Ford - Ranger :: 1997 - Clunking / Rattling Sound In Manual Transmission At Random Times
Jan 31, 2014
I have a '97 Ranger with about 120k, 5 spd manual transmission, 2wd. For the last 2-3 months I'm hearing and feeling a clunking or rattling noise (I can't decide which it is) coming from the rear of the vehicle at random times.
I can't really predict or find a pattern of when the noise will happen, but it seems like it is most likely to happen when I'm either accelerating up a hill or when I'm braking relatively hard. It happens whether the clutch is in or out. Doesn't seem to matter. It does NOT happen when idling, only when traveling. I don't ever remember it happening at highway speed (65mph).
If I have my hand on the stick shift I can feel the shaking / rattling as it happens. There seems to be no impact on the performance of the vehicle - no additional trouble shifting into or out of gear, accelerating, or anything else.
On a recent trip I towed a 1,000 lb trailer and I did not feel or hear the noise at all during that trip (about an hour each way). Any guess as to whats going on?
View 5 Replies
Advertisement
It started sputtering at random times a few days ago and the check engine light came on. The two codes are p0401 (blocked egr system) and p0402 (egr valve stuck open). It seems to do it most when it's cold but some days it'll do it non stop.
View 1 Replies
It clunks real bad at random times. Whether I have had the e-brake on or not (sometimes even with it on, so I have not put any load on the locking mechanism in the tranny).
Its a 2014... Does not matter if its inclined ground or flat.
My 08 F350 V10 it replaces never once clunked.
View 14 Replies
I am considering purchasing a 1999 4x4 ford ranger. The original owner has receipts for everything done on it recently. Rebuilt transmission, New ac, New shocks, new tires. I have never owned a ford but I always loved my friend's ranger. The only problem I had with it was an occasional clunking/rattling noise when test driving. I have read and was told this can be a common problem.
View 1 Replies
My 2009 Impreza 2.5i manual transmission makes a clunking binding when I turn. What the issue is it goes away and comes back.
View 1 Replies
My transmission has recently locked itself up in reverse. The shifter can easily shift through 1st-5th but if i attempt to drive forward it is still in reverse and works against each other. If shifter is left in neutral position it is still in reverse. If i push the clutch in the truck will move freely. I have taken the cover off of the tranny and all of the gears appear undamaged. It was dry however, and i replenished the trans fluid but it still is stuck in reverse. baffled.
View 2 Replies
I have a 2011 Ranger with four wheel drive, a manual transmission and 34000 miles on it. The transmission gets very stiff after sitting for a while. At the worst I can't get it into first or reverse at all without hunting through all the other gears to find one it will shift into to get things moving. Is this normal for this vehicle or should I worry?
View 4 Replies
I currently own an mk6 gti with a manual trans... as of late I've been noticing a rattling noise when the clutch pedal is not engaged.. once engaged the rattling stops completely .. it seems to be getting louder and louder .. I am worried this could eventually turn into something worse than just a rattling noise .. i had a friend mention it could be the "throwout bearing" ..
View 9 Replies
I have a 97 Chevy Malibu V6 3.1L with 92k miles on it, a couple weeks ago i started getting a misfire issue. The car would start to misfire when under heavy load such as accelerating up a hill. The local auto parts store diagnosed it with code P0302(cylinder #2 misfire). I started by replacing all of my spark plugs(ACDelco Platnum) and wires. This seemed to fix the issue for a day or so, after that the misfire worsened. I would misfire at random times and when under heavy loads. This caused my transmission to keep shifting up and down followed by the all to familiar hot/melted plastic smell of overheated transmission fluid. This continued on for a few days as it got worse.
The car than started to misfire heavily all the time. I took the car to another auto store and it pulled up codes for Random/multiple misfire. I then took my car to a mechanic for a full diagnostic, their computer said their was a misfire on cylinder #1, as-well as a bad spark plug wire on #1( He found this by getting shocked while wiggling the wires on the coil pack) and told me to replace the bad wire. I replaced all wires again and the problem remained. i took it back up for re-diagnosis and they then said it was a bad coil pack. I replaced the coil packs and the problem still remains.
View 11 Replies
A friend has a 2010 ranger with the 2.3L with the manual transmission. He said that when he drives and the rpms are up he said he gets a grinding noise it doesn't matter what gear 1rst or 5th. He think throw out bearing but no noises at all until the rpms are up there. I was think internal like shift fork but don't know.
View 4 Replies
Lately I have been noticing clunking and rattling when driving my 2015 DSG GTI. It only happens under very light acceleration in gears 1 & 2, and is far more prominent when going uphill for some reason. I have almost 16k miles and have just been starting to notice the noise recently, and think it has gotten worse. I took it in to VW and replicated the noise for the tech, and showed him the video below. He seemed disinterested, said it was normal, and that it would not be worth going in to mess around with to try and fix/possibly replace the gearbox, as this could not solve anything and create more problems.
He also said not to worry about it because I have 60k on the powertrain warranty (which realistically isn't terribly long). This sound does not seem normal to me and it really annoys/bothers me given the car is only about a year old. The dealership is going to have the regional VWOA rep in so I can replicate the sound for him and it will be his decision whether they will proceed to look into it. I am looking for thoughts, comments, any opinions on this sound. Am I crazy and exaggerating, or should what seems to be my transmission not sound like this? At 30 seconds you can hear the sound far better, and a little later on I stick my phone out the window and you can hear the rattling more clearly.
Note (this gives me a little piece of mind): I asked a sales rep to test drive one of the 2015 GTI's on the lot and when doing this up hill you hear a similar, but significantly less noticeable rattle/clunk.
Link : [URL] ....
View 21 Replies
So I have a 2000 Buick, and it generally starts. However, twice now at random times the car hasn't started. It doesn't turn over, but makes a buzzing sound. The strange thing is, that usually after leaving it alone for a few hours, it will start as though there are no problems. I assume it's some kind of electrical issue, but I would love some input on the possible problems with my car.
View 2 Replies
I've had a rattling/clunking sound from my front left wheel recently so I jacked up that corner. As soon as the tire elevated off the ground the bottom fell inward. I could easily push the top of the tire inward and pull the bottom of the tire outward. Does this lead to a bad hub or bad ball joint(s)?
View 10 Replies
My truck is an XL V8. Transmission is Manual 5-Speed Mazda M5OD-R2.
I bought this truck literally two days ago. It seemed a little hard to shift, but no other problems. The truck had been sitting a short while, the guy said he took it on local trips, but nothing more. I noticed the oil and coolant levels were crazy low, so maybe it had been sitting longer or the guy was neglectful, I'm not sure...
I was driving it home and it seems like what can be described as: the gear ratio went completely out.
For example, 4th gear acted like 1st gear, 5th gear like somewhere between 1st and 2nd gear, so when I'm at 20mph, in 5th gear, the rpms are really high like im going 20mph in first gear (not 5th).
Today none of the gears engage at all... I dropped off a trailer at uhaul, and I got stuck there! (The truck is still there, I walked 4 miles home)
The shifter works fine, all gears sound like neutral (including reverse) when accelerator is pressed. Car won't move at all, nothing is engaging.
Underneath the car, there is a leak from the transmission assembly, maybe around the fill plug? It's only a small puddle. Maybe fluid, shift forks, bushes? or all?
View 8 Replies
My 2002 Ranger XLT Supercab Edge makes a clunking sound, but not every time, when I start going from a stopped position. It's coming from underneath right behind the cab. The Ford dealership could find nothing wrong. What this could be?
View 15 Replies
Why my suspension is so loud and clunky are doing a swaybar link and upper control arm replacement? I did remove the air suspension unit in order to access and remove the bolts that hold the upper control arm bracket mount onto the frame.
I did not think that would do any harm. Now my suspension is way louder than it ever was to begin with.. I just did a visual inspection and saw that my original parts were cracked and worn in the bushings and links. So I did a swap.
Suspension LS460 - YouTube
View 11 Replies
I have a 97 ford ranger V6 4.0. my 4x4 lights flash on my dash board 6 times and go out, a few minutes later it does it again. When I lock my hubs and put it in 4x4 nothing happens. What could be causing this?
View 5 Replies
I have a 1998 Ford Ranger, 3.0 4X4. Purchased in early 2002 with a clunking problem which has not gotten worse or better. When I take off it is a heavy double 'clunking' like something shifting and the settling. I have had 4 mechanics look at it, have changed the front u joint and have had the motor and transmission mounts checked but the mounts are OK. Can't figure this out. I talked to a person at a local car parts store and he mentioned that it could involve the 'yoke' and that it just might need to be greased but he was just guessing.
View 9 Replies
There is a clunking sound and feel from the front end of my 2007 Ranger FX4 when in 4 wheel drive. This happens sometimes but not always on engaging or disengaging 4 wheel drive, as well as sporadically while driving along. I took it back to Ford on warranty with this problem last year, and after a few attempts I had them admit that something was wrong and they finally diagnosed that it was the front drive shaft that was binding where it leaves the transfer case, this was replaced. I have now put maybe 50km (max) on in 4 wheel drive and the problem is back, I don't think the problem was ever fixed.
View 14 Replies
1997 Saturn SL ... It's like 3rd gear is where 1st used to be and 4th is where 2 used to be. 5th and reverse work but are more towards the center. It's as if the stick shifted over to the left.
Is it possible for the shift stick and it's linkage to become displaced? The temp did drop today about 40 degrees and it snowed but the car stays in the garage and was only parked at my work for a couple hours after a 2 mile uneventful drive.
No warning lights that I can see but the check engine lite has never worked. The engine is a 96 rebuild but the transmission should be a 97 like the rest of the car.
Great mileage and otherwise drives fine.
View 4 Replies
I have a 1997 explorer awd 4.0 sohc. have a problem when driving at 25 mph it makes a very loud clunk in drive train and will still make noise all the way to 60 mph. have pulled front drive line and rear drive line and drove and noise is still there I am guessing that its in the transfer case. I have also changed the gem module and had the drive lines checked for problems.
View 3 Replies
