Caravan/Voyager :: 97 2.4 - Shut Down While Driving / No Dash Codes
Jul 13, 2013
97 2.4 caravan dies while driving. Its been going on for awhile, coded at o'riellys and autozone several times. It started with having the camshaft and crankshaft replaced. Problem solved for a few days but it always returned.It would restart a few minutes later then it got worse. I called it the 30 mile van 'cause that's all it would go before dying or not restarting immediately.
Go to the grocery store, have to wait another 30 minutes to go home. Then it started only going a few blocks before shutting down while driving. I replaced the o2 sensor, the shutoff and fuel pump relays and finally took it to a shop that engine coded it. On their advice, they said the codes were all over, jumping everywhere, we replaced the ECM. It went 5 hours driving great then died and immediately restarted. Again no dash codes.
View 1 Replies
Advertisement
1997 Plymouth Grand Voyager SE 180K 3.3L
I read other threads about the connections under the hood, both sides, which I unplugged and replugged. I also pulled the IOD fuse for a little bit. Then I removed the cluster and looked it over. Looked good to me.
Got code P1698 for manufacturers assembly control or something to that effect. Thought I checked all the usual culprits. The dash lights work fine, so does everything else. The dash gauges just don't work. This is something that has been an intermittent problem with the dash gauges going out periodically when hitting a bump. It leads me to believe a connection. But I checked all those.
View 14 Replies
I have a 2005 Grand caravan with a 3.3L. Over the summer I was having issues with the transmission.Got the codes reaf, P0700 and P1726( I think). After this had an input speed sensor replaced and the TCM. The van worked for about 3 months, but now is acting up again. This time I got codes P0700 and P0704. Was told it was a clutch switch malfunction. Can't seem to find any details about this code.
View 1 Replies
I have a 99 Voyager with 88,000 miles. Brand new battery 12/12/06- won't start 3 weeks later - cleaned & protected battery connectors - still no start if left for more then 4 hours undriven Battery tested fine- being drained approx 2 amps- something left on...? Now there is a clicking sound under the dash before trying to start. Could it be some type of relay being left open or fuse or
View 6 Replies
I'm working on a 2008 Grand Caravan SE 3.3L Brake warning light (!) on dash is on. Datastream on my OTC Genisys shows that the Brake fluid level switch is 'ON'.
The van does not have pad wear indicators; fluid is full; there are no leaks in the system; no brake pull, uneven braking or other performance issues.
Scantool says Park Brake is off and I disconnected it to be sure.
When checking connector at switch on the master, one wire has continuity to ground and the other has about 12.5V on the DMM but won't light my test light.
View 4 Replies
I have a 91 grand voyager an every time I hook up battery there is a click noise coming from the relays behind the alternator near dash. I'm also having battery drain issues also an had alternator an battery tested, ok. Is this click from relay draining battery and what relay could it be? I switched them an had same click .
View 3 Replies
I have a 2003 Dodge Grand Caravan and while I was driving it stopped on me. It will turn on but once you put it in gear it will turn off and wont turn back on. I have replaced the fuel filter and fuel pump.
View 3 Replies
96 plymouth voyger se 3.3 6cly motor cut off while driving down highway or when stopped no check engine light...
View 1 Replies
I had to replace my swaybar links on my T&C due to it not passing state safety inspection. There was also some random noise that occasionally occurred on bumps. The tech said the "book" said to replace the strut and strut mounts but he could not see anything wrong. After replacing the swaybar links, there is now clunking while driving. I thought it was a lack of grease in the links but I greased them and while it got a little better...it still happens.
View 5 Replies
I am about 600 miles from home and when I was driving on the intertsate the battery light came on. I am in northern Maine where there are long stretches of nothing. I checked to make sure the belt was on and it runs fine. When I got to civilization I shut it off and it started and the light went out. Now I don't know if I should trust it or try and get to a dealer 70 miles away?
View 2 Replies
My wife has a 2000 t&c with 150k on it its a fwd with 3.8 and about a month ago while driving we noticed the rpms will jump up 400 and go back, with cruise control on or off being held at a consistent speed. and about for days ago it started shifting late. Still has all gears fluid looks o.k. and is full no check engine light .
I am hearing transmission solenoid, tps sensor, input sensor, output sensor, tcm, iac, map, or egr are all possibilities or a rebuild . Or simple as a flush.. tonight i went out n started it it idles around 800 tried to hold it at 1200 and it would for a second and drop back to 800 with accelerator being slightly held. Not sure if related. Just observed it..
View 2 Replies
My wife has been driving our 98 Dodge Grand Caravan the last couple of days and while she is driving the Tachometer and Speedometer will drop to 0. This does not affect the performance of the engine or anything else. Runs and drives "perfect" (or at least for its age and mileage). The dash seems to "reset" when she parks and turns off the ignition then restarts it.
View 2 Replies
My GC is overheating. Started as occasionally but now increasing in frequency. I find it will being to overheat after driving on the interstate for half hour or so but I can "calm" it back down but turning on the heat. I've replaced the following:
1. coolant (no drips or leaks nor am I losing coolant over time)
2. thermostat (twice)
3. temperature sensor
4. serpentine belt and tensioner
5. radiator (last summer)
6. water pump (last winter)
I notice the fans run more often than they should. For example, after a 10 minute ride to work in the morning,. I notice the fans are running as I pull into my parking space.
View 14 Replies
Issue on grand caravan 1996 happen, while driving all one time I hearing a clicking noise inside dashboard and abs+airbag and weather control, they stopped to work all in one shot .
View 1 Replies
2007 Grand Caravan SXT, 86K Miles
Factory Radio Clock, AM/FM, CD and Tape Player.
Radio and Clock looses power and completely shuts off and will not turn back on while driving. Miles driven does not seem to be consistent.
All other Electrical seems to work fine, overhead console, Wipers, Blower, Turn Signals, Head Lights, Instrument Panel all seems fine.
When car is shut off, Blower continues to run for a few seconds and then stops.
When car is restarted Radio/Clock magically comes back, clock is reset to 12:00 and radio is on AM.
Get some funny flashing of Idiot lights on cluster that to my recolection is not normal behavior. Once while my wife was driving it the Vehicle Theft Alarm Light came on when she started it up and it stayed on until she stopped and then started it back up when she left the store she was at. That has only happened once.
I checked the Battery Voltage while running and stopped and all seems normal. The Battery was new this December. I also checked fuses and there are none that are blown.
View 1 Replies
We just purchased a 2012 Grand Caravan and was wondering where to get a key and program it. I know the key will be an arm and a leg if i get it from the dealer. Is there a tutorial that tells how to program it as well?
View 3 Replies
2006 Caravan. Heat comes and goes every minute or so. Also noticed the temp gauge goes from normal operating range to cold and back again frequently. Hasn't overheated. Does that sound like a thermostat problem?
View 2 Replies
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
View 1 Replies
Recently I had the dash lights, A/C blower, electric windows all shut down while driving. The car still drove ok, but nothing worked on the instrument panel, electric windows. After parking it overnight at home, all seemed fine except for a message saying the airbag needs servicing. What could cause this?
View 3 Replies
What am i missing i have a terrible clunk in the front end when i hit bumps. I thought it was the struts and mounting plates so they are new . no change Stabilizer links were tight but i replaced them as well. Everything else seems tight but the noise has not changed with any of the above mentioned repairs.
View 13 Replies
I'm having trouble with my 96' 3.0L, its kind of crazy its intermittent and while driving the engines surges one or twice and then dies... when I try to crank it up again cranks but don't starts if I try again it wont even crank ( no starter winding up ) what I noticed is that is I'm driving when it dies my check engine light disappears for a while and if I connect my OBD 2 reader does not link up with the ECU if I wait a while and I crank it up again its starts and the while cranking up I can hear a bang noise from the engine compartment drives side and then after a couple of minutes dies again...
View 4 Replies
