light cluster. upon shining a flashlight on it, realized it's the ABS light (or what's left of it). there's literally 2 tiny sections of it visibly lit up. Upon shutting the truck off, and just turning the key on, I noticed the whole middle row in the warning light cluster isn't illuminating with the key on. top row (turn signals, high beams, "wrench") and bottom row all seem to illuminate fine during start up and key on. I'm mainly nervous that the check engine light could turn on and i wouldn't know. is it possible that one row of the warning lights could go out? and only partially? seems strange....
[URL]....
View 2 Replies
I've got a '03 F250 7.3L 4x4 (not sure how much info you need) with many many miles. My battery light came on a couple of months ago. Replaced a battery. Light went out for a day. Checked and replaced the alternator. Light went out for a couple days. Cleaned the battery terminals for better connection. The battery light is off when I first start the truck, but depending on what I've got turned on, lights, radio, AC, the battery light comes on with in 15 to 30 miles down the road. I had the batteries and the alternator rechecked yesterday and everything seems to be charged and charging.
- Should I replace the wiring to the alternator?
- Are there any fuses I should be looking at or for?
- The alternator is a rebuilt one from Autozone, should I get a new one?
View 1 Replies
Battery light came on today, I figured were in need of replacement so I got new ones. Light is still on, until I reach about 1800 rpm. It goes out until truck idles down. Can an alternator do this? I always thought when they went, they went.
View 14 Replies
I've got a 2006 f250 with 160,000 miles, trans was rebuilt by previous owner about 10,000 miles ago. The tow/haul light started blinking yesterday, only blinks for first couple of minutes of driving and then stops. Service engine light popped on today as well. Won't have access to a code reader until tomorrow, but looking for some preliminary info...
View 3 Replies
The battery light is on when running. The light is dim at idle. Light is bright when driving with rpm's. The battery voltage is 12.8 per my older volt gauge. Alternator out put is 14 volts at idle and with rpm (2,000) +. I had the Alternator checked at AutoZone in there parking lot. Meter hooked up. The alternator passed all test.
View 4 Replies
The manual just says it's a charging system problem.
View 8 Replies
I have a 1991 Chevy Lumina and I believe this wire is the root of my problems. I
wasn't the one who unplugged it but it seems it was unplugged as an easy way to get around a problem. When unplugged the car runs but the performance is off, It doesn't feel like it has the same power as it does when it's plugged in and it also sounds different when in idle. When the wire is plugged in the car stalls while driving at random intervals between 1 and 10 minutes and needs to be jumped to start it back up. I will attach pictures of the wire and its location within the surrounding area.
View 1 Replies
I put an O'reileys alternator in my truck today. Drove it most the day and did some plowing with it and it was fine. I just went out to run to the gas station and now the battery light is on. The voltage is still good.
View 14 Replies
2005 F-350 6L diesel .... Put new batteries in it a week ago.
Been running good then the radio quit a couple of times. It came back on after truck was restarted. This morning I go to town and the battery light comes on. I stopped and started about 5 times and on the 6th it wouldn't start.
I got a boost and started home it , started to try and quit when I was almost home. Was so dead the power windows wouldn't even work. Have it on the battery charger now and it starts right up but the battery light is still on and the ABS light is on.
View 6 Replies
OK I have 14.04 volts at the batteries with the engine running but my battery light is on. I had the alternator checked off the engine and on the engine and it tests good. Shows good batteries and good charging. Is there something internal to the alternator that would make the light come on even though the alternator is charging ok? Or is there something else that would make the light come on. This is on a 1999 F250 Superduty Powerstroke 7.3.
View 14 Replies
I started to notice my battery light comes on during a hard acceleration. So I have been keeping track of it. When the rpm's hit 3200 and above the light comes on bright but never at any other time. I put a volt meter on it and I have 13.4 volts at an idle, as the engine revs up the voltage climes to 13.9 then when it hits the 3200 mark voltage drops right off to 12.4. It seems like a regulator issue to me. The parts store says my 5.4 has an external regulator is that so or is it built right into the alternator?
View 7 Replies
Long story short: I bought my 2003 F-250 super duty 6.0 used back in January. It had one Ford OEM battery and one Walmart special. I had them tested and they were both completely flat. Replaced the set of batteries the next day. Since then, upon cranking the truck, the battery indicator will be illuminated while the truck is running. It will stay on for a length of time that varies based on the day. It will eventually turn off after driving a while, but will come back on if I kill the truck and crank it again (like when running to a store).
The batteries have been tested 4 times and test just fine. No problems with the batteries. The OBD 2 computer/monitor I have installed reads a voltage of around 13 when the truck is running. What to do to solve this problem. It isn't a major issue as the truck always cranks fine and the batteries are not damaged or anything, it is more of a annoying thing. It bugs the crap out of me.
View 4 Replies
The battery light is on on the dash. I checked both batteries with the ground wire removed, and they show 12.85 and 12.84 volts, they are clean and not in need of water. The battery light will go out after around 15 minutes on the highway, but not around town, and if I shut off the truck in town, the next start is at a very reduced amperage. Alternator packing it in?
View 1 Replies
I have a 1999 f-350 V-10. My battery light came on, making me believe that my alt. has quit. I can't see the plaque on the alt so I can't tell the amps. Does my serial number on the truck tell the amps, or do i have to remove the alt to check the amps?
View 3 Replies
2004 F250 v10 xtl 260xxx. Started off by using my remote start, truck started up ran for about 5 sec then shut off, then restart itself and shut back off. When I manually started it, it ran fine. I noticed my battery light was on and as I was driving it would flicker. First thing I did when I got home was clean all my connections to see if that worked. Battery light still on, checked my volts on my battery and they were at about 11.8 with a slow but steady drop while truck was idling.then checked my alt, that too was at about 11.9 with a stead drop.
Alt was only about 7 months old and I had a warranty on it so I had it replaced at Napa and had them test it there. Good alt. Installed the new alt charged up my battery and turned it over. Battery light still on and flickering. Checked all my wires for corrosion, checked all my grounds. Everything checked out. Checked my battery again 12.4 with the truck off, cranked it over and it was back at 11.9 with a steady drop and almost the same reading with the alt. I replaced the battery as well yesterday, seeing how it was about 7 years old.
View 5 Replies
I was driving and all of a sudden the radio died, battery light came on, Power windows and interior lights died, gauges died speedometer went all the way up to 100. The Head lights, turn signals and heater work. When I got home I opened the hood and the battery was boiling.
View 14 Replies
I currently am driving a 2001 F-350 V10 SuperDuty, and recently the battery light was blinking. I replaced the alternator in it, but it didn't work. I thought it was bad so I went and got another and it still didn't work. Turned out that the alternator wasn't big enough. I then went BACK and got a larger alternator, and it still won't work. Now the battery light is solid, and I'm getting absolutely no charge out of the alternator. I checked all the fuses and nothing is wrong. It seems like all the things you think could be wrong are running perfectly fine! What could be wrong. The truck will start, and idle, but will run off the battery only.
View 14 Replies
