Golf IV / Jetta IV :: Rusty Passenger Side Rocker Panel
Oct 21, 2014
Recently I made a corrosion claim about some rust forming on my jetta. Long story short VWOA accepted to replace my passenger side fender and trunk, but refused to replace my passenger side rocker panel. Once all the warranty work is taken care of I would like to treat the rocker panel rust the best way possible. I'm not looking to spend hundreds of dollars on this procedure, but I don't want there to be a hole in my car by next winter.
Personally I'm thinking of sanding it all down, treating the rust, applying some paint to it, and then trying to protect the area a little more by investing in OEM side skirts.
View 23 Replies
Advertisement
Any tips and tricks on cleaning this? Just did an entire wash clay compound with orbital and a wax. Car looks great for a 12 year old but This area is a bit tricky clay gets stuck in the pores and nothing seems to clean it well. Id like to clay it but its not working well.
View 2 Replies
My 96 Dodge Intrepid has pretty rusted rocker panel on one side. The plastic covers are fine, the metal beneath them are in tough shape.
I would like to keep the car another year but not sure if I can pass inspection.
Someone suggested to me to look into replacement rocker panels that can be attached by an adhesive. He said he did this on his Chevy.
I took a quick look and could not find any for this car. Does not mean they are not out there. I just did not find them. Where to look?
Another person suggested I make some sheet metal brackets and attached the plastic covers and that should suffice. Easier said than done.
View 19 Replies
I've got a 2000 f150 4x4 extended cab, and the rocker panels under the doors are getting rust holes in them. I would like to get mine fixed/replaced this spring. My truck is in great shape other than the rust holes under the doors.
View 14 Replies
A 2002 F-150 XLT. I was lucky enough to find one that had always been garage kept and has no rust. Unfortunately, I do not have a garage at my house and I need to prevent rust in the rocker panels and cab corners, the typical rust spots. Is it as simple as buying a can of 3m undercoat and spraying the inside of the panels? How to prevent rust?
View 2 Replies
Awhile back I did get my battery replaced and I did reset my windows so they could be used from the driver side panel. As of now, I can roll down all of them from the driver side except for the passenger side rear (window diagonal from driver). The window does roll down from the door itself so the window isn't broken. The light on the driver window switch is lit green, not blinking. However, the light on the window switch on the passenger door is NOT lit and not blinking either. And yes, I did make sure the window lock was not on.
Could the switch, either passenger or driver door, be bad? Should the battery be disconnected and reconnected??
View 8 Replies
I just recently got a 2001 1.8t jetta. It was leaking coolant and only one fan would come on. Ive fixed the coolant leak. Only the passenger side fan comes on, and the AC blows hot as well. Ive checked the fuses on the battery and they are good.
View 3 Replies
I could hear a rattling noise under the hood. The passenger side fan would appear to be off balance or the bearing most likely is going out in it. I am having trouble finding a replacement fan for it. Can I replace just that fan, or am I looking at a new cowl complete replacement? What is the part numbers or a link about these fans. It is the passenger side fan that is malfunctioning.
View 5 Replies
After a 70km trip stop in the road and outside the car smell like sulfur and its from the passenger side not in the engine bay not in the exhaust behind not a/c. why is this?
View 2 Replies
What hardware I need to install the passenger side motor mount spacer from Euro Image Tuning. Been sitting on it for a while and cant find the hardware that it came with. Would like to install it, but dont remember what it came with..
View 2 Replies
I have an 05 jetta 2.0 and I had a loud whine on passenger side of engine. I removed serpentine belt and ran engine briefly and noise was still there. Figured it was water pump or tensioner. and when I was changing timing belt, tension, and water pump I found it was the timing belt itself that was whining. It was OEM original belt with 140,000 miles on it. The belt was in very good shape no tears just used looking. Now engine is very quiet.
View 1 Replies
I recently just lowered my gti and I noticed that the sway bar was laying on my passenger side axle. I put adjustable end links on but that did not got the problem either, this car I daily drive.
View 10 Replies
I did my pads and rotors this weekend. On the fronts I had some difficulty with the passengers side retaining clip. It was stuck in on the bottom. I wound up bending it out of place trying to get it off, and eventually just removed the caliper without it.
I took it out for it's first regular drive today and there is a rattling noise when the passenger's side goes over bumps (could be front or back, hard to say). I have theorized that the clip is deformed enough that when it gets jostled, it bumps out onto the rim which makes it go twang (which would be consistent, it's a relatively high pitched rattle. I'm going to look at it tomorrow, but I'm not sure what I should actually do. Can I just clip it off? What purpose does it serve? I might be able to get it out with WD40 and bend it in to shape.
View 5 Replies
I've got a "clunk" in my front passenger side suspension. I'm running stock struts with H&R sport springs that I put in about 10,000-15,000kms ago. The clunk is inconsistent and seems to only happen in the parking lot when I'm backing out of a stall. When I pull forward, I get a couple clunks coming from that side? Could this be tie-rod?
View 17 Replies
I've got an '04 1.8t jetta with 158k on the clock. Recently noticed I have a coolant leak on the passenger side of the car. Started the car in my driveway and looked for drips and found coolant collecting in the front valence right underneath the intercooler. Took a look from the top and noticed the hose going into the bottom of the part shown in the picture is leaking like a sieve. It's the metal canister-type thing on the passenger side right next to the radiator. What part this is? And where I can get a new hose that connects to the bottom of it?
View 11 Replies
So I just jacked up my car to check out how bad the bushings are on the control arms and the tire rod. They're bad. So I'm going to get the suspension stage 1 refresh kit from ECS.
Well I went to spin the passenger side wheel and I noticed that I can tilt it back and forth slightly, I checked the other side and couldn't do the same thing. I just got both wheel bearings replaced by a shop and I'm hoping its not the hub. This is just a CV joint or bushings or if it's actually the hub???
View 2 Replies
Upon putting on my winter wheel i was checking if the bolts were too long and my rear passenger side wheel wasn't spinning. I took the wheel off and checked the rotor and it took a lot of force to spin because the caliper didn't go back. I took the brake fluid line out hoping it would decompress the caliper and it did not, and brake fluid leaked out a tiny bit. This leads me to believe that my caliper is bad. Just want to make sure before I order another one
View 4 Replies
There is a knocking sound in the rear passenger side area. Cannot diagnose the cause, what it could be. I checked the bushings for the anti sway Bar but that was not it.
View 1 Replies
I have a creaking in the rear passenger side wheel area. Checked the anti sway bar that was not the problem I have no clue what it could be.
View 4 Replies
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 Replies
My power seat is stuck in the all-the-way-forward position. Seat has power to tilt and move up/down but will not move/slide back and forth. I am guessing there is a power cable that popped out when the seat was moved all the way forward.
2000 Jetta VR6
View 6 Replies
