Bunch of warning lights appeared and the dealer said it's code P0a80 and they recommend replacing the battery. I'd like to try to fix this myself and would like to hear your thoughts...
Plan is to check the traction battery for corrosion and use a voltmeter to test the cells and replace if needed. Prius 2004, 158,000.
I actually just bought a used 2004 Prius with 207,011 miles on it from out of state. I had a car shipped to me by a flatbed trailer. I just got the car the last weekend. However, It has a yellow engine light and a big red triangle with an exclamation mark (!) on a dashboard, and a red car with ! on top left of a display screen.
I drove it to a DMV to get it registered and took it to Pep Boys near my place since I have to get it an emission inspection within 10 days of registration anyways.
They ran a diagnostic test and found 2 current error codes (C2310-open/short in battery circuit & C2318-low voltage error) and 1 history code (P0A80-hybrid battery pack needs replaced), so they didn’t perform the inspection; otherwise, it would have a failed record). They told me that the car has had problems before and the problems are about a hybrid transaxle and a hybrid battery pack. They also told me that I need to visit a Toyota dealer to get them fixed in order to pass the inspection, and they warned me that is going to cost me a large four digit probably . So, they suggested me to just trade it in because it is not worth repairing. They also told me that a dealer who sold me the car probably would have done something to the car, that’s why it didn’t illuminate any warning lights before.
I tried to gather as much information as I could, so I asked the shipper if he noticed any warning lights but he didn’t think so; one thing he noticed was the hybrid battery isn’t charged because the engine started every time he moved the car.
I plan to take a car to another auto shop near my place as well in order to have them double check the issues and give me a repair estimate before taking a long trip to Toyota dealer.
I recently replaced my engine water pump at 164,000 miles on my 2007 Prius, the car sat for 3 weeks while waiting to gather needed parts, i.e., water pump, coolant and Airlift system for adding coolant fluid. After installing the new water pump the car ran rough for 5-10 minutes upon initial crank (parked for 3-weeks). I took a 20 minute test drive around the neighborhood that evening, outside temperature around 65 degrees F, and car ran fine. SOC looked ok, bars moving between Blue and Green, everything appeared normal.
The next morning, I backed out of my driveway and the Red Triangle of Death appeared on the dash so I parked the car.
That evening I hooked up OBDII ELM327 scanner using Engine Link and picked up 2 separate P0A80 error codes, 1 of them was pending. I disconnected the Aux battery for 3-5 mins to clear the error's, Red Triangle of Death was cleared, then drove the Prius for 20 minutes with no errors or alarms. SOC seemed to be normal. OBDII ELM327 scanner showed the HV batteries were charging at same level, 16.8V and Aux battery was registering at 14.0 Volts.
The next morning, after 20 minutes of driving the Red Triangle of Death appeared, and shortly after I experienced loss of power, with sporadic engine idle and interior traction battery fan was on. Luckily I had made it to work and was able to pull into a vacant parking lot.
I did notice that around the time the Red Triangle of death came on this morning the SOC dropped quickly to 1 Purple bar and was slow to charge then shortly after came the loss of power and sporadic engine idle followed by interior battery fan.
My 2007 Prius with 176k had the warning lights on the dash. I finally got the code read and it is the P0A80 code. The 12 volt battery seems good, it is about a year and a half old or so. That was the only code.
View 10 RepliesMy car has been fine with no changes besides tires last week, its a 2006 Prius and yesterday I got lights on my dash, went to auto zone for a read out and got an HV error code. I was wondering what is the most affordable route for my car to get repaired. I don't notice any mpg differences and everything still charges and recharges as if the errors don't exist.
View 19 RepliesMy Prius has started throwing the code P0A80, it all happened after I went away for work and left the car in storage for 15 days, during that time I left the OBD scanner plugged in and it drained the 12v battery, a quick jump start and it was back up and running.
While I was backing it out of the driveway the warning triangle came on and the MFD said "problem" the scanner showed the P0A80 code. I thought that was odd, but maybe related to the flat 12v battery and self discharge of the traction battery so I reset the code, it drove normally to the shops. When I restarted it and started to drive it threw the same code again.
I then installed techstream on my laptop to try and get some more in depth answers but was having trouble getting that running on Windows 8. So overnight I disconnected the 12v battery and would try again in the morning.
I got techstream working and connected it up to the car, connected the 12v and started it. While I was configuring techstream to graph the pack voltages I noticed something odd, the engine was being loaded and unloaded in 2 second cycles, and at the same time the inverter was whining as it does this. I was thinking maybe it's doing some sort of charge and measure cycle since the ECU's have lost any pack data due to the power loss of the 12v battery?
It ran like this for 20 mins or so and the engine stopped, techstream showed pretty normal cell voltages, I couldn't see any wild differences between the cells.
I just bought a used 2008 Prius. I had my Prius inspected after buying it, and the error code C1378 appeared, which I have discerned refers to the Skid Control ECU.
There is apparently a recall for this part in 2010-2014 models, however as a 2008 I don't think I apply.
Yesterday I got the "red triangle" and check engine light along with these 3 codes:
P0A80 - replace hybrid battery pack
P3019 - battery block 9 becomes weak
P3000 - battery control system
In April of this year I have the entire battery replaced, in September I got the triangle again and one cell was replaced under warranty. My warranty is good through April 2016, however I'm afraid that this new code P3000 is going to be something not included in my warranty.
What could potentially be wrong? This is a 2006 Prius with approximately 208,000 miles. I'm not sure this is worth it anymore especially if I have to keep putting in more money.
2005 Gen2 with 216k miles
Driving on highway and accelerated to pass a vehicle, sudden slow down and all warning/error lights went on. Pulled to side of road and used Autel 539 to get codes P0A78 + P0A90. Scan code reader does NOT display the INF codes, so I can not get them.
Turned off vehicle and restarted. Put into drive and it appeared that I could move forward (and reverse) and was apparently running strictly on the ICE - no power coming from the DC motor for assist. HV battery would charge as driving down road.
It was slow moving, but as long as I was accelerating (very sluggish!) was able to move forward. If I took foot off gas pedal then ICE stopped running and would not restart when pressing on gas pedal.
As far as the owner can tell, the car is running fine. He hasn't driven it aside from getting home after the light came on. It seems to give a very informative error message. What it's saying?
View 4 RepliesMy 2006 is doing some weird things. I have gone through a couple of HV failures and each time if I got the P0A80 code there was always an additional code telling me what was wrong. Not this time. Some times the battery will sit there while it shows that it is being charged and not take a charge. i.e. not come up off the pink bars, Sometimes it will charge all the way up to green and then fall off dramatically This is really strange because it is not showing any other code other than a crank cam sensor. The 12 volt battery seems to be ok.
View 2 Repliesand says replace hybrid battery! Its a 2006 w/ 249,000....say it ain't so?
View 3 RepliesWas driving home from school yesterday and my 2005 Prius turned the check engine light on and the red triangle light. Plugged into the scan tool it read: P0a80. I have a hybrid battery ordered. It should be delivered on Tuesday. How long can I get out of this failing battery before the car is undriveable? The Prius is my only vehicle and I don't have a problem with installing the battery, I just I'm wondering if the car will just drop dead on me before the battery gets here? The car appears to be driving normally with no loss of performance or MPG.
View 4 Replies2005 Prius. I just don't want to jump ahead to replace the hybrid batteries right away. Can I still drive the car, some place people say it is okay to drive then eventually it would get weird...
View 19 RepliesMy partner drove the Prius with 54,000 miles to work this morning as he always does. So he is on lunch and sent me a text saying some warning lights appeared on the dash while he was sitting at a red light. I asked if he had any loss of power, if the battery fan was running, he said it drove normally. We bought it last summer with 44,000 miles from a Toyota dealer. They said it had a new inverter pump. It has the original 12v battery however. Though it doesn't act weak at all. No issues this winter at all.
Note, the battery in the photo is at 1 bar. I asked him about it and he said he was driving aggressively to work today, which includes a 2 mile 6% climb he said he made at a high rate of speed... Though after the exit, he has another mile to work.. So the battery should have built itself up before him parking it.
My car was working fine except for occasional no dash lights. Unfortunately where my dash lights don't work sometimes I can't see my gas gauge and I ran out of gas today. I manage to make it to the gas station on battery power I presume. Filled the tank up with 11 gallons and the car seemed to work fine for the remainder of my trip(about 5 miles). So I parked at my destination and went inside for 30 minutes and then I went back out and started the car. I attempted to clear the out of gas error code and all of a sudden a whole Christmas trees of lights popped on my dash. I rescanned and these codes were read out
U0293
u0100
u0111
u0293
p0a1d.
History : I had the coolant pump inverter changed 2-3 months ago by a mechanic and hybrid battery and battery ecu changed 2 years ago by myself.
I had a 12v battery issue that I see common. 12V battery does not crank car. Jump car and works fine for a few days. I had this issue and it went away. Dealer said replace 12v battery, or just carry my charger pack with and use that unless it gets worse.
Jump ahead 2 months. I drive 50 miles each way to work 5 days a week. No issues. Yesterday, after my car sitting all day, I am backing out of driveway and get the red triangle. Code was P0A80. I looked it up. I cleared the code and was going to dealer if it came back. Today, after driving 50 miles into work, no issues, I get the red triangle. Code P3021. Fan started running back there too
My question : Would replacing the 12v battery useful for this issue?
Have replaced dead cells on wife's HV battery over a month ago. Threw this P0a80 code today and will barely move. She idles into dealership and they say it's the battery, really!
View 2 RepliesI'm guessing that I need to repair or replace the HV battery. But I'm not sure.
Today I drove for about 20 minutes with no issue. 10 minutes later, I got back in the car to drive again. This time, after about 20 seconds into the drive, a string of dash lights came on; Red triangle, VSC, Check engine.
The VSC light went away. But the red triangle and check engine light are still on. So, I had the trouble codes pulled by a mechanic, and the code P0A80 was returned along with a statement reading 'replace hybrid battery'.
Should I take this at face value? Or look for something else first?
2007 Prius - 150,000 miles
I have 2005 Prius with 300k miles. I started throwing P0A80 code. I removed the battery and checked all the modules and found 2 of low voltage, ordered them from Ebay and replaced them. I placed the battery back in the car and started the car but got P0A80 code again. I purchased the grid charger from Hybrid Automotive and connected it according to their instructions for 24 hours. I drove a car but got the red triangle again and P0A80 code again. I removed the battery again and tested the voltage of all the modules and these are the readings:
View 4 RepliesI have a 2005 Prius with 240,000 miles. About 4 months ago the triangle warning symbol appeared. A friend and I decided to pull the big battery out of the car and find the bad cells. We did that, replace two and the car worked fine for 4 months. The triangle warning has returned. We have done several things but the triangle remains. We pulled the big battery out and checked all of the cells. We replaced one that was probably OK. The latest reading was 8 volts on cells all but one at 7.9. We cleaned all of the bus contacts. We went into the maintenance mode on the MFD and found the aux battery to be 12.6 volts and under load it dropped to 11.8 with the lights on.
The aux battery went up to 14.1 volts with the car on. The inverter cooling fluid has movement and there is a slight humming which I believe to be the inverter pump running. The inverter fluid was topped off. The MFD showed the battery bars start at about three fourths full, drop down to one bar. With the engine running the battery bars climbed to the top purple. The engine turned off and the bars continued to climb to all green. All of this occurred in about 3 minutes while the car was parked. There were codes on the MFD while in maintenance mode. I understand that these codes are for the navigation system and the audio system.