Dodge - Grandcaravan :: 2002 - Engine Heat Transfer To Inside And Outside By Doors?
May 30, 2016
2002 dodge grand caravan. We feel the heat from engine block inside the two front seats (driver and front passenger). We also feel heated wind (blowing strong) and smell coolant when standing outside the vehicle by the driver and front passenger door with the engine idling.
There's visual small leak, once the vehicle is parked. I wonder where the leak is (not on radiator and the radiator coolant level remains full). I bought Preston Radiator Complete Care and Stop Leaks. I haven't put it in yet, just wonder if this will work.
View 9 Replies
Advertisement
I have an odd issue. I bought my car used from the dealer. The fuel pump was replaced last December, as well as had an oil change. The fuel pump died right after the oil change but are seemingly unrelated since the pump was bad when i bought it. After the pump was replaced my van stated acting up over the next couple days. The fuel gauge would dance randomly. That has since settled down. Now when i make left turns, the rpms drop and i have to pump the had to get it going again or else it completely stalls out in the middle of an intersection. .. it had been steadily getting more frequent and only on left turns. Right turns runs fine.
View 3 Replies
My car's heat gauge reaches to half and then stays there for the rest of the ride. When it reaches at/close to half, only then I hear a knocking sound while accelerating. However, if I press the accelerator only slightly OR full way down, then sound goes away. What is wrong with my vehicle? I have Dodge grand caravan 2006... (It has run 400000 miles)?
View 4 Replies
I have an 02 DGC with 187K miles. 3.8L There has never been any work done on engine or trans. We do regular oil changes and I just had a complete scheduled maintenance overhaul done about a year ago, including the trans. And as a matter of full disclosure, my wife and I are prob not considered "easy" drivers.
A few weeks ago, when I put the van in D, it won't engage. No problem with R, just D. After a few minutes it engages and off I go. If I warm the car up first, this does not happen either. And it won't happen the rest of the day. The only other "funny" thing it is doing is, when I slow down, there is a definite movement or catch as it shifts down around 20-30mph. It feels as though the gears are having trouble downshifting.
I took it to a mechanic and he said the life span on this trans is about 180K and so I need a new one. Does that sound correct?
View 16 Replies
My 2002 Dodge Grand Caravan transmission suddenly does not changing in gear This happened when I was driving. The engine light came one and transmission seems to stuck in a gear. Acceleration is fine but the van slows down quickly if I let go the gas pedal. Seems like it stuck in a gear. How to I troubleshoot and is there anything I can do at home?
View 19 Replies
I have a 2002 Dodge Grand Caravan and I am having an issue with it running a touch rich and not getting the gas mileage it should. Here we go, in March the van started to start hard and blow black smoke out of the exhaust. After a 120 mile drive back home, one morning it would not start. I pulled to a mechanic who went out and started it without a problem, he said it was flooded out and probably needed to change plugs and wires. I took it home and changed the wires and plugs. Much to my surprise, no change. The van started hard and then ran really rough with no power for a while and was polluting the air with black smoke. The average mileage was around 12 mpg. I went to the next step and changed the coil pack. No change. Finally took it in and the mechanic changed the O2 sensor and the cat converter. The can runs better but still gets around 16 mpg and still blows a small amount of black smoke. Oh yeah, the air filter is clear and there are no trouble codes either. I am thinking it could be a something with the fuel delivery system maybe?
View 1 Replies
I have a 2002 Grand Caravan, when foot is on brake, speedometer jumps all over, engine bucks so bad I have to put it in neutral or park at every red light. When I go forward, it jumps a little, and sometimes will not shift, engine revs up so bad, I have to pull over, shut engine off, turn it on and then it shifts. Speed sensors were supposedly replaced with the plug for them. It is at a dealership, they checked all the sensors, electrical wires, etc, and not it doesn't shift at all!! It is still there, now I have no van to drive. They claim they did nothing to it, it was shifting 90% of the time. It will not shift at all, even when I shut it off and re-start it. Now they claim it may need a new used tranny.
View 1 Replies
My 2002 Dodge Grand Caravan has a sound metallic rattling at about transaxle area (I am not sure if it's a transaxle issue) when it's cold but when it's at operating temperature, I don't hear it anymore. Fluid level is correct and clean, I just have the fluid changed. Shifting is fine, just annoying sound, not loud but it can be heard easily.
View 4 Replies
My 2002 Dodge Grand Caravan's most recent problem has baffled 2 garages so far. It is now in a 3rd one that specializes in auto electric issues. When I turn on the left signal it flashes a few times then the RIGHT side starts to flash. When I turn the right signal on you got it the LEFT side flashes! I installed a new multi function switch and NO CHANGE!
View 6 Replies
Upon cranking my 2002 Dodge Grand Caravan and driving app. 10 miles the speedometer and odometer will stop working and the motor will sound strained for the rest of the driving time. The rpm's go up and it dies from time to time when making a quick stop or turn. It starts right back up. The next day upon starting again the process starts all over. What's the problem?
View 1 Replies
I have an appointment next week at the dealer to have this checked out. My 2015 Grand Caravan with just over 30,000 miles, has been leaking a bit. Enough to make a mark on any spot I park in for longer than an hour or so. I placed a white poster board under the front end to see if I could identify where and what it may be. After about 6 hours, I checked and it seemed to have several drops of what certainly looked like engine oil. A dark golden. The leak seems to be located about 3 or 4 inches inside the front driver's side tire.This has been going on for just under a month. I keep checking fluid levels, and the engine oil doesn't seem to be diminishing at all, though it is a bit tough to tell exactly because it is clean and hard to see on the dipstick for this auto novice.
An attempt to crawl under didn't produce any real info, seems there is a bit of the oil anywhere in the area when dabbed with a white rag.Again I am a novice, so I am just asking what I should expect when the van is checked out. The car has had all needed maintenance at the correct intervals, though the last couple changes have admittedly been at a quickie place.My father, a former mechanic till retirement told me in theory there is no way to be leaking oil and not have at least some lowering of the oil level, obviously.Could this just be seeping so slowly to not notice a level difference? I know it is next to impossible to get a diagnosis here without a real inspection, but based on the location of the drips and the color of the liquid, any guesses would be great.I am 6,000 miles away from the end of the warranty, and we have a long road trip planned in a few weeks.
View 5 Replies
In May of this year (2015), it started to die. What I mean is it loses all electrics and it kills the engine. No dash lights, no odometer, no headlights, no radio, no blower, no electric windows, no electric locks, no interior lights, no visable sign that it has power at all except a tiny red light on the dash that blinks every few seconds.Always at low speeds under 30mph, usually while under load from either being on the freeway for a bit or while the AC was running or both. If I wait long enough, it comes back on all by itself but this can take seconds or hours. The radio is not reset, which is the only other indication that the battery terminals are not at fault. I am getting power to the starter, but nothing else.
When it first started happening, we thought it was a fuse or relay and swapped out several, but while it was dead, nothing affected it. It only happened three times until July when it stepped up its game and would die multiple times a day.Under advice of a shadetree mechanic, we replaced the Powertrain control Module (PCM) located behind the front bumper under the driver side headlight. This seemed to solve the problem for almost a month when the water pump decided to fail and we replaced it, the thermostat and radiator fan thermometer, only for it to die exactly as before only the very next day.The shop ran it until it died, took the pcm off and checked to see if it was overheating, but it wasnt. They checked the battery cables, fuses and anything else they could think of.
I got it it back at the beginning of October and on its first night out it died twice. I was driving it and noticed that it was a hot muggy day about 80F and because I was wary of it dying I chose not to run the AC, but the air coming from the vents was still quite cold. First time it died we popped the hood and the Eatx shutdown relay was hot enough to fry an egg. I replaced it with a spare I had, and all the systems in the van sprang back to life. It made it a mile before dying again and this time the new relay was hot, but all I did was wiggle it and back to life it went. Drove it 12 more miles home, then the next day back to the shop without incident.
I went to talk with the shop a couple days ago, because I really need this thing fixed but they are not sure what to do next. I told them about the AC running even while off and so we pulled the fuse for the AC clutch entirely. I ran it around for twenty minutes and even with the temp on the dash at normal hot position center of the gauge and blower at full tilt and set to hot with AC off, I had the coldest air until I hit a bump and suddenly I had hot air. Thinking the AC clutch was seized I took it back to the shop, verified that the compressor wasnt working anymore while engine was running and thought we may have fixed the issue.
Three days later, I have driven it all over with no issue, only for it to now die twice in a mile all within a mile of home. On the way home, the heater wasn't blowing as hot as it could be, until I almost made it to my freeway exit, by then I was worried that it was going to die after I had slowed down to the side road speed which it did happen.
I opened the driver door to get out and that was all the jarring it took to turn everything back on, the second time I had popped the hood and was reaching for the clips to the fuse cover to check the eatx shutdown relay when it all came back on. The relay was no warmer than the relay for the fuel pump. Between the first and second event, I could feel it hesitating every few seconds like it was about to lose power. After the second event I was so close to home I may have been a little lead-footed and did not notice.
Addendum: The bellows in the interior heater broke back on Valentine's day, so no matter what the dial it set to, it only blows out the upper body vents on the dash. The radio has an issue that it can no longer play tapes and one of the speakers is mostly silent. I wondered if either of these were shorting out and causing issue.
View 6 Replies
I have a 2010 Grand Caravan, and the engine just stops while moving down the road. Once you shift to neutral, the engine starts again easily. The only common thing we've found is that the skid control light goes on. It doesn't seem to happen when going more than 30 mph, and does seem to happen more when the temps outside are changing, but both when we get a warm spell or a cold snap. The recall work on the key assembly has been done, and the key always seem to be in the on position, so it's not that known issue. The local garage couldn't find anything or even replicate the problem. The dealership replaced the spark plugs and did a fuel system cleaning. Those were probably due, but they didn't seem to work much.
View 5 Replies
2010 Dodge Grand Caravan. On the way to work I was trying to accelerate from about 40mph to 50 mph and my van started to jerk a few times and then the check engine light immediately turned on. I only had a few more miles to work and it was fine the rest of the way.
View 1 Replies
This question concerns starting our 1997 Dodge Grand Caravan with 170K. The problem started about a week ago. When turning the key to start the engine, nothing would happen. No click, no noise, no engine turnover. By turning the key to off and then back on several times, the starter would kick in normally. The starter has never been replaced and I don't recall any electrical work ever being done on the car. I take it to our mechanic about every 2 years for a tune up and replacement of belts and hoses as needed.I have a friend that is a good shade tree mechanic and he is willing to replace the starter.My question is: Is the problem most likely a bad starter and if so, is replacement by my friend a reasonably easy task.
View 2 Replies
I had my car power steering lush at a repair shop! Unfortunately, power steering is too noisy (lot of air trapped). The mechanic fixed right away at the time I picked up my vehicle but still had some noisy, he suggested I drove for few days to get the air out. After a week driving and the air still trapped. I brought my vehicle back to the shop and had the mechanic fixed again! and this time I got power steering leak when I drove home! I returned to the shop and he said he replaced both bad power steering hoses. Noise was gone (engine was at operating temperature).
My power steering is still noisy at a touch of turning steering wheel (not even turn the vehicle), it's noisy when engine first started regardless the temperature outside. I drive my car for few blocks and the noise goes away. I won't bring my car back to the shop anymore, they may make it worse. Logical thinking, I think either the air still trapped deep inside the steering system or the O-rings at hose ends are defective. When engine is cold O-ring is cold and shrink, it does not seal properly and when it reaches operating temperature, O-ring expands and seals properly. That's my thinking, of course, I can be easily wrong. There's no power steering leak to the floor!
Will those after market power steering seal additives like Lucas 10008 and other fix my vehicle power steering issue? is there something I can do at home to fix this?
View 7 Replies
Our 1997 Grand Caravan with 170K loses more air conditioning every year. So, I assume I have a slow leak. Is recharging something I can do myself with the new type cans offered by auto parts stores? Also, I think the radiator fan no longer comes on, I never hear it and the engine temp will go up when driving slowly around town.
View 1 Replies
I recently had to replace my drive belt on a 97' dodge grand caravan sport 3.3 engine. The belt shredded and this is how i knew i had to replace it. Since i replaced it i notice a whine type of noise that increases in pitch as the engine is accelerated. The other thing I've noticed is that all electrically related operations work better as it is accelerated. For example, the air blows harder, the wipers move faster, and the lights brighten. Now i honestly can't say that it didn't do this before i changed the belt. I wonder if a bearing is going out on a pulley. I have noticed the same behavior on my daughters 98 sable. Also note that i did get all of the pieces of the old belt out from the pulleys and i did spin each of them to make sure the were moving without any resistance.
View 8 Replies
My 2002 Echo doesn't seem to be producing much heat. I have a scangauge installed, and it shows my temperatures around 75-80 C while our current temperatures here are around -20 C. I'm getting a bit of heat out of the vents but hardly enough to keep me warm.
I noticed that the coolant temperature will also drop a bit when I'm sitting idle listening to the radio before heading into our building at work. From about 85C to 70C, and the vents blow cold air.
My Radiator & Expansion tank are filled to proper level. I have just installed some cardboard inside the grille to try and block some of the cold air from entering. I haven't tested this out yet though.
View 2 Replies
I have a 2002 Dodge Durango and the rear passenger air blows cold only - was fine last winter. Neither the passenger or the driver controls will get warm air to the rear via the overhead vents. Warm air comes out under the front seats to the rear only.
View 1 Replies
I recently had my 1991 Dodge D250 with a 5.9L gas engine serviced and they recommended an internal engine cleaning with a machine they hook it up to for $160. The truck does burn and leak oil and they said it would work for both. I have seen videos on the internet with an HHO machine that some people swear by and others calling it a scam. Can it cause damage? I also saw videos of putting water in the intake with similar comments that it works.
View 15 Replies
