Golf/GTI VI :: 2010 - EPC / CEL Came On - Throttle Body?
Feb 1, 2013
So while driving yesterday I had a EPC and Check eng light come on and go away shortly after... maybe 1hr of drive time. Any way I took into dealer today to have them scan and they stated it was an issue with my throttle body.
Now as soon as he told me that he also said he can not do any work under warranty on my engine due to Stage 2 software and intake/down&mid pipe...... no big deal as I figured he would say something like that anyway. Should I take it apart and try to get it cleaned..... or what?
Its a 2010, with roughly 21k miles.... Had APR stage 2 for a few months now and this is the first thing that has come up.
View 3 Replies
Advertisement
Started my car this morning to warm it up, idled for ~ 20min. weather conditions. I returned to my car, and it was misfiring and threw the p1545 throttle body code. There was a mk5 tsb for a similar problem involving wiring. 49k miles, stock tune, w CTS catted dp.
View 8 Replies
I decided to take out the throttle body and clean it with throttle body cleaner that I got from autozone, after I put everything back, I started my car and the motor was shaking and smoking a lot out the muffler and just would not be drivable at all. the RPM was just going up and down and hesitating bad. later I took off the spark plugs and they were very much burnt black at the tips and that is probably not normal right? but I replaced them with NGK BKR7E spark plugs and it still gave me the problem.
View 13 Replies
I have a customer that has a 2.0 mk4 with 260000 miles on it..about 20k miles ago we had 6 codes saying throttle body was not working and car was surging, so we ordered a vdo tb, installed it reset tb and it ran fine for 7 months and 20k miles. Again car is surging, so i tried a tb reset. tb was under guarantee so we took advantage and replaced it/reset it and it threw a code within 5 min of driving and hesitating/surging. He is original owner? possible ecu getting sleepy?
View 22 Replies
So the other day I went to the mechanic for him to see what code(s) were causing my CEL. He simply told me that there was an issue with the throttle body and it didn't know what position to be in; he cleared the codes, clean the throttle body and said if the light came on again I needed a new tb. The CEL came back on, but his diagnosis doesn't make sense to me.
From what I've researched if the throttle body had this issue the car would run like crap; however, it runs fine. Smooth idle, good throttle response, accelerates smoothly through the rev range, and I'm still getting decent fuel economy. Given that, it doesn't seem like it's the TPS either, and the tb was just cleaned so I'm confused. Could it actually be the throttle body, or is there some sensor that has just gone bad? The car is a 2000 Golf with an AEG engine & 5-speed box.
And here are a couple pic for clicks of a stock-ish car.....
View 5 Replies
The inter cooler to throttle body hose and it seems to have coolant all over it.
View 12 Replies
I have been having the dredded EPC light coming on and according to the vag scan its the throotle body. What I need to know is if one off a 2003 2.0 jetta will work on my 2004 2.0 jetta. The number on the side of mine 06A 133 062s is not the same number on the 03. I was told that they must match to work properly.
View 2 Replies
So i have been hearing a whistle under acceleration for some time. Normally comes at 1/2 to full throttle. I also have had check engine light for a bad o2 sensor for about the same amount of time(2months). Fast forward to last week. finally replaced sensor. Check engine is gone. Open her up a little on and on ramp, Whistle is still there and the CEL comes back. Have it scanned, and it come back load calculation cross check 17551. I need an sticker so i rest the ecu (no light) and drove it like a grandma 50miles to get the sticker. No CEL. Get sticker. Just to make sure i wasn't crazy i gave her some gas on the way out of the inspection lot, and there is the CEL.
In conclusion, Between the whistle, CEL, and the fact that i drove it 50 miles with out the CEL coming back under very light throttle, and i just replaced the MAF with a new Bosch 2 months ago, i am pretty sure it is some kind of vac leak.
I have a new TB gasket in the mail, but my question is, Is there other places where such a vac leak is common in these cars? Other info on car.
UM tune
evoms intake
HPA downpipes (whistle started after these where installed)
Flapper
no res
74k on the clock
View 11 Replies
So starting with the specs: I have a Stage III+ Golf R with about 39k Miles on it. Stage III+ was added at 17k miles and has treated me pretty good. The car is driven about 3 days a week and has the oil change interval of 3k miles.
Things that I've checked or done recently:
- Cam Follower: Wasn't too bad but seemed like the outer coating was wearing off on it so I replaced it.
- Oil change: Changed the oil about 1 week ago but hadn't driven it since then until yesterday were we did about a 50 mile road trip. (No unusual things noticed)
When we came back home and parked in the garage, I noticed the sound when I turned the ignition off. It was pretty noticeable as you will see in the video. Could I possibly have a bad throttle body on my hands?
[URL] ....
View 8 Replies
2006 Honda CRV, throttle by wire. How can you get the throttle plate open to clean the throttle body etc.
View 4 Replies
I searched but couldn't immediately find anything about this particular line. I've been struggling with a rough idle for the past couple weeks, throwing codes that I'm running to lean all the time. I cleaned the throttle body and MAF, and was in the process of replacing the MAF and noticed a small hose fitting behind the MAF but before the throttle body was pretty much split in half. I don't know what it's for and I'm replacing it regardless, but could this be the source of my problem?
View 5 Replies
I have got a 5 door 2002 Golf 1.6l petrol, manual transmission with 190k kilometers on the clock. It has been playing up recently and the authorized VW garage is clueless, but still happy to charge for a miserable job...
The "symptoms" are always the same: I can start the car no problem. Plenty of water coming out of the exhaust and EPC light comes on, no power transmission (or very little). In this state, the engine runs irregular. Before all this happens, you can tell there will be a problem (this is not super obvious), as the car does not run smoothly in neutral, especially when it is at a a hill You might get away with another 50k but that's it.
Breakdown 1: Called out road side assistance and got it towed. Volkswagen dealer retrieved the error code P1564 and they replaced the throttle and some of the contacts of the throttle. (Costs 800 GBP)
Breakdown 2: However, 300 km later, same problem as before road side assistance retrieved error code P0638. The memory was reset and it did run perfectly fine for a short while (2000 km).
Breakdown 3: As before, error message P1564 was read. This time they thought there was a problem with the coil in cylinder 2 and replaced it (250 GBP) - also the one in cylinder 1 as "old". Picked up the car and it was not running smoothly in neutral and it eventually broke down after only 90 km.
What to get changed next? What is the real root of the problem here?
View 2 Replies
So i recently bought a used 2003 camry le 4cyl with 72k miles on it. So it's still in good condition. Previously I had a 92 camry 4cyl which is run with throttle cable. The new generation camry's now are drive by wire or driven electronically. So I decided to check out the whole car and looked into the throttle body, the out side of the butterfly plate, and notice some thick black substance. It seems like grease or oil. I don't know if its there to lubricate the motor to run the plate or just oil.
View 8 Replies
When cranking there is no fuel from the throttle body. Dropped the fuel line on both sides of the filter that was replaced last fall and have good flow before and after the filter. If I spray starting fluid down the throttle body it will fire. Switched out the throttle position sensor and idle air control valve to no avail. It used to die after warming up every so often at a stop light but would start right back up, now it just quit and wont start ???
View 1 Replies
Would a corroded throttle body cause a false code P0332 knock sensor.
View 4 Replies
I cleaned my throttle body this afternoon.
My car started fairly easily, and I continued with running it to 4k RPM a few times, then took it for a ride. I floored it a few times, as suggested, to clear everything out.
Now, my 2004 J-VIN Camry is running around 1200 RPM, it was at about 650-675 before the cleaning. Is this normal? Do I need to d/c the battery to reset the ECU so the car can re-learn with a clean TB?
View 5 Replies
My prius has a coolant leak, which look like it's coming from the throttle body. The stealership recommends a new throttle body. The mechanic said he has not seen coolant leak from the throttle body before. Is this the only fix to replace the throttle body?
View 8 Replies
What Is that little hose for? I can Smell the gasoline whenever i start the car in the morning. It is cracked But i recently heard a z-zzing Under the hood. Is it an expensive hose? What about the hose clamp.. it looks weird.. is its special for that application ? I wanna replace it myself but I don't want to do it wrong and turn my car on fire.
View 4 Replies
I have a 2012 Camnry I4 and want to clean the throttle body.
Is this throtte the type that I can manualy open valve by hand without damage, or does the pedal need to be pushed to open, to prevent computer or throttle timing issues?
View 7 Replies
The rpm with the A/C on are 550 , I was told to replace Throttle body, I did, rpm continue the same,when im driving and I stop the car start vibrating, some one told me that i have to program the new throttle body , how can i do that?
View 3 Replies
I've tried searching everywhere, but can't seem to find the torque for the 4 bolts holding the throttle body to the plastic intake. This is on a 2az-fe engine in my 2004 camry. I imagine the torque would be the same for any Scion, RAV4, etc. that has the same engine.
View 4 Replies
