Ford Super Duty (1999-2016) :: F250 Turns Over But Doesn't Start With New Battery - Electrical System Fried
Aug 27, 2015
So a truck that was running fine Sat for 2 weeks. Battery died so i sent some coworkers to jump it. They tried using a welder which they didn't get turned down enough. Now the wiper motor stays on even without the key. Radio doesn't work but the dash light still comes on. With a new battery installed it turns over but doesn't start. I know something had to get fried but where to start. Thinking about replacing all fuses and relays...
View 7 Replies
Advertisement
I have a '99 F-250 super duty with a 5.4 L engine and I am having trouble starting it. Initially it wouldn't turn over at all, so I had the battery checked, it was fine, and after charging it the engine would turn over very, very slowly once or twice then stop. I then replaced the starter and now it turns over very erratically but wont start.
View 4 Replies
My dad has a 04 f250 5.4 auto. The motor turns over but very slow and will not start. He's put two new starters on. I went and looked at it and figured it was loose cables or corrosion, but it was fairly clean, and tight. We decided to pull the battery out of his van that he drives everyday, and I cleaned everything very good. Same thing. Pulled the belt to make sure nothing was lockup, same thing. Truck was running and starting great, then just did this one morning on him.
View 9 Replies
I recently caught up on some maintenance with my truck, changed the turbo pedestal seals, replaced both batteries, brakes, e-brake cable etc and installed new 10k hid headlights. its a single cab 250 with a 7.3 and zf6 4x4 with 133k. a couple days ago I turned on the headlights and the truck died, restarted no problem and would die the next 5 times I tried to turn them on, then it worked fine. yesterday I got in my truck to leave for work and got no wait to start light, no glow plug chatter, no fuel pump running. turns over just fine but no fire.
I got a ride to work and tried it when I got home, fired right up. I pulled the pCM, checked it out, no weird smells and my TS chip wasn't corroded or anything like that, worked fine. drove to 711 to get a 6 pack and it did the headlight thing again. I removed the HIDs because this all started after I installed them and reinstalled my silvanias and it didn't die when I turned them on. this morning went to leave for work, same no start condition. I disconnected both batteries for 30 seconds to reset anything and same problem. I was about ready to light it on fire this morning.
View 1 Replies
I have a 2008 f 250 super duty gas v10 i have never had problems with it start always starts right up and strong. After coming out of the story today I tried the remote start and it tried to turn for a couple seconds and stopped. I replaced the battery and starter and still nothing. i hear the relay when trying to start with both keys or remote start but nothing from the starter all lights are working .
View 1 Replies
I have a problem on my F250 4x4. The 4x4 doesn't engage from inside. I tested for vacuum on the pipe that leads out of the solenoid. There seems to be no vacuum building on the outlet line. This is the line that go to the wheels. Is my solenoid stuffed. the pump works well and vents do not default to defrost.
View 14 Replies
My truck doesn't want to go grab parking!! The shifter has a lot of play, Every time I go to park my truck I have to forcefully hold the shifter up into parking so it can grab. I had times when the shifter its in parking and it will still move, like I've gotten out and pushed it and it moves.
View 1 Replies
Pretty much as the title says, I'm having an interesting electrical gremlin. Ford 7.3 super crew 2002 lariat LE.
I have batteries from 2015 that are losing their charge, both of them. It's like the alternator isn't charging them. Truck will struggle to start until jump started, then she's fine.
Symptoms are:
ABS light comes on when as best I can tell the batteries aren't getting charged. Not the battery indicator.
Now that the batteries are low enough, on the instrument cluster the little light the powers the mile LCD screen dims when it's not getting power (but it's fine when the batteries have charge.)
All accessories work when driving, but I haven't been able to drive a long while on the "not charging phase" to see how low they're go.
Batteries register dead (now) because they haven't gotten charge in a while.
When the alternator IS charging or "connected" I can leave the truck idle and she'll charge the batteries, truck will start just fine on the next run (no parasitic drain.)
Driving causes this to happen randomly, doesn't happen when I'm stationary, nor do I believe it CHANGES state (so if I'm idle it won't suddenly NOT charge if it was charging before.)
Narrowed down to 2 probable things.
Alternator
Bad alternator to battery cables
View 6 Replies
Parking brake light stays doesn't come on when the parking brake is engaged. The light DOES come on when starting the vehicle and the gauge cluster cycles through its start up procedure. Couldn't find a fuse that would fix my issue...does one exist?
Truck is an '02 F250 w/ 7.3TD and 6 speed manual.
View 2 Replies
My windshield washer has recently just sprayed up about a foot.
Will adding some vinegar to the fluid and see if it will unclog?
Or does this just mean that my pump is giving up?
'99 F250 SD V10
View 7 Replies
I recently had need of replacing my left exhaust manifold on a 2000 F250 4 x 4. I removed plastic inner fender well. Now I have a two pin harness with both white wires. One is white with red stripe, the other is white with black stripe. The harness is round with a locking square on one side. The harness is located about 10" from bottom of inner left plastic fender panel. It has 2 mounting pegs. Where the heck does this connect?
View 13 Replies
I have a 2009 F 250 5.4L, couple days ago it acted as if the alternator had gone out and killed the battery. I swapped batteries with a coworker to get the truck home and when I hooked the battery back up, the battery and the alternator both tested fine. I've put the voltmeter on periodically and everything seems to be fine and all electronics are working except for the radio. I did a light test on the fuse and it showed a bad fuse so I tested the fuse and it tested fine and I put a new fuse in and tried the light test again and it failed. What the problem could be?
View 1 Replies
My 2005 ford f250 fx4 won't activate when I turn the key the light illuminates then turns off but when I start the truck and select it it doesn't go into gear
View 2 Replies
As I am driving everything goes dead radio, windows, dash, alarms, everything then turns on a usually 30 seconds later. is it a ground? is it a sensor that's getting to warm? is it a loose wire? where should I start??
View 6 Replies
2000 F-250 Super Duty
I was replacing my headlights, which required me to splice in their lights to my parking lights, and I seem to have shutdown ALL my parking lights. I did a test after twisting my wires together and everything worked fine. Then I soldered and heat shrunk them and somewhere during that process I lost all the parking lights.
I checked the 8th fuse as per the manual (for Parking Lamps) with a multimeter and it checked out just fine.
Figured it was the time to ask the experts on here where I should go from here. Are there some other fuses I could be missing, or maybe some else I could do?
Solved: Bad fuse in the #8 slot in the Power Distribution Box (under the hood, near Cab, driver's side)...
View 3 Replies
I went to replace a headlight bulb and now I lost electric in the cab. I have no interior lights, no power window or door locks, turn the key on, no crank, no cluster, no radio, no chimes, the upfitter switches work, the mirrors power fold and telescope. Have power to both fuse boxes and battery is fully charged.
View 6 Replies
The other day I was under my truck and noticed electrical plugs behind the front splash guards. What these might be for? I have a 00 F250 superduty XL model with the 5.4.
View 8 Replies
Can get up to speed about 55-60 in my 2003 f250 6.0 4x4 truck and hit the brakes hard and the pedal gets hard almost like you cut the truck off and the truck doesn't stop well I can let off the pedal and hit it again hard and it works like it should. Also when it does this the power steering doesn't work. I was on an exit ramp and almost wrecked when I exited off the interstate I hit the brake pretty hard and couldn't steer I let off the brakes then hit them again and it worked fine and so did my steering. It would seem that the two are connected somehow. What's wrong?
View 2 Replies
I have a 1999 f250 super duty and something keeps draining my battery, I replaced the old one and im having the same problem. What could it be?
View 14 Replies
2013 F250. Wife turned the ignition on to roll up the windows before the storm (good thing), but left the switch on. Both batteries dead. I charged them both (although not completely). Started OK but have a check engine light on. Should I just put the batteries back on charge?
View 5 Replies
I have a 2001 f250 5.4 triton. My cb antenna hole leaked water in cab, soaked my fuse block. Horn goes on and off, radio turns on without key in ignition, truck only starts when key is on and I bridge solenoid, and number 4 coil is not firing. I have let truck dry out, fixed the leak. Everything is bad to normal except starting issue and coil issue.
View 6 Replies
