Santa Fe (CM - 2007-12) :: 2011 - Loud Rattle On Cold Startup For 3 Seconds
Sep 5, 2016
2011 Santa Fe 3.5 L
I've isolated this rattle down to the cam phaser( CVVT) in the right cylinder head. It rattles bad for 2-3 secs on cold start or after it sits for 3 hours.
I've put in 5w20 synthetic oil and synthetic Lucas additive and it cleared up the noise for short interval start ups.
I changed the cam phaser in the right head with a used one ( 40k ) but it didn't make a difference. I should change out the attaching cam as well.
View 21 Replies
Advertisement
I have a 2011 santa fe limited with the 3.5 and 35k miles that has a noisy timing chain rattle upon start up after sitting for a few hours,it's my understanding that the cause is no oil pressure to the tensioner because the oil drains back into the oil pan after sitting for a while. Is there a solution for this situation like a spring loaded tensioner-it seems to me that replacing the tensioner and chain does not solve the problem.
View 32 Replies
My 2011 sonata rattles when starting. It sounds like noisy lifters and quits after 2-3 seconds. It does not do it on the first start-up of the day, but on subsequent starts when the engine is warm.
View 7 Replies
6.2L F250 truck is just shy of 60k runs good however on cold startup there's now a pretty loud ticking noise for a short period (30 seconds) until it warms up then it slowly goes away. Once its warmed up there isn't much of anything.
Did these have exhaust manifold gasket problems like the 5.4? Hoping that's it if not, any other common problems that would make that ticking noise and then go away quickly once the engine is warmed up.
View 14 Replies
Our 2007 RX350 with 91,000 miles started an annoying rattle at startup that lasts a couple seconds then goes away. The car drives fine and makes no unusual noise after the initial start. Its definitely not normal as it hasn't done it the last 91K miles we have driven the car.
View 3 Replies
Bought 2009 santa fe new [3.3]. after cold start up tac is moving up and down and it seems to be missing. After temp is reached tac is steady but there still seem to be a hesitation when driving. 21,000 miles on vehicle. could it be a bad tbs?
View 4 Replies
Twice this week our 2009 SantaFe (3.3l) had a squeal from the engine upon cold startup. The first time it was very cold (-20C or so) and this was louder and longer than the second time (-10C or so). The squeal lasted only a few seconds and trailed off to nothing. Each time the heater controls were set on defrost (fyi). In order of likely suspects, I suspect one of the following:
-compressor engaging and causing sudden increase in resistance on the belt or compressor engagement clutch noisy
-idler pulley for some reason causing belt to slip at first, but don't suspect idler bearing as noise disappears right away
-belt slippage due to resistance somewhere else--e.g. water pump or alternator.
This may not happen when I take the vehicle in for its next scheduled maintenance as by then the weather will likely be warmer. This has 76000 km on the clock.
View 2 Replies
While we continue to enjoy our recently acquired Mineral Gray 2011 Santa Fe, I have noted a momentary engine noise upon startup after it has been shut down for say 2 hours or more.
The noise reminds me of having an oil filter with a malfunctioning or absent drain back valve where by the bearings will complain for 2-3 seconds until oil pressure rebuilds
The SF has but 20.7K miles on it to date. Do we know of this is usual for the V6, or should I be concerned and planning a dealer visit?
I love the power of the V6! We test drove a 4 cylinder model first thinking that was the way to go for economy reasons. I found this one with such low mileage, AWD, and the V6 at a great price so we jumped on it.
I am a little disappointed though that the AWD does not function "full time" like that on my 04 Dodge Durango. The SF runs rings around the Durango in the mpg department though.
View 3 Replies
I have santafe 3.5 2012 4WD , it's 51K on odometer, the problem when cold startup , Noise and small vibrate form front side , its look like from gears
When put to reverse (R) sound is louder and strong vibration from front side, all this problem gone when drive about 15 minutes.
I have visit 3 local shop they check the engine, gear box, everything normal, no check indicator appears.
View 5 Replies
Trying to find any information on what's happening with my 2008 2.2 Diesel Santa Fe ... Been driving fine until I pulled up at a set of traffic lights yesterday and started hearing a loud rattle- knocking coming from the engine at idle.
Put it in gear and drove and it goes away. When at idle if you rev the car it goes away.
Mechanic seems to think it could be clutch as it vibrates the gearbox, but sound seems to be more prominent around the engine, my thoughts were maybe a loose timing tensioner.
Clutch replacement is very expensive.
View 1 Replies
If you push the remote lock button twice the horn beep is very load and startling. Can this be programed for a lower volume sound?
View 5 Replies
The vehicle has 80,000kms, and from a cold start it is having this problem more and more frequently. I must crank the engine 3+ times, and then she starts. A prolonged cranking period doesn't seem to work, and this only occurs when cold. The car starts fine when warmed up. I have scanned the car with a generic OBD2 reader and there are no codes. Once the car is running, it runs great with no misfires.
View 1 Replies
I have a 2004 F150 with 195,000mi. For the last several moths the truck has had a rattle on startup, some days it is barely noticable and only on cold starts, other days it is loud and occurs on every startup. The truck was most recently serviced at the Ford dealer and is filled with Motorcraft 5w-20 syn blend and Motorcraft filter Every change before was either Motorcraft syn blend or Penzoil Platinum (I have always used Motorcraft filters on it) and the noise continued after oil changes so I don't think the drain back valve is the issue. I replaced the cam phasers, timing chains, chain tensioners, and guides about 15,000 miles (2 years) ago and the vct solenoids shortly after that. Here is an audio clip of the noise (I know the truck also has an exhaust manifold leak, I plan on replacing the manifold while im working on it
Is this noise the lash adjusters or have the cam phasers failed again (they were dorman parts)? If it is the lash adjusters, can they be replaced without removing the cams? will failed adjusters be obviously damaged? Should I also replace the cam followers? do i need to replace all 24 at once or can i safely replace only damaged ones or maybe just 1 bank (noise seems to only be coming from the pass side)?
View 11 Replies
First bit of cold weather and I'm getting thirty seconds of loud clicking (or clacking) coming from the immediate vicinity of the blower motor on start up and shut down. Doesn't matter whether my climate control is on or off, it still makes the noise. I'm assuming it's stripped out teeth on one of the blend door actuator gears and I'll probably just end up replacing it. My problem: Where exactly is the offending actuator? I've removed the glove box and noted one located on the left side. I unplugged this but am still getting the ratcheting sound so it obviously isn't the culprit. I had this happen a few years back (same time of year) and out of ignorance and frustration solved it with a well aimed kick but the way it's acting this time I don't think I've got a big enough boot.
View 4 Replies
I cant start the sonata 2011 unless I keep the start button pressed for 10+ seconds. It just doesn't start anymore by just pressing the brake and hitting start button once. I figured before I replaced the brake light switch, is that's what causing this problem?
View 9 Replies
Still considering the change from my '08 F250 to a newer F150 with the EcoBoost. I have been driving as many of them as I can to get a feel for them. My current question is this: if one exhibits the dreaded rattle at cold startup, does it always get worse with more time/miles? I found another one that I'm pretty happy with overall, but it does have the startup rattle for about a second at cold start, and only at cold start. Is it worth the gamble, or should I keep looking? It's got about 108k miles and is otherwise in fantastic condition...
View 8 Replies
There was a TSB for 2AR engine, Engine Knock/Rattle Noise at Cold Startup. My question is for those I4 camry owner, do you have these rattle sound when you start your vehicle at cold? I am not sure if mines have the same issue, but pretty sure is I can't find any differences between mine and this clip:
You Tube
So should I take it to the dealer? Or it's normal?
[URL] .....
View 11 Replies
I recently bought this CPO Azera that came with 100k mile powertrain warranty. I noticed startup rattle that occurs when the car has been sitting for 30mins and longer. It usually lasts 2 - 4 seconds.
I wanted to take it to the dealership but I want to make sure that I approach them the right way and won't be sent home with "this is normal behavior" as it happened in many cases when I was researching it. I suspect chain tensioner but I might be wrong.
2013 Azera Limited with 49k miles ....
View 21 Replies
Two months ago I bought a used 2006 Sonata v6 with 54,000 miles. After a few hundred miles I began to hear a rattle on cold start that lasts approx 5 secs. I did my research and saw the TSB concerning the timing chain tensioners. The TSB instructs the dealer to turn the engine off after reaching operating temp then restart after 10 minutes. If there was no noise after the ten minute start then the car is operating normally. My car does not rattle after the 10 minute start up. I just can't see this as a normal characteristic. What could be causing this noise?
View 1 Replies
Have a 2011 F150 with the 5.0. 91K miles. On startup-cold or warm-there is a ticking/tapping noise coming from the engine for about 3-5 seconds then it goes away. Happens on every single start. Sound like it's coming from driver side on top of engine, but hard to pin point.
View 3 Replies
When I start my car I hear this very loud noise. I think it is coming from the exhaust but not sure. This only happens when the car is cold(not weather) and after a few minutes the noise is gone. I have aftermarket lowering springs on the car, do you think that caused the problem?(I'm thinking no)...
View 4 Replies
