Ford 6.0L Power Stroke Diesel :: Engine Stalling Related To Oil Leak
Aug 3, 2017
My 6.0 excursion has been stalling at stops, and in slow traffic for the past couple weeks. I've also had an oil leak (see my most recent post w pics)
Could those two things be related? The compression gauge shows its okay, What else could be causing the stalling? I just got a lead on a good diesel mechanic in springfield missouri (30 ) minutes from where i was today with the excursion, I don't know if i should risk a 2 hour drive back to springfield to take it to him.
I had the oil changed at a local shop last week and the tech told me the oil pan was leaking oil, but you can see on the pics I posted that that oil seems to be on hoses above the oil pan. So I don't know if the leak is coming from above or what.
View 14 Replies
Advertisement
I have a 2003 6.0 and I am havi g problems with it stalling once getting up to operating temps. I found a leak earlier after the engine stalled, it was leaking pretty good around a drop every 2 seconds but stops once the engine cools down some. I noticed the oil dripping from under the oil pan.
Can this be the cause of the engine stalling? Or just another problem? If it can be the cause where can the leak possibly be coming from?
View 6 Replies
I just had my 14 350 dually in for its 10k mile service. They told me I had a oil leak somewhere on right side of my engine. They cleaned it and put some die in it, told me drive and bring back so they can put uv light on it to see where it's coming from. I haven't had time to take back yet as I just started a new job, but I've put about 900 miles on it and it's definitely got a leak! I crawled underneath today and the oil pan right beside the oil filter is wet with oil. Trying to figure out what I might be looking at.
View 14 Replies
My 2007 F350 CC DRW KR has developed a serious oil leak recently. The oil runs down both sides of the bell housing but seems to be worse on the passengers side. It only leaks after five or so minutes of running and not while off. I have searched literally hundreds of threads and found only one that seemed similar and the resolution was never posted.
The truck is stock with only a turbo back 4" exhaust. I initially thought of the STC fitting failing and cracking the rear engine cover, but I still have very good ICP (650 almost immediately when cranking and at idle, 3000+ when on the throttle).
I plan to pull the turbo next weekend to check the drain tube and HPOP cover as well as checking/replacing the STC fitting (since I'm in there).
View 1 Replies
Was replacing my cracked and leaking charge air cooler pipe Friday evening and noticed oil all over the place at the lower front of the engine. It has been a few months since I've been under the truck. No drips on the ground so it must be a slow leak while driving. Oil level is fine so it hasn't been leaking for long.
Any ideas from this limited two picture view? Front main seal? I've been reading the vacuum pump leaks oil as well but I'm not sure where that is other than driven by the HPFP. I took additional pictures but those were useless, it's a bit cramped in this area.
In the past ten months I've had the turbo coolant inlet pipe leak repaired and then the DEF heater failed, which means replacing the entire pump of course. The wastegate solenoid air compressor noise started some time ago as well at shutdown but I haven't been concerned about that (it doesn't seem to cause an issue). 96,000 miles.
View 5 Replies
Noticed oil on the underside of the engine last oil change, took to Ford dealer for repair under extended warranty. Got a call back today, stating the the oil leak is coming from a injector on the drivers side, and that the injector seals is not covered under warranty. I'm having an issue understanding that oil leaking out from around the injector is not covered under a power train warranty.
View 2 Replies
I have a 06 f250 that has a coolant leak in the front of the engine. It's was leaking about a month ago replaced the water pump it stopped. Then about 2 weeks later it started back up again. It only happens when the engine is cold. But once it warms up it starts leaking again. I am confused as all get out on this.
View 1 Replies
I'm dripping fuel on top of the engine at the fuel filter . Where the line ties into the filter canister , there is a small plate that's attached with small Allen screws its dripping between this plate and the canister .... I assume there is a gasket/oring that is causing it ...... What is the part number or correct description so I can go to ford dealer and get one.
2007 Ford 4X4. 6.0 diesel
View 10 Replies
I've had a persistent diesel leak its gotten worse and I've found it. Its in the valley of the V. I've attached a photo of the part its the one with the plug off it.
What it is called and maybe the part number. The gray plug under the red wire.
View 5 Replies
I started having an oil leak under my truck in the last week or so and when I went under the rig briefly (it is raining here) it looks like it may be either coming from the oil pan itself or the seam between the tranny and engine case.
I thought I'd try the easy solution by torquing the appropriate bolts. Looking for the torque specs for these two sets of bolts or have any other suggestion where the oil could be coming from?
I have ~130K on the truck.
View 9 Replies
I just purchased a used f250 6.0L a week after having it i noticed a small oil leak slowly got worse (looked as if it was coming from the too rear of the engine) then noticed about a half quart of oil under my truck. While driving it home the oil pressure gauge kept dropping then going back to normal then eventually dropping for good. The truck still ran so i drove it to take it to the mechanic but then the throttle began to become unresponsive and then gain power again then finally the truck shut off and wouldn't start again, blowing oil all over the inside of the hood and top of the engine. I checked it and noticed the pressure sensor pigtail were fraid so i replaced that along with the sensor and added oil but still wont start.
View 10 Replies
I have a coolant leak somewhere on the top of the engine running down to the oil pan and bell housing. I have done some research and discovered it could be the coolant inlet tube to the turbo.
View 14 Replies
I have developed a leak coming from the top, driver side, rear of my engine and I could not figure out where it was coming from. I took it to a reputable shop for diagnosis and they tell me that the rear leak is coming from the transmission lines.
The weird thing is I never thought the leak looked like ATF. They also told me that it looks like the stock radiator/cooler has been bypassed so I have no cooler.
Should I assume that the stock internal cooler failed and that is why the PO bypassed it? Also is there a decent write up on deleting these lines and running soft transmission lines to a aftermarket cooler?
View 5 Replies
Turns out I've lost nearly all of the coolant from my secondary cooling system and am trying to diagnose the problem.
Things I noticed:
-All of the hoses appear to be in good condition.
-Coolant is dripping from the center of the engine bay.
-After inspecting the turbo area, it appears the valley below the turbo is wet.
The intake manifold is still on the truck, so I haven't been able to get a better look. Is there anything else near the area I am describing that has coolant? My guess is the turbo water inlet?
Perhaps this : Coolant leak on the 6.7 Powerstroke diesel - YouTube...
View 6 Replies
I recently purchased my 2011 F250 Powerstroke a week ago today with 87000 miles on it. the dealer assured me they did all the maintenance on the truck before i was able to drive it home. I noticed on my dash that it kept popping up i needed to change oil soon.. so i got out to investigate and realized i was about a quart low on oil so i looked around more and am seeing that i have a leak coming from the back of the engine running down to the oil pan.. I have not noticed any on on the ground at all but what this leak is coming from...
View 14 Replies
While servicing the bosses 121k 6.0, I noticed the coolant resevoir empty. It took 1 1/2 gallons to bring to proper level. Returning under truck to install drain plug, I noticed coolant coming from rear of the engine(right side). And of course Ford has changed the cooling system cap, so I wasn't able to pressure test it to pinpoint the leak. Started the engine and seen coolant coming from the left rear as well. I've been reading here to see what others have been seeing, (EGR cooler, head gaskets). With all the heat shields,not much room to look.
After work I did go and buy the adapter to test the cooling system. With any luck I will be able to see leak better.
View 14 Replies
So I started my truck this morning and it sounds like air rushing out from the driver side of the engine. I currently have my ICP unplugged due to a bad sensor, will be replacing it on Sat. Also I have been having an issue with my turbo but I don't think that it's related as I here the air rushing sound when at idle as well at when driving. It seems to be a bit louder when the engine is cold but I could also be crazy about that.
View 3 Replies
I have a oil leak that I can't seem to find it appears to be leaking down above the passenger side valve cover and then goes under the engine cover. I don't notice much oil in the valley. This is a 2011 f250 6.7 with 116000 miles on it. I have had no other problems with this truck. Could this be the turbo lines? I am on a RV trip several hundred miles from home so I have very limited tools. The leak doesn't appear to be bad at this point the valve cover is wet with a small drip but it's only in the middle. I just changed my oil prior to the trip when I noticed the leak. I did have a leak on the new filter but a new filter fixed that but still have this one higher up.
View 14 Replies
I have a small coolant leak coming from the passenger side near the back of the engine that forms a spot about the size of a dinner plate if it sits for a few days.
One thing I noticed is if I turn off the AC selector switch when I park I will get the drip but if I leave the switch on MAX AC when I shut the truck off I do not get any leaking.
It is definitely coolant and not just the condensation from use of the AC. If I haven't used the truck for a few days or if I have run it with the AC off I will get the drips.
If I run with the AC on and leave the switch in the on position when I shut the truck off it won't leak. I have tried to locate it from looking above and below but can't determine where it is coming from.
View 4 Replies
I've been having this problem for a while and seem not be able to get anywhere.. so at first my truck had a stalling when hot getting low icp which lead to a new hpop, couple injectors, dummy plugs, icp.
Ever since I got the new hpop, now when it gets to operating temps the low pressure gauge drops, and once you get on pedal it goes back up then eventually stalls. Then have to wait till cold.. the low pressure gauge will not drop till oil is warm. Does it sound like a low pressure pump?
It's a 2005 6.0 with 213,000
View 12 Replies
My 6.0 stalls out when under load above idle intermittently. When it stalls, if I release the gas pedal and tap it, it usually catches again but not always. ICP is strong and doesn't seem to waiver when it stalls. Engine runs much better when oil comes up to about 180. Oil / water temp spread about 5 degrees.
View 14 Replies
