Elantra XD (2001-06) :: Noisy Flex Pipe Exhaust
Jun 28, 2015
How to replace this bad flex pipe....
View 25 Replies
Jun 28, 2015
Advertisement
Passat (B5) :: Flex Pipe On Exhaust Is Cracked And Completely Broken
So the flexpipe on my exhaust is cracked and completely broken, so my passat sounds like a Mack truck. I've been looking into getting it fixed and I've been told i need to buy an entire new down pipe. Should i attempt to just get it fixed or buy a new down pipe.
View 4 RepliesGolf IV / Jetta IV :: 2002 - Exhaust Leak Coming From Either Manifold Or Flex Pipe
So I did the seafoam trick and I came to the conculsion that my exhaust leak is coming from either the manifold or the flex pipe. There was no smoke coming from under the car only a mist of smoking coming up from the back of the engine, probably by the manifold or the flex pipe. I do not see any visible cracking per say. I have attached a picture of the end of the flex pipe and it almost looks like someone may have tried to seal it before? I don't know if that is normal or not as seen in the picture.
2002 Volkswagen Golf 2.0 ...
Elantra XD (2001-06) :: Exhaust Leak Between Front Cat And Connecting Pipe
I changed my front catalytic converter yesterday. Everything was installed properly and the repair went smooth. Unfortunately when I started the car, I discovered the connection between the bottom of the cat and the connecting pipe was leaking out a ton of exhaust. The previous cat didn't leak like that. I put in a new gasket and tightened the bolts extra tight but the leak is still there. The worst part is that the leaking exhaust fumes are all traveling up into the hood, which makes it look like the engine is smoking. What should I do to stop the leak? I even tried using muffler tape but that only worked for an hour until it hardened and sounded like crap.
View 3 RepliesElantra XD (2001-06) :: 2004 - Leaking Metal Coolant Pipe Behind Exhaust
As shown in the photo, the metal pipe that runs behind the exhaust manifold is leaking coolant. I can't see the leak (obviously), but I can feel it with my hand (after getting burned on the exhaust!) It is NOT leaking from the right hand clamp of the metal pipe. How do I remove this pipe to inspect? Do I have to remove the exhaust to get to it, or simply remove the right side clamp and some bolts?
View 15 RepliesCamry :: Crappy When Accelerating - Flex Pipe Replacement
I think I need my exhaust flex pipe replaced. My car sounds so old and crappy when accelerating. Is there anyway I can cut this out and replace it myself without welding? If I do need to take it somewhere can someone recommend a good replacement part? Here is a pic of it....
flex pipe camry 5.2.2015
Golf IV / Jetta IV :: 2004 1.8T - Flex Pipe Leak / Rusted Out
I have a 2004 1.8t Jetta with a rusted out flex pipe. The leak is causing a bad smell and also a lot of noise -- What's my best option to replace the downpipe (but also other parts if need be) without having to weld it?
View 6 RepliesSonata NF (2006-10) :: Check Engine Light Won't Go Off After Replacing Flex Pipe
I recently had my 06 Hyundai Sonata 3.3 v6 brought into my local repair shop for a flex pipe replacement and ever since I got it back the check engine light has come on. I brought it back in, they said the 02 sensor needed replacing, replaced it free of charge, got the car back light went back on again and they said this time they put the wrong sensor in so they replaced it, now the light is coming back on again. It seems to go on for a day then go off for a day. I've only had it back for about 3 days so far.
Could this be perhaps the 02 sensor needs to break in or the computer needs time to reset or something like that? What could be causing this issue? Should I wait a couple more days before bringing it back in to have them.
Ford Escape / Hybrid :: 2008 - Flex Pipe Broken / Replacement
My flex pipe recently broke, and as a temporary fix I pieced it together using a universal flex pipe and some exhaust tape and clamps. When shopping around, I came across this:
Walker Exhaust Pipe 50465 - Read Reviews on Walker #50465
Is this an OEM part for a 2008 ford escape 3.0? It looks somewhat correct, although I do not remember seeing the other two fittings in that picture on it. (It looks like the end with the flex pipe is the end that connects to the catalytic converter, and the other two connect to the front and back headers on the engine, but I don't recall seeing a fitting like whats on the end of that flex pipe on my car (It could be that it was cut off, too).
If this is the OEM one, then perhaps the original exhaust shop cut off the fitting between the cat and where the flexpipe attaches. Is there a way that I can get parts to re-make this section of exhaust so that I can use this piece? The flex pipe they originally put in was too big and it came loose again forcing me to have to rig it again since I can't weld, and needed to get it fixed quickly.
I really do not want to replace the entire exhaust system if I don't need to, and hoping I don't have to.
Elantra MD (2010-15) :: Rattle In The Undercarriage - Exhaust Resonator Pipe Replacement?
I had my E in for service today to get her fluids changed and to replace her engine oil with Synthetic finally (second service for her).
I had noticed a rattle in the undercarriage for a few weeks now and assumed it was a common TSB for a heat shield that rattles. As it turns out, it is the resonator pipe that needs to be replaced (under warranty). I've never had to replace one before so hopefully it's just a one-off!
Otherwise, I can already tell she's happy to be filled with some wonderful Synthetic...
Elantra MD (2010-15) :: Exhaust Pipe Blows White / Gray Smoke When Accelerating
My Elantra is at 14k miles and it has happened twice now that the pipe has released white/grayish smoke when accelerating abruptly (pretty much forcing the engine) on the highway above 60mph. I can see in my mirror that it leaves a pretty big smoke screen behind me.
I took it for an inspection after the first time it happened and the mechanic said it might have just been steam and that I should not worry about it. Since my 15k maintenance check is coming up, I will ask that they actually check on it.
I'm also curious to know if this could cause me to get a ticket? I'm thinking I could get pulled over for "imparing the vision of drivers behind me and making it dangerous for them", or something like that.
Ford Super Duty (1999-2016) :: 2001 F250 5.4L - Smoke From Exhaust Pipe
2001 F250 5.4L - I recently had my muffler changed and the pipe flange on the tailpipe up by the exhaust manifold welded back on. I haven't driven my truck much this past summer so when I took it in to get the muffler fixed the front caliper got temporarily stuck like it tends to do. It eventually freed up but in the meantime I noticed a hot oil-like smell coming from my truck from time to time. I chalked it up to either the new muffler or maybe it just smelled hot and it was instead the front brake caliper still being stuck. One day I'm driving down the interstate and I start uphill. I noticed smoke behind me and pulled over. The brake was not overheating so I got underneath the truck.
The smoke was rolling off of the exhaust pipe all the way down it all the way up near the manifold but mostly around the muffler. The smoke quickly went away while I was under the truck. I noticed it doing this only while the engine is under a load like going uphill. Just driving around town nothing is noticeable. When it does smoke I lose power. Once I slow down for awhile and then gradually speed back up things seem okay. I checked the oil.
Normally I don't lose a drop but this time I was a quart low but the oil on the stick was clean. It's been awhile since I had my oil changed but very little mileage on this change (my truck has sat awhile). My truck doesn't leave a drop of oil under it when it sits. From what I read you can remove the radiator cap and start the truck to see if it's a blown head gasket. At least that one of the things I can check easily without actually taking the plugs out even though the oil looks clean. The radiator has not lost any fluid. The transmission fluid is also good. It's been doing this for about 3 weeks.
I still drive it to and from work (about 15 miles round trip) everyday but I take it easy on the acceleration and stay on city streets. I looked into the EGR system online for my truck and instead found an EVAP purge solenoid/valve in its place on the passenger side. I don't have any service lights on the dash. I went to Autozone and had them scan it but nothing came up. I read somewhere that either the purge solenoid assembly or EGR (I can't remember) can burn up the board if it goes bad resulting in no code showing up.
I recently changed a vacuum valve out that went bad that controlled the vacuum chamber used to operate the hubs on the 4WD. The 4WD is now operational again. Assuming the head gasket is not blown, what to check for next?
Elantra XD (2001-06) :: Noisy Lifters On Startup
My 05 beta 2 (CVVT) lifters are a bit noisy. On startup its a bit loud but quiets down after it warms up, but its still there. Kinda sounds like it needs a valve adjustment. Not sure if there is another way around the noise. Like a full synthetic or a heavier weight oil?
View 2 RepliesElantra XD (2001-06) :: 2002 GLS Wheel Bearing Noisy When Come Into Corners
My 2002 Elantra Gls 1.8 got some weird sound coming from all 4 corners of the wheel... Recently I had replaced the front wheel bearing as the car goes very noisy when come into corners... But there still some knock... knock... sound after the car warming up especially from rear wheel.
I replaced all 4 absorbers 1 year ago as well as the tie-rods end... Still facing the same problems, the mechanic also don't know where to start...
What should I replace to settle the problem??? All the rubber bush??? Recently mileage on my car is 190000miles.
Ford - Taurus :: 1993 - Exhaust Clamp Between Resonator And Exhaust Pipe Came Off
I have a 93 ford taurus 3.8L V6 automatic GL. The exhaust clamp between the resonator and exhaust pipe came off and I need to know what size clamp I will need to replace it. I think it is a 2 inch but I am not sure.
View 1 RepliesFord Exhaust System :: Exhaust Pipe Cut Just Behind The Rear Of Cab - No Muffler
i have my 4 inch exhaust pipe cut just behind the rear of the cab right now with no muffler. If i cut it further up maybe jsut under the front seat or so what would this to the sound? would it make it deeper or louder?
View 7 RepliesFord Exhaust :: Crack And Subsequent Leak In Exhaust Pipe
Actually developed a crack and subsequent leak in a pipe running lengthwise, so assume the factory weld over the years went bad. Since it would be a weld overhead, wonder what method would be best? Would oxy acetylene work or mig? I don't have a tig so that not an option for me.
View 2 RepliesElantra XD (2001-06) :: Exhaust Has Been Getting Louder
My car used to be quit as a mouse, but over the last couple of years it has been getting louder. I feel it is something with muffler....When i look under I don't see any holes...I have 145,000 miles on it...Do these models, as they age start sounding louder.
View 1 RepliesGolf IV / Jetta IV :: Exhaust Pipe From Cat Back?
Putting a straight pipe from the cat back on 1.8T mk4? I was thinking going 2.5 inches from the cat back with a tip. But I wanna know how loud it is.
View 6 RepliesElantra XD (2001-06) :: Exhaust Leak Sound From Engine Compartment Only At Cold Startup
I hear a bit of exhaust leak noise from engine compartment only at a cold startup, it goes away in seconds. I am 700miles from home. If it's a nonessential fix i will drive home before fixing, or, if an easy gasket replacement, I have two more days here, and tools,garage, and competent support to diy the job.
View 4 RepliesPassat (B5) :: White Smoke Coming From Exhaust Pipe
I have a ton of white smoke coming from my exhaust pipe only after it ran a long time then is started back up ????
View 7 Replies