My main concern with this replacement job( I am not doing it), is that the R rack is different that the standard golf rack. is that so?
I have a very good friend and excellent mechanic who said "...it's the part number it gives me." which makes me nervous. I don't want a "less sporty" steering feel.
so are the racks the same? what part number it should be I am having a hard time finding it.
as the title indicates i had the pleasure () of changing out my leaking power steering rack - all seamed to go well but right after that i am now getting a constent traction control warning light on my dash - what should i check ?
View 3 RepliesOur 2000 Subaru Outback has just over 200k. We want a vehicle that is safe, but do not want to put a lot of money into this. At the last service the dealership said the left ball joint boot and power steering rack boots need to be replaced and the rear differential bushings are broken or loose. All of this would be > $1000 to repair. They said that the ball joint could get dirty and fail catastrophically and be a safety issue. Is that right or will the steering start to feel rough beforehand? Can we drive it safely?
View 11 RepliesI need to replace the power steering rack on my car. Mech wants 300+parts. I supply the parts. Is there a different rack for the vr6 VS the I4 jetta?
View 1 RepliesI bought a brand new 07 Legacy 2.5i sedan at the end of 2006. At 1500 miles the steering was problematic, took it in to the dealer, and by the time they were done, they replaced the entire power steering system. They said the problem was with the power steering rack, which they replaced. I asked if this new part was from the same supplier, so could also be defective, and apparently it is. I am rather alarmed, this is the 1st brand new car I have purchased in 20+ years.
View 27 RepliesI just finished my first MK4 steering rack replacement (don't work on too many VWs), and when I placed the steering shaft from the column onto the shaft from the rack and bolted it down, there was still some clearance (see photo). I was able to get the bolt tightened down ok, but the clearance is bothering me.
View 2 RepliesA few weeks ago I drove my car straight into a curb and killed the steering column. The car was not drivable. After a discussion with BMW service rep, I obtained a copy of an addendum to the steering and alignment manual that indicates if certain parts were damaged to the suspension then the steering rack MUST be replaced -- despite the fact that there is absolutely NO indication that the part is damaged. My problem is that my insurance company is refusing to pay for the part since it shows no signs of damage and BMW will revoke the warranty on the steering column and attempted to remove themselves from any liability if the steering rack did fail after suspension repairs. I can't consciously drive my car knowing that there is a possibility that the steering rack could go out at any time so I am forced to pay the 2k. Is this fair? Can an auto manufacturer force their customers into a catch-22 like this? It is my understanding that BMW and Mercedes are the only automakers that do this. Not even Ferrari.
View 8 RepliesMy 2006 Toyota Camry LE (4cyl) is in the shop today for its 120,000 mile maintenance. The Toyota shop says my power steering rack (or boot?) is leaking, the whole thing needs to be replaced, and this is a $1200 repair. I had an accident in this car on 01/03/13, I was hit on the front passenger side tire, pushing it in and under, along with damage to the front lower corner of the door and the whole fender. I got the car out of the repair shop last week and immediately noticed a lot of banging and bumping that was not there before. I called the repair shop, they said bring it in and they will look at it, I was planning to take it in tomorrow. Meanwhile my car was due for an oil change and the 120,000 mile maintenance, so I dropped it off this morning and you know the rest of the story. I asked Toyota if this could have happened in the accident - they said while it could be that the banging and bumping noises are the boot rattling, it was not likely this would have happened in the accident. What do you think, is it possible or likely the power steering rack could have been torn in the accident or in the ensuing replacement of parts on the undercarriage?
View 6 RepliesI was replacing the oil in the transfer case and came across this under the passenger side. Power steering rack seems to be leaking through the rubber boot, but I have not noticed anything on the garage floor in recent months...
Can the boot itself be replaced? I hate to think the whole system needs to be replaced.
My power steering seems to have sprung a leak. There is quite a bit of fluid below the passenger side of the steering rack. The leak seems to be right below where the power steering hose comes down off the pump, gets secured to the chassis and changes to metal line from rubber. The metal line then goes into an L bend and is routed towards the driver side right where the leak apparently is.
I haven't had a chance to have a good look, as it was 10:30 at night when I parked it and looked (12km of careful city driving since it started to act up)
Is this a high pressure or return line?
The leak seems to be forward of the steering rack, so hopefully I wont have to replace it.
Replace the seals in a power steering rack on a Passat? I recently noticed I had a fluid leak after seeing spots on my driveway. After discovering it was power steering fluid when I checked the reservoir, I checked all the lines and found the leak coming from the rack on the drivers side. The boot on the steering rack had come loose and there was fluid leaking from the side of the rack. Is there a fix for this or am I looking at a expensive repair?
View 6 RepliesWe have a 2005 Camry XLE, with 102,00 miles on it. It has been very well cared for, and only serviced by our Dealer. We would like to keep the vehicle for another 50,000 miles. We have had an assessment of the vehicle done by the Dealer, because our brakes were very soft.
He found a great deal of air in the lines and flushed them out. He also found:
1.) Leaks in the power steering rack, which he graded as a level 8 severity on a 10 point scale. Repair estimate is $1100 to replace and align.
2.) Both front struts are cracked and graded for severity as an 8 on a scale of 10.
What do you think:
A.) Are these safety issues ?
B.) What are the consequences of delay ?
C.) Are these problems indicative of other likely problems ?
D.) Is it better to have a Dealer perform the repairs ?
Last week I took my 2004 Honda Odyssey in to Firestone for a rear brake job and they ended up selling me an oil change, two new tires, alignment, an alternator drive belt, and two front engine mounts as well. When I picked up the vehicle late Friday afternoon, I noticed the power steering was making a whining noise and the steering seemed a little stiff. I took it back to Firestone Saturday morning, and they looked under the hood and said my power steering fluid was low, so they topped it off. That fixed the whining, but the steering still had a bit of a kink in it. They said it might be an air bubble in the line that would work itself out. Monday morning on my way to work, the whining was back and the steering very stiff and getting noticibly worse by the minute, so I took it directly back to Firestone.
It turns out the rack and pinion is leaking, and Firestone denies that it could have happened while they had the vehicle. The manager I spoke to said "all we did was replace a couple of belts -- didn't even get near the rack and pinion." Well, that's not all they did, but if anything they did could have caused the current issue. I know there were no suspension or power steering issues before I took it in, and after I picked it up suddenly it's leaking fluid like crazy. What can I do or say to press my case?
The next thing on my list of things to replace on my truck is the steering box. I have dealt with a lot of play on my steering for quite a while. I recently replaced the the ball joints and that worked but I think the box is just worn out. I have read all the great review on Redhead boxes but I just can't afford it now. What else is out there? Is our oem box a motorcraft or something else?
View 6 RepliesMine is leaking badly from both tie rod ends. I am guessing the seals got nicked up when the tie rods were replaced. Is there anyway to replace just the seals? I would really like to avoid replacing the rack.
View 2 RepliesIs that unusual?
View 9 RepliesI'm going to replace tie rods assembly. I have a question about inner tie rod boot. How do you attach it to the steering rack? No room there, horrible access.
View 1 RepliesI need to replace my pressure line on my 02 Escape 3.0L. Looking for a DIY for doing this same job?
View 1 RepliesI just had my Prius C in Alignment shop, and after alignment was done I got ABS light ON. We checked it and it says Steering Rack Angle Fault.
View 10 RepliesThe steering rack on my 2009 Sonata was previously replaced under warranty but now it start to leak seriously.from the two boots at the ends of the steering rack ends. Is it possible to replaced seals only where it leaks?
View 13 RepliesI'd noticed an oil leak drivers side and upon investigation it appears the rack has developed a leak. I lifted the car on the vehicle lift and when I did noticed oil pouring out of the boot surrounding the steering linkage coming from the steering rack. With the tires dropped the full amount this created a tilt of said boot allowing the oil that had filled the boot to drain out. My conclusion is the rack has developed a leak with the boot being full of oil.
I did a "steering rack" search but nothing of value appeared.