Golf IV / Jetta IV :: Airbag Light On After Seat Swap
Sep 12, 2014
I swapped my cloth seats for leathers today and the airbag light came on after... the seats were out of a 2000 golf, so I was expecting to have to splice wires, but, the connectors were the exact same on the cloth from my car and leathers from the donor car... so I just did a plug and play... I scanned with vcds and got these codes:
Address 15 -------------------------------------------------------
Controller: 1C0 909 605 A
Component: 1M AIRBAG VW51 02 0006
Coding: 12621
Shop #: WSC 00000
2 Faults Found:
00592 - Seat Belt Switch: Right (E25)
30-10 - Open or Short to B+ - Intermittent
01218 - Side Airbag Igniter: Passenger Side (N200)
32-10 - Resistance too High - Intermittent
I take it the passenger seat is the problem... I didn't clear the codes, I wanted to ask here first before I did if I need to do anything to connectors there or just the clear the codes?
View 3 Replies
Advertisement
I have a 2004 Jetta which has the 2-wire seat belt sensor on the passenger side and a 4-wire sensor for the drivers side. I swapped seats from an older style MKIV which had no seat belt sensor on the passenger side and a 2-wire seat belt sensor on the driver side.
As of now the seat belt sensors are disconnected and I am throwing seat belt sensor codes for both passenger and driver side. I have already tried to clear the codes via VAGcom...took care of 2 ignitor codes, but not these seat belt switch codes.
Is it possible to splice in the 2-wires from the older seats to the correct 2 out of 4 wires coming from my car? What's the difference between the 4-wire and 2-wire connector on the driver side?
Also, reading through the DIY here: [URL] ..... It states that I would need a recoding of the Airbag controller in VAG-COM to deal with the airbag light. What this code is suppose to be?
View 9 Replies
Last winter I had to replace my front passenger seat. The seat was starting to burn a hole or two, generally getting too hot for the passenger. At about the same time my airbag warning idiot light came on! I changed my front seat. The seat change was no biggy, but I keep getting the airbag light! Can this be cleared simply or only by a dealer?
View 8 Replies
While driving on the highway I lowered my seat. Once it got to the lowest setting, I heard something sort of like a snap, and it threw an airbag light, so I raised the seat back up. I'm new to VW, but I know there's lots of possibilities for the light.
2000 Jetta GLS
View 2 Replies
I purchased a 2002 2.0 jetta a couple of months ago and not long after I had it I noticed that the airbag light had come on. I brought it to a garage and had them check it out and they came back with a code that read 01218 side airbag igniter passenger side. When. I asked about getting this fixed they really couldn't say much about what exactly the problem was other then to say that it could be a problem with the whole system...which I don't get as the code only came back for the side airbag igniter. I also went and spoke to the dealer here in town and they wouldn't even speak to me about it unless I let them have the car be seen by one of their mechanics and putting the computer on it to read the code which I had already told them about.
View 6 Replies
I was check fuses looking to see if taillight bulb was bad. I pulled out a few while the car was running, then there was a beep, and airbag light came on. Tailight fuse was ok, just had a bad bulb. Put in new bulb, everything works fine but airbag light stays on. All fuses are good.
View 3 Replies
I'm looking for the secret to eliminating the airbag light when running an after market wheel. I realize that not everyone agrees with this modification, but could we stick to the subject at hand. I know there are some hubs that come with a premade resistor that you plug in that eliminates the light, and I've read that some people use a 4.7 resistor. I don't have a plug in resistor, I've tried the 4.7 and that didn't work for me. I've never been able to find any place that would sell the plug in resistor separately, is this possible? What I might have done wrong?
[URL]........
View 23 Replies
Not permanently, but temporarily? I can't really figured out any obvious reason why it is on, all the connections seem good, but I don't really know if I've covered all my bases. I obviously care that it functions properly in the event of a collision, however I was curious if there is a way to manually turn it off for a duration? I have an inspection coming up which doesn't allow for this light to be on.
View 19 Replies
I have a 2000 VW Jetta GL. A few weeks ago I noticed my charging light come on followed by abs and airbag lights. Which would mean that the alternator is not charging the battery. However I kept on driving and this light would go off. However when I hit a bump on the road this light goes off meaning that the battery is being charged by the alternator. I recently installed a sound system in the vehicle which worked without problems for a few weeks before I started having this problem. Since then I have changed the alternator, battery and taken out the sound system. I now have a 125 amp alternator instead of a 90 amp alternator. The charge light doesn't come on anymore after startup but the abs, airbag and emergency brake light with a beep is now occurring.
View 3 Replies
The remote locks on my 2000 Jetta GLX have been working intermittently for almost a year. I had been using the manual key to lock/unlock until finally the manual lock alarm disarm also became intermittent and I found myself stuck at a truck rest stop at 1:30 a.m. with my alarm repeatedly howling into the night and no way to disarm it. I felt caught. I felt trapped. Like I was found guilty of a crime I had never committed. I knew then - I had work to do.
My research in the forums indicated that the door lock assembly was a common culprit - a gremlin, often leaving headaches as it's only calling card. I worked quick, pulling a driver's side door lock assembly out of 2003 at the local junkyard and replacing it no problem. To my surprise, although this DID fix the manual locking/unlocking/alarm disarming problem, it DID NOT fix the remote unlock problem. The culprit was still at large.
Business as usual with intermittent remote unlocking/locking/trunk-popping for weeks until my dash threw the "AIR BAG FAULT" light. I decided to question a local garage owner who's VAGCOM told me that it was caused by something on the driver's side door. He was busy, but it reset fine and I was on my way. I know now that I should have asked for the code then but I was caught in the beauty of a girl who only nails polish was the grease and dirt of the car she worked under. And about a mile down the road, the light came back on.
Now, the "AIR BAG FAULT" light is on as soon as I start the car. However, the time seems to vary slightly before the Jetta beeps and tells me in faded red letters "AIR BAG FAULT". Sometimes right when I leave my driveway, sometimes not before I drive a mile or two down the road. My remote unlock is still working intermittently.
I need both my airbag fault and the remote unlock fixed. I'm wondering if these two problems are related? Like maybe there's a loose connection that is causing the airbag sensor to short and it's beeping when it bumps out of place and maybe the intermittent remotes are being caused by slamming of my driver's side door too hard & it's losing a connection as well. I tried putting a little conductivity jelly in the female clip that goes to the window regulator motor because I heard that the airbag sensor is in there somewhere but it didn't make a difference.
View 5 Replies
Driving my car (2001 Jetta Wolfsburg w/ 1.8T) to work yesterday and all of a sudden the airbag light comes on... As I was almost to my exit I continued another 500 yards. The ABS/and brake light come on as well and the car dies as I coast to the side of the road. I would not start so I had my spouse bring the trailer and another battery to see if it would start up. It started up and we loaded onto the trailer.
Took the battery to Napa and they said battery was bad. Today I buy another battery and the voltage of the battery not running is 12.2V and with the car running the alternator to battery voltage is the same. How do I know if the voltage regulator is bad or the diode or something internally in the alternator? Also how to I get the airbag light reset?
View 3 Replies
My son has a Jetta MKV and the seat heater button no longer illuminates. I assume there is a bulb in there.
View 1 Replies
My 2003 vw golf gti mark 4. So first things first I just bought the car and have done quite a bit of googling and troubleshooting and its became frustrating because I am a mechanic so now I've resorted to blogging. The air bag light is on and throwing no codes unless you need a specific obd2 scanner. Also my seat belt warning light does not come on and it does not beep so I'm figuring that someone used that vagcom to turn it off. And then third and finally the ac won't engage and I've checked the common problem 30amp fuse in the engine bay above the battery and nothing. I've read a lot regarding common ac problems so I'm just gonna assume that the ac is not bad.
View 8 Replies
I have a 2007 Toyota Camry LE, and the seat belt light keeps on flashing and the airbag light is solid. We have tried literally everything possible, tried replacing the seat, replaced the seats sensors, tried a airbag module out of another 07 camry with exact same part #. Toyota have diagnosed that all the systems for airbag is fine, except it has something to do with the seat belt of the drivers side/or module but all that's been checked and still no luck. My car is due for Safety inspecting coming month and need this to fixed. How to handle this. Btw light came on because we had a blown fuse for the drivers power seat, and my mechanic thought that it was the motor so we replaced the seat and noticed that it wasn't the motor. Was just the fuse and we put back the original seat and everything is functional except the lights came on. No accidents on it to the extent i know. and the wiring is all plugged back properly without anything like wiring damage.
View 9 Replies
I have a 2003 Montana which has the airbag light illuminated. Also no matter if the seat belt is locked in or not - no seat belt light ever comes on. I have a code scanner but it doesn't scan airbag codes.
View 4 Replies
My seat belt latch is throwing the common error:
1 Fault Found:
00591 - Seat Belt Switch; Driver (E24)
32-00 - Resistance too High
I measured block 2 and found that wiggling the seat belt latch showed a 'On' vs 'Too High'. So I know it's that switch inside the latch. I don't want to buy a new latch. But since I always wear my seat belt I could just use a resistor to set it to 'ON' at all times.
I have found a few DIY, but thing seem to vary from R32 to Golf. In this .pdf, it is for the airbag defeat, but I am thinking this is a different issue all together.. [URL] .... This guide then shows different wires than the R32... [URL] .....
View 15 Replies
I could find mentioned using a 4.7 ohm resistor to disable the airbags at the connector. I need to get my seat re-upholstered and the VW haus wants to charge me like 80 bucks, how can I do this for less money?
View 19 Replies
Quick question about the air bag light function for the passenger seat. When no one is sitting in the seat it does not display "on" or "off" by the clock. When I sit in the seat it displays "on" Shouldn't the light always display "off" if no one or someone too light is sitting in the seat? Is this normal, or is there something wrong with the sensors in the seat?
View 2 Replies
A few weeks ago, a relative was riding in the front passenger seat and asked me why the light said "passenger airbag off." I had seen that on before and didn't think anything more about it as I rarely have a passenger. Called Toyota to login the problem as I was traveling that week and thought I would be out of warranty before I could get it to the dealer. That particular light was on for some days afterwards and then I forgot about it. Tonight I noticed that "passenger airbag off" is not lit, but there is a light saying "airbag off."
I turned the car on and sat in the passenger seat, and the light that came on for my aunt didn't come on. Just "airbag off."
View 7 Replies
I had posted about it earlier [URL] ... but now the car has been to the dealer and was told it was the passenger side seat belt buckle.
View 13 Replies
I recently bought a used '06 Camry V6.
After driving it for several days, the red airbag light went on on the instrument panel. Certainly, I do not want to go to the dealer, not only because of costs, but also cause of the distance of the dealership from my home.
I did a bit of a research and so far have tried disconnecting the ground wire on the batter for half an hour, in order to reset the computer. Although, as soon as I plugged in the wire back and turned the car on, the light did not disappear.
After looking online, I found a similar problem and a solution regarding Toyota Sienna in this link: [URL] ....
-Following the advise, I remember that right before the light went on, I have tried to reach for the plastic water bottle that ended up deep under the driver's seat.
Is it possible that the airbag problem stems from the loose connector under the driver's seat? If yes, how should I approach this.
Also I recently had my intermediate steering shaft replaced [URL] .... Are there chances that such replacement caused the airbag to fail. This manual does not tell any steps to disconnect any yellow wires (or wires at all).
View 1 Replies
