Golf IV / Jetta IV :: 2005 - Engine Temperature / Fuel Gauge Not Working
Mar 16, 2014
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connecter and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning. I've searched and searched without being able to narrow down a solution.
View 19 Replies
Advertisement
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine came to me and decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connector and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning.
View 1 Replies
My sister drives a 2005 Nissan Altima. I am not real familiar with Japanese OEMs but I do most of my own repair work on my car (which currently has issues of its own). What's wrong and how do I go about making the repair...
View 8 Replies
Just bought my 5th Vdub an 01 Jetta Wolfsburg with 1.8T and 5 speed manual. I bought it from a local dealer and found the speedo not working. they ordered parts for it to fix that and the front end. They tried to fix it by replacing the VSS. CEL was off when I first started driving it then came on shortly and began to stutter. I haven't hooked my vag-com yet because I just got home with it a little while ago. I think it may be a loose wire because it also beeps and fuel gauge goes to empty around corners. Typical areas to look for etc???
View 13 Replies
I borrowed a friend's small Toyota truck for a few days of easy chores, and made a point to check the fuel at the beginning: the gauge showed 3/4 full. Four days and only 25 miles later, when I got in to return it, I noticed the fuel gauge was not working, I'm certain there's no fuel leak, I would have noticed that: the truck had been parked on my property the entire time, driven only a few hundred feet from one spot to another moving firewood around, so I would have smelled the gas if there was a leak.
When I added a couple gallons of fuel, the gauge didn't budge. Once on the road, I realized that the engine temperature gauge was also dead - no change on the gauge after 10 miles. So I have two non-functioning gauges which failed on my watch. This may not be directly my fault, but as my friend is kind enough to lend the truck whenever I need it, my contribution is to provide maintenance.
Is there anything in common between the two gauges which would explain the synchronized failure? Or is this total coincidence? This one is outside my experience, so don't know where to start. It's a 4 cylinder, 5 speed manual, base model truck, about 150k, generally runs just fine. There are no other gauges, and I don't recall what warning lights there might be, but I didn't see any after I realized there was a problem. Would the whole instrument cluster die at once, or could this be something like a bad ground for the cluster? I don't mind investing effort into tracking down and solving a problem, but if it needs a new cluster, that will cost more than I'd like to contribute, yet the problem occurred while I was using the truck (gently). My total use of this truck for all the times I've borrowed it is certainly less than 300 miles, so I'm reluctant to fund the entire repair if this is something that just comes with age.
View 10 Replies
I recently had my fuel pump replaced in my 2005 GTI ... twice. Both times, the fuel gauge no longer shows a full tank, and doesn't show empty tank correctly. Is there some way to reset the gauge? Is the pump somehow tied to the gauge, or did the mechanics mess the float up when they changed the pump? Sadly I had it repaired somewhere other then the dealer.
View 1 Replies
2002 ford sport trac.I have been having an ongoing issue that started with the engine cranking but would not turn over until an hour passed. After replacing multiple parts (cam shaft sensor, crankshaft sensor, ignition pack) I am now down to poor fuel economy as the last of the issues (roughly 12 in the city and 15 highway). I was told the issue may be the engine coolant temperature sensor going bad so I decided to replace it. I found this was very difficult due to it being a plug and locking pin design and in a very tight spot in the engine.
I tried to purchase a replacement and the parts store kept trying to insist on selling me a part with threading. I finally found someone that figured out the issue and found the part for the 2001 sport trac had the same plug style with clip that did fit but was shaped a little different on the sensor end which I assume was due to being aftermarket. I noticed that there were two plugs side by side and the one easiest to access was on the left and I was told the one on the right was the sensor that gave the temperature reading to the gauge.
After installing the engine coolant temperature sensor I found the temperature gauge on the dash now will not respond and is sitting below the cold end of the gauge completely off. Is it possible this is because the part was for a 2001? Is the sensor on the left (passenger side) the engine coolant sensor?I would hate to put the old sensor back in just to test if that's the issue due how difficult it was to put that locking pin back on. What to check that could resolve the gauge issue before pulling this sensor back out?
View 3 Replies
I have never seen any of my other cars do this and I just want to see if this is normal. It happens like clockwork every time I get in the car with a cold engine. I let the car sit while the RPMs are high and as soon as the tach drops I start to drive the car softly. The engine temp gauge reaches normal operating temp in a normal amount of time, it does not just jump to the middle. But after about 1 minute it just starts falling quite quickly, as you can see in the video. It's very predictable - happens every time I drive it so it was easy to catch on video. I don't notice any difference in engine performance. Is this normal for a VW GTI or is something wacky going on?
You can skip to 19-20 seconds in the video to see the needle drop.
View 24 Replies
Car is a 2012 GTI 6MT with APR intake.
Within the last couple of days, my engine temperature gauge has been acting a little strange. The needle will fluctuate depending on if I'm accelerating or at speed. I've actually seen it go down several times before going back up to normal temp. On a couple of days, it will go up to about halfway to normal temp, and just stay there for a lot longer than it usually seems to.
There have also been times when the car is at normal operating temp, I'll go into a store for maybe 15 minutes, and when I come out, it shows the engine temperature is maybe halfway to where it should be. Then it will go back to normal after a few minutes of driving. I would think that if the engine is warm, it should stay there for more than 15 minutes, even if the car isn't on.
We haven't had any abnormally cold days lately, and I'm not getting any CEL, but I was wondering if anything to worry about, or if it's normal.
View 11 Replies
Recently had extensive work done on my 2005 F250 PSD. 4 injectors replaced, fuel regulator, and STC fitting on HPOP.
Got the truck back, and the fuel gauge, and "distance to E" display are working intermittently.
When the truck went in for repair, it was about 1/8 tank. After repairs, shop put about 30 miles on the truck.
I picked it up, and the gauge read E, and display said 0 kms to E. I filled the truck up, and the gauge still read E, and said 0 kms to E.
I then drove for a while, then powered down, and back up again, and gauge read below E (like when truck not running), and display had 4 dashes...no numbers, for distance to E. I powered down, and then back up, then it read 696 kms to E, and gauge working normally.
This morning, on a cold start, the 4 dashes, and empty reading returned. I shut off truck, and restarted it, and it started working again.
Could the shop have damaged the sending unit, while driving 30 miles, with so little diesel in the tank?
View 5 Replies
My '04 Passat 4Motion (station wagon) engine coolant temperature gauge, fuel gauge, and outside temperature display all stopped working in the same time. Interestingly enough, car has 32K miles and just ran out of manufacturer warranty 2 months ago.
What could be happening? Should I be checking fuse box or this may be related to some more serious failure?
View 1 Replies
My fuel gauge just quit working along with the "miles till refuel" in the message center on my R. Before I suck it up with a trip to the dealer, Is there a sensor on the fuel tank that goes bad?
View 3 Replies
I just worked on my car for a week and it was jacked up with the rear end squatted down and now when i corner the fuel gauge goes down.
2004 1.8t jetta ....
View 1 Replies
I am having an issue with my speedo and the fuel gauge on my 2002.5 24v vr6. First it started with a speedo that would bounce and dance around. it went away then came back and so on for awhile. Then i notice the fuel gauge would go up or down and would flash that i need to fill as I would go around turns. Also the odometer doesnt work either. I know that the vss could be the cause.
View 1 Replies
I have a 2003 Jetta 2.0L. I've noticed for the last few days that my engine temperature has been getting pretty high. We're going through a pretty intense heat wave where I live and that surely part of the problem but I've also noticed that two large fans at front of my car don't start up right away when I start the car. Is it supposed to be this way? Do they only kick in when the engine reaches a certain temperature?
View 3 Replies
Got a Vr6 a couple weeks ago and recently the gauge has been acting strange. Few days ago the gauge went from normal to showing completely empty and did that for a couple days (gauge would just display normal and occasionally just drop straight to empty and sit there until restart) but yesterday it started just sitting on full. Even when restarted just goes to full. I assume its the sender unit ....
View 2 Replies
2003 Chevy Malibu 3.1 temperature gauge stopped working last night, this morning having trouble starting, no check engine light fans do turn on have heat, replaced the coolant temperature sensor but gauge still not working?
View 1 Replies
I have a 2009 Prius. Last summer I noticed that the outside temperature gauge was not working properly. I asked at the wonderful dealership I go to and no one knew anything.
View 10 Replies
I have a 1.8T with 152kmiles
Recently, both the coolant reservoir 'Y' connector and the driver side coolant flange cracked and I was shooting G12 all over the engine. I've replaced both of the parts and the coolant temp sensor with a "green top". Reservoir was refilled with the proper ratio of G12 to distilled water, ran for a bit and topped off accordingly.
This morning I started my drive to work and the engine temp was at 0 for a minute or so and started to climb slowly to 190. It stayed at 190 until I took the exit to the highway and the temp slowly started to rise while I was at 60mph. I immediately turned around and went back home with the heat cranked to high. With the heat on, the engine temp would slowly go down but then rise again if I, A. turned the heat off or B. made a hard pull up to ~55+mph.
I popped the hood and the coolant was not boiling and I couldn't see/smell/hear any leak. could this be the thermostat or is this a water pump issue? I plan on taking the thermostat off and checking the pump empellars for any shards. I'm not sure but I do believe the water pump was replaced by my parents while I was on deployment.
View 2 Replies
The outside temperature gauge and park distance system on my Phaeton isn't working. In place of the temperature reading on the dash it just says --.-C I've had it scanned at my local Bosch diagnostic garage and it showed a fault on all six front parking sensors. I can't recall whether he mentioned the temperature sensor as well but I put a new one on anyway as they are cheap and easy to get at. It made no difference. They were very busy so didn't have an opportunity to do any further investigation or dis-assembly and I was in no rush so am taking it back next week.
I have checked the two block connectors which the wires from the parking sensors and temperature sensors go in to and that seems properly connected. Is there another connector somewhere or is there a fuse that protects these somewhere as there isn't a fuse described in the manual as being related to these?
View 6 Replies
I have a 2004 Pontiac Montana with about 107500 kms on it (VIN: 1GMDX03E24D183870) and the coolant temperature gauge is not working properly. Sometimes when I start my van, the temp gauge is pinned at MAX temp and stays there the whole trip...other times it's pinned at MIN temp...and other times it seems to work OK.
When it's pinned at MAX temp, I check the actual temp that the on-board computer is seeing, by using my OBDII scan tool...and I get about 87 degrees C when I'm halfway into my trip (i.e. - when the van is at operating temp), which seems OK. All the other analog gauges are working perfectly.
I read a lot about the issues with "connector C305" on the Internet on the Montana vans...could this be the problem?
View 14 Replies
