Ford F-150 - 1997-2003 :: 2002 - Right Rear Brake Smoking
Apr 24, 2017
I have a 2002 F150 4.6 liter 2 wheel drive with 49000 original miles, 30000 of that in the past 2 years. on a recent road trip the right rear disk brake caliper jammed in city traffic. I limped into a local repair shop with the right rear brake smoking. I rolled out with all new rear rotors pads and calipers. The mechanic could not locate new brake hoses. These hoses and lines are one piece from the caliper to the T fitting on the axle. Even the ford dealer could not locate the right rear brake lines.
Made it home 450 miles but the right rear caliper is still dragging a little on the new rotor. Seems to be about 40F hotter than the left side. I have spent the day trying to find replacements and can find the left side in one piece but not the right side. I have looked at the the union where the hose and line connect and there is no hex on the line side of the fitting its just round. You can see where the mechanic put a pipe wrench on the round and tried to break the two pieces apart but no luck.
View 2 Replies
Advertisement
I've got an '02 F150 with a 5.4L Triton. Despite being 10 yrs. old it's just passed the dealer warranty mileage about 80,000 miles. Due to a family situation it's been sitting idle for upwards of 2 or 3 weeks between startups.
When I do startup there's a puff of blue/geyish smoke, the engine idles rough for about 30 secs. and then everything smooths out and she runs normal.
I haven't noticed this issue before, I would add the temps here have been extremely cold the last few weeks. What direction do I point a mechanic in so he doesn't waste time or money on a diagnostic.
View 5 Replies
Any recommendations on brake calipers and hose?
View 14 Replies
My truck is a 1998 F-150 4X4 set up for towing etc. The left front started smoking and the front end just started bouncing around very badly. Of course I pulled off and let it cool down. My question is this; I've pulled the hub and the bearings seem smooth although maybe a bit tight. I've checked the caliper and it seems to be working properly.
View 5 Replies
A few weeks back my rear drivers side wheel started smoking severely...when I stopped you could smell the brake material, feel the heat coming from the wheel, and lots of smoke. I speculated it was the parking brake that got hung up. I jiggled that cable around and then went around the block - no issue. Note: I did not leave the parking brake on.
It happened again a week later, but not as bad. I took it into the dealer today. They said heat was evident as it burned off a sticker on the disk or caliper hsg area. They have not determined yet if it is parking brake or caliper?
View 14 Replies
I have a 1998 f150 4x4 with a 4.6 triton vin #w and only 150,000 miles but its smoking. On first start up everything is good to go but when the engine reaches operating temperatures it will smoke.
It does not smoke all the time, just on takeoff. Such as after taking off after sitting at a red light it will puff a cloud of smoke from both sides of the engine. The engine is smoking blue so I know its oil its burning.
I pulled the valve covers off last week and the engine is clean, no sludge or gum. Power is good, runs good, and has good compression. Why its smoking.
View 14 Replies
After removing the tires, I can't figure out how to remove the brake pads to change them. How to do it? Does the caliper have to come off? These are on the rear. 2001 F150 4X4...
View 1 Replies
2002 F-150 4x4 w/ 5.4 v-8. Brake pedal goes half way to floor before it starts to stop the vehicle. I have replaced and bled the master cylinder, bled out all of the calipers, and the calipers are installed correctly because the bleeder screws are at the top on all of them so no air can be trapped up there. The truck seems to stop fine, but just takes more pedal to get it to start stopping than I'm comfortable with. Could the ABS unit need bled out too? Or could it be an adjustment issue with the booster rod?
Also, something else I noticed, and it may be related..the ABS unit usually makes a slight clanking sound (like someone kicking a metal garbage can) a couple seconds after the key is turned on. I know its the ABS unit because a couple weeks ago I had a friends scanner hooked up to the truck, and I went into the ABS computer to clear the codes (have ABS light on from what I found to be a bad sensor wire on the front drivers side according to the scanner) and as soon as i cleared the codes on the ABS, it made that sound. I don't know if maybe there is something wrong with the ABS actuator, or if it's related to the brake pedal issue.
View 3 Replies
What is the degree of difficulty in replacing the rear shocks on a 2WD 2002 F150?
View 14 Replies
I have 2002 f150 XL 4.6 L 2 wheel drive.Do i have rear discs?Need to change them not sure what to buy.
View 5 Replies
I've recently purchased a 02 F-150 4x4 with 135k showing. About a week after purchase 4 COP's were replaced to eliminate a skip that started the day I drove it home. After a few hundred more miles it started shuttering at take off, much the same as the trans shuttering usually in higher gears/speeds. Only does it briefly in 1st gear and occasionally it goes into 2nd, but stops immediately after shift. After about 10 miles it stops doing it and until the trucks sits awhile it stays gone. About the same time a popping sound started coming from the rear axle at slow speeds. It changes sides as you drive and turn, and sometimes goes away intermittently altogether. Also is it possible or probable the two are related ?
View 4 Replies
I have a 02 power stroke 7.3, driving down the road the other day is started smoking a grayish white smoke pretty good. i let off the throttle and it had a real loud knock along with the smoke. oil pressure was good. i stuck it in neutral and revved it up kept smoking but the knock would go away at higher rpm. then all at once it would stop and run fine. then today it started doing it and wont stop now at all.
View 14 Replies
When I lost the rear brakes due to a rusted line, naturally the ABS light came on. Will it automatically reset when everything is repaired and working or is there something else that needs to be done?
View 2 Replies
How does it come off. I wasn't able to turn the axle vent without turning the block on axle for the brake lines.
I would like to remove the brake system from my current axle without breaking any lines open, then putting a new axle in and put the brake system on the truck to the new rear axle.
View 2 Replies
I am in the process of re-assembling a 97 F-150 that was disassembled by someone else. Looking for photos or reference as to where the bracket for the parking brake should be located and how? It looks as if the bracket connects to the front leaf spring hanger, but I'd like to see a photo of it in position as well as routing of the cable around the spring and axle. I'm concerned with re-installing it and having it in a position where it will bind or get pinched.
View 1 Replies
ll, I changed out the master cylinder on my 2002 F-150, disk brakes front and back w/ ABS. Bleed all the air out and bench bleed the master cylinder. I have good pedal but the brake light will not go out.
View 6 Replies
The brake lights on my '02 F150 have started flashing spontaneously ie - with no one in truck. This lasts for a few minutes, then stops, but can start again a few minutes later. The fear of course is that someday lights could come on and stay on, resulting in dead battery.
I do have a trailer brake controller that has been on truck ten years. Read something on internet that brake pedal switch might be going bad (??). Any one else observed this strange behavior?
View 3 Replies
I noticed a few weeks ago when I was in the bed of my truck that the black plastic trim piece around the rear window appears to be broken. it's on the left side near the top. when I look down there it looks like the brackets are broken on one side. I've never noticed any water leak back there. I'd like to definitely get it fixed, but I don't think the dealer would have a listing for it anymore if it's not crazy expensive. I looked at LMC truck and there doesn't seem to be what I need on there. It's a 2002 F150 Lariat Supercrew non-sliding window.
View 7 Replies
I have an 02 extended cab F150 and whenever it rains the rear window leaks (it doesnt have a slider, it's solid) and the half doors leak too... i sealed the back window with caulk to try and fix it and it worked for about 2 storms and then it started to leak again. The side doors leak at the seam where they meet the front doors... Should i order new seals for the windows? or is there a simpler way to do it that isnt as expensive..
View 9 Replies
I have a 2002 F-150 extended cab and the rear door(drivers side) quit opening a few days ago. No warning--worked one day and just stopped opening the next. Are there any tricks to getting the panel off to ck. for trouble spots?
View 13 Replies
Last week my brake pedal started going to the floor when I stopped, it still stopped and felt fine on the top half of the pedal travel but then it would just slowly fade to the floor. I took it to a local shop and they said the master cylinder was leaking internally and my rear brakes were shot. I have 75,000 miles and the rear brakes were original so I told them to fix it. This is basically what I expected it to be.
They kept thinking they were getting defective master cylinders but after the two Napa parts and two Carquest parts they realized they misdiagnosed it and said I needed to take it to the dealership. I paid for the rear brake job since it needed done anyways and have an appointment for next week at the dealership. What might be causing the problem? I see no brake fluid leaks, no vacuum leaks, the booster was replaced 25,000 miles ago due to noise, no ABS light on, no CEL on, no other symptoms.
View 14 Replies
