Mine is leaking badly from both tie rod ends. I am guessing the seals got nicked up when the tie rods were replaced. Is there anyway to replace just the seals? I would really like to avoid replacing the rack.
View 2 RepliesThe steering rack on my 2009 Sonata was previously replaced under warranty but now it start to leak seriously.from the two boots at the ends of the steering rack ends. Is it possible to replaced seals only where it leaks?
View 13 RepliesI'd noticed an oil leak drivers side and upon investigation it appears the rack has developed a leak. I lifted the car on the vehicle lift and when I did noticed oil pouring out of the boot surrounding the steering linkage coming from the steering rack. With the tires dropped the full amount this created a tilt of said boot allowing the oil that had filled the boot to drain out. My conclusion is the rack has developed a leak with the boot being full of oil.
I did a "steering rack" search but nothing of value appeared.
My 2006 Toyota Camry LE (4cyl) is in the shop today for its 120,000 mile maintenance. The Toyota shop says my power steering rack (or boot?) is leaking, the whole thing needs to be replaced, and this is a $1200 repair. I had an accident in this car on 01/03/13, I was hit on the front passenger side tire, pushing it in and under, along with damage to the front lower corner of the door and the whole fender. I got the car out of the repair shop last week and immediately noticed a lot of banging and bumping that was not there before. I called the repair shop, they said bring it in and they will look at it, I was planning to take it in tomorrow. Meanwhile my car was due for an oil change and the 120,000 mile maintenance, so I dropped it off this morning and you know the rest of the story. I asked Toyota if this could have happened in the accident - they said while it could be that the banging and bumping noises are the boot rattling, it was not likely this would have happened in the accident. What do you think, is it possible or likely the power steering rack could have been torn in the accident or in the ensuing replacement of parts on the undercarriage?
View 6 Replies2009 Sonata 2.4L ... About 60 000km ago, the complete steering rack was replaced under warranty. Now I notice the PS fluid going down in the PS reservoir. I checked for any loose fittings, all look OK. But I did notice PS droplets hanging from the steering rack boots. So today I replaced the PSF4 fluid with Amsoil PS fluid. I suspect maybe some seals are leaking. Any good product I can use to maybe stop the leaks?
View 1 RepliesI was replacing the oil in the transfer case and came across this under the passenger side. Power steering rack seems to be leaking through the rubber boot, but I have not noticed anything on the garage floor in recent months...
Can the boot itself be replaced? I hate to think the whole system needs to be replaced.
We have a 2005 Camry XLE, with 102,00 miles on it. It has been very well cared for, and only serviced by our Dealer. We would like to keep the vehicle for another 50,000 miles. We have had an assessment of the vehicle done by the Dealer, because our brakes were very soft.
He found a great deal of air in the lines and flushed them out. He also found:
1.) Leaks in the power steering rack, which he graded as a level 8 severity on a 10 point scale. Repair estimate is $1100 to replace and align.
2.) Both front struts are cracked and graded for severity as an 8 on a scale of 10.
What do you think:
A.) Are these safety issues ?
B.) What are the consequences of delay ?
C.) Are these problems indicative of other likely problems ?
D.) Is it better to have a Dealer perform the repairs ?
Last week I took my 2004 Honda Odyssey in to Firestone for a rear brake job and they ended up selling me an oil change, two new tires, alignment, an alternator drive belt, and two front engine mounts as well. When I picked up the vehicle late Friday afternoon, I noticed the power steering was making a whining noise and the steering seemed a little stiff. I took it back to Firestone Saturday morning, and they looked under the hood and said my power steering fluid was low, so they topped it off. That fixed the whining, but the steering still had a bit of a kink in it. They said it might be an air bubble in the line that would work itself out. Monday morning on my way to work, the whining was back and the steering very stiff and getting noticibly worse by the minute, so I took it directly back to Firestone.
It turns out the rack and pinion is leaking, and Firestone denies that it could have happened while they had the vehicle. The manager I spoke to said "all we did was replace a couple of belts -- didn't even get near the rack and pinion." Well, that's not all they did, but if anything they did could have caused the current issue. I know there were no suspension or power steering issues before I took it in, and after I picked it up suddenly it's leaking fluid like crazy. What can I do or say to press my case?
Is that unusual?
View 9 RepliesI'm going to replace tie rods assembly. I have a question about inner tie rod boot. How do you attach it to the steering rack? No room there, horrible access.
View 1 RepliesReplace the seals in a power steering rack on a Passat? I recently noticed I had a fluid leak after seeing spots on my driveway. After discovering it was power steering fluid when I checked the reservoir, I checked all the lines and found the leak coming from the rack on the drivers side. The boot on the steering rack had come loose and there was fluid leaking from the side of the rack. Is there a fix for this or am I looking at a expensive repair?
View 6 RepliesHaving problems with motor craft oil filter leaks. Every time I change my oil the filter ends up leaking. This has happened three times.
View 7 RepliesI took my 2010 Camry LE for its 70K service to the mechanic to find out there is a leak in the rack and pinion. The tech said that this might happen due the wear and tear as the seal might get eroded or so. He showed me the leaking part and interestingly I never found any oil leak on the garage floor until the day. Anyways I just got the basic powertrain warranty on my camera so will have to take the repair costs on my own. They suggested replacing the rack and pinion with a quote of $1.4K (out the door which includes tax, labor and wheel alignment etc). Not sure if its a rip off being a novice in the auto field. Now my question is, is there a way to get this leak sealed or should i go for the replacement of rack and pinion? Also is it dangerous to drive around in the car which has this leak?
View 4 RepliesJust took my 2007 GX-470 with 133,000 miles in for an oil change and the tech told me that my rack assembly is leaking and needs to be replaced to the tune of a little over $1000.
Is this something fairly common? I haven't been able to find a whole lot of information on this forum pointing to problem with GXs..
I just had my oil changed and was told that my rack and pinion was leaking also my valve cover leaked I had the gasket change about a year ago an the leak is so slight it wont even show up in my dip stick, is it possible the valve cover leak is getting on the rack boot. Also can I change just the boot car has 15000mi in great shape an well maintained.....
View 7 RepliesMy main concern with this replacement job( I am not doing it), is that the R rack is different that the standard golf rack. is that so?
I have a very good friend and excellent mechanic who said "...it's the part number it gives me." which makes me nervous. I don't want a "less sporty" steering feel.
so are the racks the same? what part number it should be I am having a hard time finding it.
I bought a brand new 07 Legacy 2.5i sedan at the end of 2006. At 1500 miles the steering was problematic, took it in to the dealer, and by the time they were done, they replaced the entire power steering system. They said the problem was with the power steering rack, which they replaced. I asked if this new part was from the same supplier, so could also be defective, and apparently it is. I am rather alarmed, this is the 1st brand new car I have purchased in 20+ years.
View 27 RepliesI just had my Prius C in Alignment shop, and after alignment was done I got ABS light ON. We checked it and it says Steering Rack Angle Fault.
View 10 RepliesI have a 2000 lexus rx300. the steering rack was replaced 2yrs/20k ago. now, there is very slight seeping of fluid. only noticeable on on the boot and never drips onto the floor. i took it back to the dealer and they said that is normal and after 2yrs it's in very good shape. i question why if the seals are working properly then should i see this?
View 6 RepliesI'd like to pin down the issue before dismantling the whole thing.
So my XC90 started creating noise very much like this video (note: this is not my vid) [URL] .....
The car recently got most commonly problematic suspension parts replaced to no cure to the noise.
Mechanic said that it is the steering rack but can't tell what exactly is making the noise.
I just finished my first MK4 steering rack replacement (don't work on too many VWs), and when I placed the steering shaft from the column onto the shaft from the rack and bolted it down, there was still some clearance (see photo). I was able to get the bolt tightened down ok, but the clearance is bothering me.
View 2 Replies