Phaeton :: Gas Pump Malfunctioned - Not Shutting Off When Tank Was Full
Jul 23, 2010
I was filling up the Phaeton tonight when the gas pump malfunctioned. Instead of shutting off when the tank was full, it just kept on pumping until gas came spewing out of the tank. The side of the car (and my best pair of pants) got drenched in gasoline. I immediately went home, threw my clothes in the laundry, took a long shower, washed and waxed the car, and cleaned the seats with leather conditioner for good measure. The car still smells of gasoline, but not so badly now.
My question is this: Is there harm in filling the tank completely to the brim? Because my tank is now as full as it possibly can be. Is there anything I should do before I drive it again?
View 1 Replies
Advertisement
I have difficulty filling my gas tank in my 1996 Sebring convertable. The pump keeps shutting off as if it is filled. Thought it was a venting problem but my mechanic couldn't find anything.
View 1 Replies
This has happened to me 4 times now in the 7 years I've owned my car. It happened so infrequently I thought the problem was the pump's sensor was not working properly. However now it's happened twice the last two times I've tried to fill up. On Friday my son was supposed to fill the car and could only get 1 gallon in and the fuel pump kept clicking off as if the car is full of gas. The bars never moved and I thought the problem was the pump. Then today, Sunday 2 days later, I decided to go ahead and fill it up. I have 250 miles to drive and want a full tank of gas. The tank shows 3 bars. I started fueling and it clicked off at 1 gallon. So I pulled the pump trigger again and tried to force more fuel in and it stopped and wouldn't add anymore than 1.7 gallons.
So now I have a long drive tomorrow and I can't figure out why the pump is clicking off as if the tank is full yet it can't be because I drove 250 miles since my son tried to put gas in and it's showing I have 3 bars.
View 3 Replies
My car is a 2003 Hyundai accent . When getting gas, the gas pump often shuts off several times( almost every $0.50 of gas) well before my gas tank is full. Also, I have to fill the tank VERY SLOWLY to prevent spills and it takes a long time to fill up the tank. After Im done the car takes gives a bit of problem to start. Could it be the fuel filter?
View 6 Replies
When I fill up gas at the pump, the pump continually cuts off as if the tank is full. I spend about 10 minutes at the gas station filling up the tank, and I can never tell if the tank is full or if the hose is just cutting off. The car mechanic told me the replacement vent line cost $200 to $300 to replace (with labor). Is there any cheaper solution?
View 1 Replies
I had less than half a tank and went to fill up before a long drive. At the gas station, the pump wouldn't let me put any gas in the tank , it kept clicking stop. I gave up and was going to try again later, however when I turned my car back on, it said I had a full tank all of a sudden.
The gauge on my dashboard isn't going down at the right speed either.
View 1 Replies
I have an 02' Blazer 2Door 2WD 4.3L vortec. Great truck - very low miles. About a month ago the fuel pump went out. She was showing signs / not starting on the 1st/2nd try and finally wouldn't start. It's a 12 year old pump and I was also that guy trying to make til Friday on a quarter tank - so no complaints so far. I checked the relay and fuse, all good there - so I bought a new AC Delco and fuel filter. Drained and dropped the tank, cleaned and dried the tank and installed the new fuel filter. The pump came with a new pigtail - so I wired in the new pigtail, attached the hoses and re-attached the tank. Not bad for 6 hours of work ( first time - don't judge ). She fired right up and ran like a champ / about a week later I stopped and filled up the gas tank. Next day - no start / no whine from pump / 0 psi at the schrader valve.
Assuming it must be an electrical issue - I dropped the tank and tested the gray power wire / 12 volts. But to be thorough / in case I made a mistake / I stripped and re crimped all the connections, heat-sealed the sleeves and wrapped in all in electric tape. Tested the pump - she hummed like a kitty. Re-installed the tank and she fired up like a champ. Drove around a couple of days - stopped and filled the tank with gas. Same thing - wouldn't start right there at the pump. i poured fuel in the intake - she would start and run until the fuel burned up.
No hum from the pump. had it towed home ... again ... began to siphon my now full tank of fuel to drop it yet again. At about 1/2 way , I tried her and the pump primed and she started right away. For the past two weeks I have been unable to make it NOT WORK - but i am worried to go very far , less i be stranded again. on the gauge I get 60 with the key on and 56 running. With the engine off the pressure holds for quite a long time - well over an hour+. So what would cause a brand new AC Delco pump to not work only when the tank is full - then start working when some of the fuel is removed?
View 7 Replies
I'm having issues filling up my gas tank; I can't pump gas at full speed, not even at the slower setting that you can set the pump to. It just clicks off like it's full. When I pull the gas pump out i can see some gas has collected and it takes time to drain down the pipe. In order to fill the tank I have to hold the pump so it pumps slowly. It seems to be worse during hot weather; and the severity of it varies.
View 24 Replies
I was driving my 2005 RX 330 (138k miles) North on I-75 through Atlanta in rush hour traffic when the car completely died in the left hand lane w/ no shoulder. GDOT stopped six lanes of traffic to push us up and over a couple of hundred yards to a right shoulder. It was determined that due to a coolant leak from the water pump the timing belt malfunctioned and shredded.
I had heard that the water pump should be replaced during the 90k maintenance when the timing belt is changed, but my water pump was not replaced according to my maintenance records. I understand from reading a couple of posts that this isn't always required but that they do check the water pump. Is this correct? And if so should they have noticed that there was a potential problem?
View 9 Replies
I filled up my tank this morning and everything seemed fine (the tank showed full an everything). I drove 20 miles and the gauge was on 2 bars. I though that was strange so I checked for a leak, there wasn't one so I went to a nearby gas station and filled up again to make sure I wasn't leaking fuel (this full up was for about .2 of a gallon so there was not a leak). Anyway I continued to drive and I received the blinking light followed shortly by the dash board lights going off and my car using its battery power up before stopping. Now I can't put the car in "ready" mode and can't drive, it just immediately tells me to add fuel. I believe my car thinks I do not have gas, when I still have a full tank. I have to get my car towed to the dealership now, but was wondering if this is a common problem and/or is there any easy fix for this?
View 4 Replies
The gas pump keeps shutting off when I try to fill my '95 Saturn, like it would when the tank is full, even when the tank is empty. This is a recent phenomenon, and it does it at every gas pump. I have to keep pulling the handle to get gas in the tank. I took off the filler tube and checked both it and the vent line. Both are clear. What could be causing this?
View 2 Replies
Actually, anything more than a half tank of gas will produce a sloshing sound. it's most notice able at low speeds, i.e. going over a speed bump. Also, when in D at idle speed, then hit the breaks, I hear a thud then all the sloshing of the gas. The dealer just told me this is normal. I didn't hear it before the gas tank recall.
View 14 Replies
I have 2002 Ford Explorer and I have trouble filling it with gas. The pressure in the fill line keeps shutting off the gas pump. I have to slowly drizzle the gas in to fill the tank. Sometimes the problem is better, sometimes worse.
View 4 Replies
We just got through changing out the 12 volt battery. Car is 2009 and had 60k miles but last summer was a killer hot summer in Texas. The care was doing strange things with the first start of the day with the triangle! coming on and then having to turn off the car and power back on to get it to go. So all posts seemed to indicate bad battery. We checked diagnostics and it was showing 9 volts. So now it is changed, diagnostics shows 12 volts but the gas indicator went to nothing. no bars. yesterday it was all bars. I supposed someone could have siphoned off all my gas last night but highly unlikely and too coincidental that it shows that after the battery change. Is there something we need to reset?
View 2 Replies
I generally average north of 50mpg on a regular basis. Yet, my cruising range is always somewhere around 300~ miles for a full tank.
View 5 Replies
I picked up my new to me 2008 Touring Prius last night from the dealership (Mazda not Toyota)- happy to see the tank looked full. I started and stopped the car on two errands after picking up the car, and the gas tank still showed full.
This morning the car would not start after the first attempt, after the second all the lights came on including the red triangle, and on the third attempt the car started but the last pip is flashing.
View 12 Replies
My 2015 2.4L Hyundai Sonata randomly started overheating today. The coolant tank is full and it never did this before. The temperature gauge goes up and the information display says car has overheated.
View 9 Replies
I have a 2003 accent 1.6L ... It's been like this for a while, but when filling up, it clicks and stop filling like if it was full, but it is not. I can maybe get 0,30$ worth of gas in before it clicks. Then I have to wait a couple of seconds, and do it again.
I have read that it might be the charcoal filter that is clogged. Is there any way to fix this? from what I have read this filter is inside the gas tank.
View 7 Replies
I am the original owner of a 337 with 292,800 miles, that's correct. I recently have had a fuel cutoff problem when the fuel tank gets less than 1/3 full. So I replaced the fuel pump and fuel filter thinking that would solve the problem. It still stalls with a low fuel tank. It runs fine with more than a 1/2 tank. I have a Vagcom and no issues there.
Mystified at what could be the cause. Possibly fuel pressure regulator or vacuum line, is there a check valve somewhere in the fuel system that could be sticking, or what about an issue with the EVAP system? By the way this car still looks great, has been to the track many times as well as autocrossed, and still has the original clutch. Way to go VW. My race car is a spec miata.
View 2 Replies
I'm having difficulties fueling my vehicle. The fuel pump will shut off every few seconds indicating the tank is full, but it is definitely not full at all. With this, I have to carefully insert the pump into the tank only a little way and generally I can hear the gas bubbling up and eventually spilling over onto the ground, and me. This method takes about 10-15 minutes to completely fill the tank.
I have replaced the vapor canister vent valve and was given another part with two ends connecting by two wires (see attached) that I couldn't locate on the car to replace, so I still have it in my tool box. After replacing the one item, it did not fix the problem.
View 6 Replies
The gas pump/hose keeps shutting off when I fill my tank. The problem is progressively getting worse. No Codes. Truck runs fine. I looked at the filler neck and filler hoses. They appear to be original but no obvious signs of an issue...
View 9 Replies
