Chevrolet - Malibu :: 2005 - Gas Cap Causes Check Engine Light
May 8, 2011
2005 Malibu 2.2L 4 cyl.109,000 miles
If I hit a bump too hard the Check Engine light comes on because the gas cap pops out. Dealer told me this is a common problem with many of the Chevy models earlier than 2007. GM doesn't have a solution, either.
Since none of these cars have a locking mechanism I decided to get a locking cap at NAPA because the locking mechanism would hold the cap in place. Nope! The locking cap is even worse.
View 13 Replies
Advertisement
After filling the gas tank yesterday, as I was on my way to work, the check engine light came on. For the last couple of days the temperatures outside have reached 118 degrees. I have checked the oil and coolant and have resealed the gas cap as well, yet the light still remains. The research I have done leads me to believe the problem may be the catalytic converter, but I'm wondering if there is any further troubleshooting I can do without heading to a mechanic.
View 7 Replies
When I tried to turn left yesterday, my car suddenly stopped with both the "check engine" light and "battery" light on, but the heat, headlights and radio were working just fine. I turned off the engine, and waiting a few minutes, ad then restarted the car, and everything is fine. I do not drive the car today. My question: is this a problem with the battery or the electric line? When the "battery" light is on, can i conclude it's a problem limited to the electric line only rather than a fuel line. My car is Chevy Malibu, 1999, with 90,000 mileages on it.
View 12 Replies
My 2008 Malibu service manual states that the check engine light should briefly come on when I start my engine. When the engine is cold this does not happen. Also, it happens infrequently when the engine is warm. My Chevrolet dealer says this is normal as the light checks out when tested. Chevrolet has not given me a difinitive answer on this. My concern is that if this is a problem it may surface at another time when the light should go on and cause damage if not attended to. If the manual says the check engine light should go on when the engine is started and it doesn't, doesn't this mean something is wrong?
View 14 Replies
I have a 2006 Chevy Malibu 125,000 miles, 2.2 Engine that was running sluggish, noisy like needed oil (checked didn't) and check engine light was on. Took it to a repair shop and told needed an oil change, car still ran sluggish, told to drive it a day or so. Two days later, car wouldn't go over 50 mph, took it back and told needed air filter and mass air flow cleaned. After they did that, they told me the Catalytic converter needed replaced however they don't do that work. Within a week car would not run so had the cat replaced.
Car ran better but still not great. Took it to another place, spark plugs replaced, throttle body cleaned and fuel injector cleaner added to gas.Still the car ran sluggish and was making noise and check engine light was on. Took it to parts store to have code checked on check engine and said error in bank one of oxygen sensor. I replaced that, reset the light and am sure you know, it still runs bad and noisy and check engine light came back on. I am losing power on hills and big hills the engine rattles.
View 5 Replies
Started having problems with my Chevy Malibu (1999, with 95,000 miles on it) while driving two times this week. Both times an alert warning flashed on my dashboard. The first time, flashed the brake check and ABS warning on the left side of the dashboard, and the second time the check oil and check battery warning on the right side. In both cases, after the warnings flashed, the car was still running, but stepping on the gas pedal resulted in no acceleration, but brakes still worked. The steering wheel also locks-up to the point where I can't turn any more. Both times, I stopped and shut off the engine, waited about 30 seconds and restarted, after which everything is fine and normal. The brake pads were changed recently, but not the rotors which may not be in very good shape.
View 14 Replies
I have a 2001 malibu , my cars engine light has been for about a week. This is the second time it has happened. lately I have been having trouble starting my car. Does this have anything to do with my car , or because of the cold weather? How important is it for me to get my car checked out?
View 2 Replies
I recently replaced the head gaskets in my 2003 Malibu. First time and all seems other than it runs rough at stop lights. The check engine came back on and so I had it read and there is an air flow issue. Is there anywhere that I can get a schematic for the vacum lines? I have all over and cannot seem to find a loose or broken one.
View 3 Replies
2001 with the 3.1 6cyl. First thing that started this nightmare is I was noticing a bit of a hiccup after driving for a couple miles. We've only had the car a few months and not sure what maintenance was done so we thought maybe it needed a tune up. Before I got the parts the check engine light came on so I went to parts store to get it read, it was P0302.
Did the wires and plugs and it got worse, the code wasn't p0302 now its just p0300. But after the plugs it also started idling really rough and would be slow to shift. Once it tacked up high and wasn't speeding up. That was only once tho. Also now it has no power its like driving a 2cyl ...
Anyway we decided since the first code said 2 we replaced coil 2, no luck..ok, fuel filter and fuel injector 2, no luck. Also has cleaned various things Im not sure of the technical name for..sensors and air filters and other things.
None of this has worked the car still idles very bad and doesn't have the power it should have. Also cleaned things on fuel rail(?). He is in the process of replacing the crank sensor as someone said if it was all the way bad it would throw a different code but it may just be faulty.
View 10 Replies
I have been dealing w/ a broken gas gauge for a while and have been monitoring my mileage and fill-ups and have been able to calculate my gas usage pretty well, however sometimes I may get a little lost on where my level is at. I just recently have been using a long plastic tie strap that reaches the end (I think) of the gas intake and I believe hits the gas tank. (Its goes in about 4' and I cannot push it any further at that point)
My question is when it comes up w/ no gasoline on it I am wondering how many gallons are remaining. Looking at a diagram of the gas tank it looks concave, where some of the gas may sit lower that where my tie hits. But I am almost certain that I have at least a few gallons remaining. For safety and other reasons this is not something that I am doing often, its just in this case I am a few miles from a gas station so I do not want to risk it.
View 5 Replies
My car is idling hard in reverse, and the mechanic said, in fact, a problem with the transmission (a turbine?) Well, a new transmission costs much - so, not much savings there. I was told to try some simple fuel injector cleaner first. Chevy Malibu Classic, 2005....
View 4 Replies
When I brake I get a rhythmic noise that starts like a quiet chirp and by the time I have completely put the brake pedal down it sounds like a loud grinding noise. It is a rhythmic pulsing noise, not continuous. I recently got new rear drum brakes, and 2 garages said my front brakes were fine. One guy said it could be the wheel bearing but I looked online and it says that happens when you accelerate, not when you brake. It only happens when I brake at relatively low speeds. In other words if I'm on the hiway and brake to slow down from 70 to 60 or 40 to 30, it won't happen. I also feel vibration in the brake pedal, but only when I have almost completely stopped.
View 1 Replies
I have a 2005 Malibu. After two alignments, a front wheel alignment by an independent shop and a "four wheel" alignment by the dealer, my car still pulls to the left at highway speeds. What else could be the cause of this? Bought the car with 22,000 miles and now have 80,000 plus. No accidents; don't understand what is wrong.
View 4 Replies
2005 Malibu Maxx, automatic transmission, well maintained mechanically. About a year ago, while driving up a small hill, my display panel starting dinging and all of the lights came on and my steering felt like it was losing power. After I got to the top of the hill, all the displays went off and bells stopped dinging. I've had the codes checked at the local dealership and the only thing found was that one of the battery cells was low. We replaced the battery about 3 months ago and that hasn't stopped the battery light and bell from coming on when driving up any incline. It still feels like I'm losing steering in these instances. I also tend to accelerate when going up a hill, so I don't know why that would be a problem. A recall has been issued for my car, but I'm not sure if it has any bearing on this problem.
View 9 Replies
I own a 2005 Chevrolet Malibu and am having issues with the driver's door not being able to close. I live in Michigan currently, and the weather here is very cold. When I first start my car in the morning, the door will not latch to the car. It just bounces back after you pull it closed. However, when I get to my destination, whether it is 15 min away or 45 min away, my car door will close. I've tried WD40 on the latch thingy to work with lubrication, but it is to no avail.
View 6 Replies
Why does my car front end shake when I go pass 65mph steering vibrates & everything inside does to then you can feel that right or left tire shaking not to sure....
2005 chevy malibu classic....
View 6 Replies
I have 2005 Chevy Malibu that has been making slightly metallic thud noises while turning. The car does not need to be in motion, but will make the noise in both forward or reverse in both directions. The noise is gradually increasing in loudness. I have inspected the CV boots and verified that this car has electric power steering assist. The dealer would not look at it, stating that the "Malibu's do this". Additionally the service rep stated that "if he had it checked out they would not find anything anyway." This noise does not sound like anything that should be ignored and sounds like major failure / safety issue pending. I can find no consensus on what might be wrong?
View 4 Replies
I have a 2003 Chevrolet Malibu LS.
The bulb for the parking light on the right headlight doesn't come on, it only comes on when the turning signal is activated. I'm not sure if it's the bulb or the fuse? If it's the fuse, do I need to buy electrical gloves and disconnect the battery before I "operate".
View 7 Replies
The ABS light in my wife's car goes on and off intermittently with no apparent. The car has about 47,000 miles on it. Bad connection, computer going haywire, loose or corroded wiring?
View 3 Replies
I have a 06 chevy 3500 express van with a 6.0 engine. The engine light came on about the O2 sensor bank 1 sensor 1 and bank 2 sensor 1 came up on the on the scan tool. It run great. how do I fix it
View 4 Replies
Wanting to no what the inlet and outlet ports for heater hoses on a chevy 350. I have a air gap intake with the the four water hoses 2 in the front and to in the back and of course the one on the water pump.
View 1 Replies
