Prius (2004-09) :: New Hybrid Battery - Red Triangle Pop Up Intermittently
Apr 13, 2016
I have a 2007 Prius with 107k miles. Last July it had a minor drivers side front end collision. Last November it had the hybrid battery replaced. I believe all this is unrelated just putting it out there for information.
I am currently having the red triangle pop up intermittently. When it does a "problem" message will display on the MFD. This seems to occur most often after a long downhill or when the Energy display is showing the hybrid battery is nearly full.
The hybrid battery seems to be functioning normal and the car is driving normal and has expected fuel economy. I do have a headlight that cuts out occasionally but no other noticeable electrical problems. I do not have a diagnostic device to get the codes.
View 6 Replies
Advertisement
i have a 2006 with almost 200k miles. Got the red triangle, check engine light, and the red car at the top of the MFD. I ran the codes and got P3000. Does this sound like traction battery failure? The car still turns on and ICE still cycles off and on.
View 19 Replies
I have an 07 Prius which I bought used in 2011 and which has been fine (except for some A/C work last year) but got the 'triangle of death' this morning and having towed it to my regular shop, they tell me the code (they couldn't give me the number) simply said 'replace hybrid battery'... the car has 102,605 on the clock.
View 9 Replies
I have a 2007 toyota prius. The car drives, but pulsates. The Check engine light and triangle of death are on. Diagnostic test says "replace hybrid battery pack", but wouldn't the car not even start if the bat pack were dead? What it could be? perhaps a bad cell or two? a bad ecu?
View 19 Replies
I have a 2007 Prius and the red triangle showed up. It has less than 50,000 miles. I noticed that almost right after I start it up the hybrid battery fan kicks on. This leads me to believe that maybe one or more cells in the hybrid battery are overheating due to charging problems. Is there a way I can check this out without going to the dealer?
View 3 Replies
well I saw one other thread on this topic but no resolution. I replaced the hybrid battery like the codes told me too on my 2003 prius and it now drives great but as soon as it start it shows a problem and the red triangle stays on. No check engine light, no codes, no driving issues just a red triangle. How to diagnose a red triangle when there are no codes.
View 16 Replies
I have a 2005 prius with 84,000 miles. The car is running fine but the main red triangle light came on. I took it to toyota and they said I needed a new hybrid battery.
View 10 Replies
I replaced my hybrid battery of my NHW10 a year ago. now recently it shows the warning triangle. Once it went off after a long drive but now its permanent. is there a way to Diagnose what is the cause of this? If its a Hybrid battery issue, will it go off if i replace the bad cells?
View 3 Replies
I have been having some hybrid battery issues. My prius is a 2006 with 198,000 miles. The original battery was replaced at around 120,000 with a junkyard battery. About a year later that battery gave up the ghost and I decided to rebuild that battery. So far that has worked quite well until recently.
My troubles started a couple weeks ago when I got the Red triangle and all the dash lights and the hybrid system icon on the MFD. Naturally I thought it was the battery again. Took it out and checked the voltages of the modules. All the modules where within tolerances. I grabbed a OBDII scanner and checked the code. It was telling me that the Hybrid current sensor was bad. I changed that out with the wiring harness from the old battery.
That lasted for a few days before the red triangle came back. I checked the code and it was indicating one of the blocks was bad. I think P3019. So I took the battery back out and replaced that block with other modules. Almost instantaneously the red triangle came back with two more bad blocks. I think it was P3012 and P3022. So I took the battery out once more and tested all the voltages of all the modules. Everything was 7.86-7.9v. So I decided to start the rebalance of the existing modules in hopes to find some bad modules.
I also bought a new 12v battery and installed that. I got everything back together and took it for a road test. It took about 30 mins before the triangle came back. I grabbed the codes and it was still indicating bad blocks. P3011 and P3018. I am a little at a loss.
View 3 Replies
During a highway trip three months ago, my 2004 Prius suddenly lost engine power, the red triangle Master Warning light came on accompanied by a warning sound, and then the Hybrid System Warning sign appeared on the Multifunction Display. I pulled off to the side of the road and stopped. I turned the car off and then tried turning it on again. Engine power was restored although the warning lights remained. We took a chance and carried on with our trip. The same sequence of events reoccurred about 10 times on our 1,300 km journey. I took the car to a Toyota dealer where they found a C2318 DTC. They checked the battery and the HEV fuse but could not locate the problem.
We returned home and on the way the same thing happened a few more times. My service manual noted that the description for C2318 is Low Voltage Error (Power Supply Malfunction) and the trouble areas are HEV fuse, IGCT relay, Wire harness or connector, or Auxiliary battery. Since the car was nearly 7 years old I thought I had nothing to lose by replacing the battery, which I did. However, on a short 150 km trip last week the problem appeared again, once while approaching our destination and once when we were almost home. There seems to be a pattern in that the problem appears every 150 km or so of highway driving. It has never done it while driving in the city.
View 19 Replies
A few days ago I was driving my 2005 Prius aggressively up a mountain road and all at once the hybrid system warning light, the triangle with the exclamation point, and the regenerative brake system warning lights came on.
After about 2 minutes parked, I restarted the car and the regenerative brake system warning light went off, but the other two were still on. I still drove it twenty miles home, over another substantial mountain gap (about 1000 ft up and another 1500 down), without any problems.
I checked the voltage of the 12v battery, which seemed to be on the low end, but OK. (I think the lowest reading was 11.9). There seemed also to be some turbulence in the inverter coolant reservoir.
I brought it into the electronic vehicle specialist in town here today, who pulled my codes and said that the hybrid battery was dead.
View 5 Replies
Possible hybrid battery failure in my 2004 Prius (96K miles).
Sunday before last, the check engine light, warning triangle, and hybrid warning light came on when I started my car at the grocery store.
Because I was close to home, I drove home and the car functioned completely normally. The next morning, when I started the car, the same warning lights appeared. However, when I tried starting my car with the headlights off (I always leave them on), no warning lights appeared.
I took my car to an independent mechanic. This is their written report:
"Found multiple check engine codes, P3000, sub code 123, V0100 sub code 211/330. These codes are set when high voltage control detects a malfunction in battery pack/ECU assembly. To check battery pack we took vehicle out on a test drive while monitoring the cells in the battery pack. Found that they are all weak and drop fast when battery is put under a load. Code C2318 is a low voltage error/power supply malfunction code with the auxiliary battery. The voltage spec for setting the code is 9.3 volts, this battery is less than 9.2 volts."
In conversation, the mechanic also told me there was significant voltage variation across the cells in the hybrid battery.
I then took my car to the dealer to try to confirm this analysis. They were unable to read any codes because the independent shop apparently cleared them. The dealer was unable/unwilling to do more than read the codes to diagnose the problem. (Indeed, they seemed surprised that the independent mechanic could monitor the cells in the pack.) All they did was to drive the car around some more to see if the check engine light would come on. It did not.
The car has been driven 80 miles since the warning lights last appeared and appears to be behaving normally. From your perspective, does the report from the independent mechanic make sense and is it believable? And is their test under load definitive of a hybrid battery problem? Could the results be affected by the low auxiliary battery? Also, if I do have a hybrid battery problem, what are the chances of being suddenly thrown into limp mode while driving it?
View 5 Replies
My wife was driving our 2009 prius this morning. she said the red triangle, this other yellow circled, light with an ! came on plus in the display window the car icon with the ! came on. Manual states that this is a hybrid system failure.
On very cold mornings the car smells very hot for a period of time. She said this happened again.
I tried to do a reset (turning it off and on atleast 4 times) did not work. So I had it towed to a dealer tonight and I started it again and this time very hot smelling and a whole lot more lights were on, ( brakes lights, almost all of the lights I would say.)
View 10 Replies
I had my Prius check out and gave me these trouble codes couples battery's low he has a red triangle ....
P0A78
P3000
P0A80
P03014
P0315
The battery's rating 13.5 volts. Will always trouble codes go away after replacing the battery I added inverter to it because it was it was dying after 50 miles per hour then it slowed down??
View 3 Replies
I recently cleaned all of the corrosion off the copper bus bars on my traction battery. When I got everything put back together I went to start the prius up and got the red triangle. I then remembered that I forgot to plug the master orange switch back in. After doing so I still had the red triangle so I turned the car on and off a couple times and it went away. Is this normal behavior from forgetting to put the master switch back in an attempting to turn the prius on?
View 6 Replies
I've pulled the HV battery from my 2007 Prius with 144, 000 miles given recent Red Triangle of Death (P0A80) and looking to replace battery pack but want to rule out the ECU. I've searched the threads and found mention of testing the ECU but wasn't clear.
How to test the HV Battery ECU in or out of the car? Using a volt meter and light bulb, etc......I would really like to rule out the ECU before putting dollars in a rebuilt battery pack.
View 18 Replies
I changed my oil, oil filter, air filter at 90k for a trip to Miami this past weekend. Uneventful on the way up. On the way back, stopped and did some shopping before hitting alligator alley to come back home. As I got on the alley after paying the new $3 toll my 05 prius with 90k miles on it would not go over 65 with my foot on the floor and the battery on the mfd was in the pink. So I drove to the nearest exit, checked the fluids etc, all good. Got back on same thing so I put on hazards and stayed on until i could get off on a much slower road. I was going about 55-60 and it would go no faster.
As I got to a place I pulled over DC'ed the negative battery cable and let it sit for a half hour. I then attempted to get going and it seemed to be running fine until I attempted to pass a car and the car seemed to lock up and lose all power, check engine light came on and the red triangle light came on. I pulled over and let it sit again. I then got it to a gas station with the check engine light on. I put a few gallons gas on and tried to limp it home. It made it home and the battery seemed to recharge back to all the blue it can get to, but has yet to hit the green.
View 19 Replies
I have a 2004 Prius, the Red triangle came on intermittently and went off so I changed the 12V battery last night, after changing it the red warning light went off and everything seemed okay. Today while driving, the warning light came back on. I checked the battery voltage via diagnostic mode on the cars computer and the specs are what they should be. I noticed the following error codes in the computer:
01-D5, Sub-code: 190-30-8
01-DC, Sub-code: 190-B7-8
01-DC, Sub-code: 1C6-4D-F
Not sure if these are what is causing the problem.
View 2 Replies
Got the triangle of death after letting the car set during my 2 week vacation. P0A80 and Battery block is 14.17V all the rest above 15.35. That's a lot of money to repair a car. Not sure if I want to cut my losses and move on or replace it and drive as long as I can.
View 19 Replies
I bought a 2005 prii with 145k miles about a month ago and have since driven it 1,200 miles. A few days ago, the red triangle light came on when I started the car in the morning. I had to get to work so I unplugged the negative on the 12v and reconnected it. It started and it drove just fine. I get off work and the same thing happens. I did the same thing and drove home just fine. I then ordered a optima yellow top from elearnaid and it was shipped and arrived in 1 day!!!
I installed the battery this morning and called the dealer to notify them of my situation. The light didn't come on so I thought it may just be the 12v. But of course I didn't wanna run out of warranty and then the hv battery completely goes bad. The dealer tells me to bring it in and I did. They "diagnosed" the car and could not "repeat" what had happened to me. They said because I unplugged the 12v, it erased any codes. I thought it's always saved on the ECU? anyways, I told them about installing a new 12v battery and they said, "that must be it." I'm at 147k miles right now and I don't want my 150k / 10 year warranty to expire before something really goes wrong with the hv battery.
Am I just screwed and hope for the best for miles to come? Or is there a Toyota number I can call to tell them of the situation? I'm almost hopeful that it was only because of the 12v but at the same time, I have doubts.
View 10 Replies
Had a company install fog lights on my replacement 2007 Prius I picked up after I totaled my 2008. When i went to pick the car up, the car wouldn't start. Showed the triangle of death and threw a code that the 12v was bad. Probably from having the car off and testing the fog lights continually - resulted in a drained battery. I picked up a brand new yellow top optima battery and thought this would resolve my issues. Nope, once the batter was replaced, the car wouldn't go into Drive or Reverse, only park or neutral. The current code is P0A0D. The shop is baffled. They removed all modified parts and still can't figure out the issue. They are currently replacing the interlock plug in hopes that this will resolve the issue.
View 19 Replies
