Ford F-150 (2004-2008) :: 2005 - Rear Axle Whine Over 25 - 70 MPH?
Mar 27, 2011
had a leaking rear driveshaft seal at the axle and replaced it and fluid. 75W145 full synthetic as recommended. it was changed at 128000 and I've started to get an axle whine over 25 MPH up to 65-70MPH. quites down around 80 MPH. I just checked it after 2 months (whine just started) with 133000. Any TSB. does this fall under TSB 05-23-3? Noise sounds like I've got really aggressive tires on the truck. Only have Dayton HT all season. Did not add the XL3 additive. Would this work at this juncture.
View 5 Replies
Advertisement
Experienced a rear axle whine above 70mph? I've noticed a whine while just slightly on the gas above 70mph (maintaining speed). Does the GX have a regular ring and pinion set up or is it a more complicated affair?
View 14 Replies
I recently had my rear axle seals replaced due to leaking. Does the rear diff fluid get replaced on that repair since the rear diff cover comes off? Trying to figure out when my next interval for changing rear diff fluid should be.
View 1 Replies
I had the rear axle seals replaced less than 1000 miles ago. Now the axle is getting whiny. First I thought maybe that the tires made noise but now I'm pretty convinced it comes from the axle.
With a seal replacement, what do they do that might impact the axle - over tighten the bearings?
I also had the rear diff fluid replaced - perhaps they put in the wrong stuff...
Should I replace fluid and see if that stops or should I simply take it to the dealer and let them deal with it?
View 14 Replies
Unable to decode the B6 axle code on my f150,5.4 L,FX4 2005. Clearly located on the drives side door is the label 'axle' directly below that is B6 ! Unable to locate a listing for this code any where?
View 3 Replies
I got a new to me truck. It's a 2004 F150 Lariat 4x4 with the 5.4L. It's got a whine that I believe is coming from the rear differential. I'm going to change the fluid. My axle code is 26 which I believe is 3.73 non-limited slip. My owners manual says to use 75w-90 but I've seen a lot of posts on here that say to use 75w-140. Which is right or better? Also, is my rear differential the 9.75"?
View 14 Replies
My '04 4wd has a pretty loud rear end howl, it is a LS but don't think it's an LS problem, no noises or chattering when turning. Howling is loudest at 50 to 60, but some noise at all speeds. I don't mind tearing into the rear myself, but not sure if I could tell what was wrong just by looking, i suppose bad bearing might be obvious, but not sure how to diagnose gear lash tolerances. It only has 107000 mi. and is an 8.8 rear I believe.
View 2 Replies
I have a constant whine going down the road with foot on the gas. Back off and it quiets up. At 2-3 MPH i think i can here a " tick- tick". Took the drive shaft off, wheels off ground, cover off and oil out. Spin wheel and i can hear a tick - tick, I think around the pinion bearing. No play up and down or in and out, but it appears to have 2-3 times the backlash i would expect. I used the screw driver- stethoscope--- still think its the bearing. This is a 9.75 axle. What kind of luck would I have pulling the yoke off and going in from the front without removing axles halves and ring gear? I thought I had read that here before. Never done one that way .
View 2 Replies
I had a loud whine from the rear axle of my 04 SCREW and had the bearings replaced at the dealership. It has been about a year/12k miles since it was done and I just noticed that the vent hose is missing. I'm not sure if they left it off or if it fell off on its own. Anyway, my question is, do I need to replace the fluid once I put a new hose on? I'm not sure how much if any dirt or water might have gotten in there. Also, where does the hose go up to? I figure it must clip to the frame somewhere.
View 5 Replies
I own a 2004 F-150 FX4 5.7L V8, I notice this morning that I had gear oil coming out of my rear Axle Vent Tube. What would cause this issue? I'm kinda at a loss as to what would cause it.
View 3 Replies
Some family members borrowed my truck, and when they returned I have a loud whining noise coming from the rear axle, which I have determined is a 9.75 rear. I checked oil level and it was high enough, but has a slight leak from the pinion seal. Everything feels solid but I have nothing to compare it to.
Its on a 2005 Super Cab with the 5.4L 183,000 miles. The front pinion seal was replaced in Feb 2 years ago, by the dealer's mechanic, who may have been a shade tree mechanic.
I am a Youtube Certified Mechanic, as in, I watched about 10 videos of people working on their 9.75 differentials, and realize I don't have all of the tools to do the job, such as a press, or race drivers, or the special gauge.
How many of you have tackled this issue? What did you find? What am I looking at for cost? I am on a very small budget.
View 5 Replies
When I am coasting in reverse or forward at low speed e.g. 5 mph, I am hearing a whine that seems to be coming from the rear axle.
Usually it happens just after I have shifted OUT of gear (it's a manual transmission).
I uploaded the sound as a WAV file to here: Note! I recommend that you disable flash before going to this [URL]......
When I speed up the whine just rises in pitch and it's making my ears ring. What that sound might be? Maybe I just need some "axle grease" or something?
View 4 Replies
2005 4wd excursion. I have a leaking rear seal on passenger side.
I have the hub assembly off. I'm down to the spindle. My old seal came out in pieces. There's either a piece of the old seal or another seal on the back of the spindle.
Are there two seals? This what looks like a seal still on the spindle against the plate on the back...
View 1 Replies
My uncle has an 05 F150 extended cab. When he bought it he put his license plate in the rear window until he could get some bolts for it. When it was there it fell between the back of the rear seat and the back of the cab. Currently he has one plate on the rear, but is worried he will get stopped for not having a front plate installed. So he knew I am an FTE member and I could find out how to remove the seat back. I have not tried to remove it nor seen if I could reach it.
View 4 Replies
My 05 f150 is lift with a 6" skyjacker lift I've only had it a week from the dealership when it stopped firing on cylinder 8 which is a lil problem easy to fix,but then it started clunking around turns in the front and rear end. So I took it the dealer and 3 days later they give it back. It's running good but its still clunking in the front they said they changed the cv joints and tie rod ends but after I got home. I inspected it they changed one damn tie rod and that was it. Is it the tie rod end that's still making the noise?
View 1 Replies
I'm new here to the F-150's forum although I've owned a few since 2001. I bought this F-150 '05 5.4L Lariat. Really nice truck. But when I purchased it, it had this weird noise inside the cabin. I thought because it had a camper on it that some tranny noise was coming up thru the camper and the rear cab. After taking camper off, the noise was still there. From everything I've read online, it could be rear pinion seal, differential bearing, tranny, front hubs, etc. I have left a video. Pay close attention to the little whine. Kinda hard to hear if your not listening for it.
Note- when i drive it is most definitely coming from the middle to rear of the truck. But I'm not ruling out anything. I have looked underneath the truck and the differential is dry and the driveshaft area near diff is dry. No leaks. I have not checked fluid in diff. Is there an easy way for these trucks? I have read and heard about adding an additive? The noise starts at about 10-15 mph all the way up to 80. I've never taken it past 80 but I'm sure it's still there.
[URL] .....
View 8 Replies
I am having a problem with my sliding rear glass where when I attempt to open the glass, the pull cable barely moves. When I push the close button it will eventually pull the close cable tight and close the window. (The length of time it takes to pull the cable tight in the closed direction depends on how long I had attempted to open the window, i.e. when I'm pushing the open button it looks like all I'm doing is making slack in the cable and not really pulling it open at all)
I have done some research on how to access the motor behind the seat, but have not gotten a chance to investigate further.
View 1 Replies
I just bought a 2005 fx4 and there is a whining or whirring sound coming from the rear of the truck when I hit around 70km/h. the second i let go of the accelerator it stops.
Today when I got home after a 15 minute highway drive, i got under the truck and felt the differential area. it was warm but not hot. and there was a wet spot on it. i wiped off a drop of oil. there was also a wet spot on the bottom, seemed to be just water? I'm not sure.
View 14 Replies
What exactly does the sensor on the rear axle do? 08' f350. I know it's a speed sensor of some sort, but what does it do or control exactly.
View 3 Replies
My '05 Ranger Edge has started making a loud bang from the rear axle. It does it when I apply throttle, apply brake, and to a lesser extent, when I hit a (small) bump. The truck shakes when it bumps almost as if I got rear-ended. What does this sound like?
View 4 Replies
I have a 2004 F-150 FX4 4x4 with 80k with a 9.75 LS, recently I've had the truck start making a humming sound/vibration (similar to the sound/feel you get when crossing onto rumble strips, only not as intense) when at speed anywhere above 20 mph or so, its doing this all of the time. The strange thing about the sound is that is only occurs when I am driving completely straight or to the left, if have the steering wheel just slightly turned to the right of center, the sound and vibration completely goes always until the wheel returns back to center. also I've started to notice that sometimes (not all the time) at lower speeds when let off of the gas and decelerate. I'm getting a very high pitch whine that sounds like a metal-metal sound but only lasts for a few seconds then goes away.
I cant tell where if the sounds are coming from the front or back and i cant decipher which side it is coming from. Also, I don't know if it is related but over the summer, probably june or so, i had to drain the fluid from the rear end and replace and add an extra bottle of friction modifier to get rid of the shuddering problem alot of people with 04's have run into.
View 8 Replies
