Ford F-150 - 1997-2003 :: 2002 - Transmission Stutters While Going Into OD?
May 4, 2009
I have a 2002 f150 2wd 4.2l engine. With 135,000 miles I just replaced the battery about 300 miles ago and I usually tow a trailer almost always. Also I replaced the Plugs and Plug wires about 15,000 miles ago When I am towing I turn the OD off. Now the problem. I noticed that when I am not towing now that when approaching highway speeds it seems to shift back and forth from overdrive while accelerating only.
But when pulling a trailer with OD off it shifts fine. No engine codes appear. I am due to service the transmission fluid I think I have about 35,000 on the fluid now but before I do I just want to pass this that while I have the pan out. Is there anything else I should check or could this just be a issue with dirty fluid Or Possibly the drivetrain controller because I hardly ever drive without towing..
View 11 Replies
Advertisement
So I leave town Friday with the wife's car for a golf tournament that is 4 hours away. I left her with my 2001 F150 Supercrew Lariat 4x4 5.4L. She calls as I am starting my practice round on Friday stating that the truck had died on her in the local Dillons parking lot. She had driven to the east side of Wichita, then drove all the way back to the west side before swinging into Dillons to get some chinese food for lunch. When she gets in the truck to leave, she starts it and it runs rough.
She gave it gas and it ran fine for a few seconds, she put it in drive, and then it started running rough again. She stopped the truck in the parking stall ahead of her, turned it off, and restarted it. Same thing...runs rough. She tried giving it gas, but it would not go above 1500 rpm. Then it just died on her. She then tried cranking it, but it would not turn over. She let it sit overnight and got a ride from a friend (it was 102 degrees out), went back the next morning to try again. Same thing, just cranks. So I get back last night and go up with my scanner. No codes, no SES/CEL.
So, I am now thinking it is the fuel pump. I crawled underneath the truck and had her turn the key so I could see if I can hear the fuel pump. Nothing. I went ahead and disconnected the battery to let it sit overnight.
I am about to head up there and see what I can do. So far, here is my list of things I need to check:
1. Fuel pump relay #301
2. Fuel pump fuse #18
3. Check for the theft light
4. Check "inertia switch" on the passenger side kick panel
5. OPEN gas cap and listen for the fuel pump (had never heard of that one)
6. Hit the gas tank a few times with a rubber mallet to "jar" the fuel pump (again, never heard of that one).
My question to all of you is: Am I missing anything else? Alos, with it running perfect, then running rough and suddenly dying, would is necessarily be the fuel pump? I had read something about a "Fuel Pump Module" located near the spare tire. Is that something I should check into with it running rough (well, not running at all now) like this?
View 7 Replies
I just bought a 99 f150 it has 257000 miles on the truck, and a motor and transfer case from an '01 with 215000 miles. I'm not sure about the maintenance on the truck but when I'm on the highway the truck randomly stutters. I was thinking it was coming from the tranny because the tranny was overfilled by almost a quart but really not sure.
View 7 Replies
Woke up this morning and was going to work. Went to unlock my truck and noticed the lights didn't come on inside when I used the remote door unlock. Then I started truck and the tranny lever on the steering column wouldn't go into gear plus the sterring wheel will not lock when the truck is off!
View 1 Replies
I have a 2002 f150 lariat super crew 4x2 with a 5.4L engine with 145,000 miles. My tranny is shot, and i was told it happened because the tranny cooler went bad. A few people have told me it sounds strange that the cooler went bad on its own. The truck is still at the shop that diagnosed it and i cant seem to figure out if it has the 4R70w or the 4r100 tranny in it. Is this something that's standard or something i will have to look at on the truck itself to figure out.
View 11 Replies
Was looking for some advice on what my problem may be. I just replaced the slave cylinder on my 02 f150 4.2 and two days after I changed it on my way home from work my truck jerked when I was about to turn into my driveway. Then when I stopped I put it in neutral snd it started rattling really bad it stopped when I pushed the clutch in And when i let out it started again. It sounds really bad and im hoping its something I can fix my self and not terminal.
View 4 Replies
Anything else that could cause reverse to go out of an automatic tranny other than the tranny being shot? I don't know of anything but any way to keep me from replacing a tranny.
View 2 Replies
My car is just about at 60k, and I'm really starting to notice that its not the same. Power is not all there, steering is really loose, suspension has definitely begun to sag, it has rattles, the transmission slips and stutters...maybe it is all a sign.
View 19 Replies
So my wife's 2002 Passat, 1.8T, is acting weak on the interstate. Under passing conditions, it seems to lose power, and even stutters a little. Cruising and idle are both fine.
It has blinked the check engine light at me a few times when the stuttering happens, but when I check for codes, there are none stored. I replaced the plugs and coil packs about a year and a half ago.
View 3 Replies
Just started doing it last week some time and only happens when I am launching it from stop or grabbing gears hard.
This is a little idea on whats happening.. At stop light next to some random ricer.. maintaining 2500 rpms on tach
drop (stage 4) clutch on green
Car squeaks and dies out like a stall and dash lights flash as well as lights on controll/radio area (around abs light) radio shuts off like a stall.
View 3 Replies
The car is an 02 gti. I am having problems at full boost(17 psi) where the car starts to stutter, backfire, and eventually drops to 5 psi. Throttle up to 15 psi is always smooth and there is no hesitation or misfires. It's chipped but I am unaware of which software as it was already on the car when purchased.
What I've done:
Checked for any leaks - none
Cleaned maf
Replaced plugs(0.028) and coils which was needed anyways
Coil harnesses look good
Fuel filter changed
I've read about the n75 but I am not experiencing any surge issues that many have described. I do believe the car is running a little rich because I can smell some fumes but it is very light. Car fires up just fine and idles smoothly.
View 4 Replies
I have a 1997 Ford F150 4x4. I only have reverse gear, when you put into drive you have to rev up truck and then it will kick into gear & as long as you keep a little pressure on throttle it will stay in gear & shift fine if you let up on throttle it seems to go back into neutral & you have to start the the process all over. What is my problem? I have changed fluid & filter.
View 2 Replies
Looking for any good videos of flushing the transmission out of an 1997 F150. I'm having a hard time locating the input and output lines to the radiator. I don't know which it is top or bottom one...
View 11 Replies
I have a 1997 F150 XLT V6 Speed Manual stickshift. My problem is the transmission will not go into any gears, it is in neutral.
View 1 Replies
Transmission lost 3rd and 4th gears so I pulled it and found the direct drum burnt up, got new drum and changed all seals, clutches, steel plates, aftermarket cooler and put a sure cure kit in it.
Truck drove great until it blew the front seal out 250 miles later, took it to a shop since I was away from home and he said the clutches got hot so he completely rebuilt it. Truck made it 150 miles and lost 3rd and 4th again. He replaced all the solenoids also.
Transmission shop rebuilt it again and it made it 80 miles and now it will not move at all. We replaced the neutral switch, shift cable, and shifter handle on the last rebuild because he thought it was hanging between neutral and drive.
What else could be making this transmission keep going out? Could it be a bad case, bad valve body or what? We are at a total loss on what keeps burning it up.
View 3 Replies
This is wife typing in middle of trip. Today we drove almost 300 miles down the road before it stuttered. We lost the tach but nothing else. No check engine lights. It has done it a few times since. Watching with Torque and don't see anything there. Have 100 miles to go and it's happening more frequently. Replaced CPS 4 weeks ago with a Ford grey. Running down road it's 95 day. Oil was checked to be good at 211, transmission 182, EGT 790, pulling enclosed 6x12 cargo trailer. What can I check?
View 14 Replies
So I was given a 1999 f150 4.6. The transmission was supposedly either new or rebuilt. (I'm going with rebuilt) Driving it for the first time today, I noticed it had very little poor acceleration. When I would get on the gas (to the floor) the rpms would shoot up (3-3.5) but the truck didn't accelerate accordingly. It feels like the power it's getting to the wheels. Driving at highway speed trying to maintain a speed at over 70 the truck wanted to stay at 2500 rpms but if I let off the gas just a touch it would shift up (into overdrive I think) and level out at just below 2000 rpms, but if I accelerated even just barely, it would down shift and go back to 2500. I've also noticed the truck runs 5 mph faster than it reads with stock sized tires. I've check the tans fluid and it is bright red in color and at the appropriate level. I crawled under the truck and noticed the trasfer case mount was wet with fluid (not dripping) and the rear output shaft of the transfer case was also wet. Could this be a transfer case problem?
View 13 Replies
My friend has a 2000 f-150 2x2 and was following him and he said he heard something pop and then no transmission , haven't put a code reader on it yet. It's not the flex plate starer works fine fluid is a little discolored and has no bad burned smell to it.
View 1 Replies
My truck is an XL V8. Transmission is Manual 5-Speed Mazda M5OD-R2.
I bought this truck literally two days ago. It seemed a little hard to shift, but no other problems. The truck had been sitting a short while, the guy said he took it on local trips, but nothing more. I noticed the oil and coolant levels were crazy low, so maybe it had been sitting longer or the guy was neglectful, I'm not sure...
I was driving it home and it seems like what can be described as: the gear ratio went completely out.
For example, 4th gear acted like 1st gear, 5th gear like somewhere between 1st and 2nd gear, so when I'm at 20mph, in 5th gear, the rpms are really high like im going 20mph in first gear (not 5th).
Today none of the gears engage at all... I dropped off a trailer at uhaul, and I got stuck there! (The truck is still there, I walked 4 miles home)
The shifter works fine, all gears sound like neutral (including reverse) when accelerator is pressed. Car won't move at all, nothing is engaging.
Underneath the car, there is a leak from the transmission assembly, maybe around the fill plug? It's only a small puddle. Maybe fluid, shift forks, bushes? or all?
View 8 Replies
Tranny just started slipping a couple of weeks ago, only occasionally. Seems to be between 2nd and 3rd. any chance a fluid change will work? I don't have have the money right now for a new or rebuilt and I am far from mechanically inclined to do the work myself. 2000 F150 62K org Miles....
View 1 Replies
I have a 1999 ford f150 v6 no 4x4 has wont shift from 2nd to 3rd, shifts fine from 1st to 2nd, after that tho there's nothing. What to do or what it could b?
View 1 Replies
