Cavalier - Chevrolet :: 2002 - ERLS Fuse Keeps Blowing / CEL Came On
Oct 14, 2012
Why my 2002 cavalier keeps blowing the ERLS fuse?? Happened a while ago, and I heard the pop. Then my check engine light came on, along with the off track light and the air started blowing hot air, and it won't shift out of first gear. It is an automatic. I replaced the fuse, quit using the A/C and it ran for a couple weeks but not real far. Then after a 6-8 mile round trip it blew again and I can't seem to find any answers for a very odd problem.
View 1 Replies
Advertisement
Had a directional bulb go out recently and replaced it without any problem. About 3 days ago it went again, I bought a 2 pack of bulbs - replaced it and drove on. Almost instantly right after I turned and signaled the right directional bulb blew again, I grabbed the extra bulb put it into plug and started car - first right turn with directional bulb blows again. I'm at a loss as to where this can be happening. Is this in the steering column or elsewhere, where do I even begin to look.
View 3 Replies
I've been fighting this almost a month now.2.2L Engine.
The engine turns over, but want start.
We have fuel pressure (55psi) and a spark.
Sprayed ether in the intake -- nothing.
Changed the crankshaft positioning sensor. Put a simple scanner on it, it stated no errors or faults could be found.
Tried another ignition module, checked the PCM fuse and ignition module fuse, both look fine.
Installed an anti-theft system bypass and followed the reset instructions. Didn't fix.
Just for fun we changed the spark plugs as well.
Now, the person I was with who saw the spark (I was inside the car) says the spark looked "weak" to him. Is this possible?
View 16 Replies
I have a 2002 Chevy Cavalier that stalls ever time it is fueled at the pump. It then continues to stall. I have to pump the gas like the old days when we all had carburetors and repeat the action many times. It always starts eventually, but causes unnecessary anxiety so I always fill my car at a time I don't need to be anywhere in a timely manner. It was taken to the shop but they could not reproduce the stalling, as they did not have the information that it mostly happens at the when fueling. The gas cap can be taken off for a while and it starts okay. The rpm is low after adding gas, if you give it gas, it runs then eventually idles normally.
View 6 Replies
Replaced Fuel Pressure Regulator but still notice smell of gas and sometimes at start up rough idle.
View 7 Replies
I have an '02 Chevy Cavalier whose passenger side headlight went dim suddenly one day when I started the car. When I start the car, the daytime running headlights indicator flashes and clicks, and then the service light comes on. I have tried the following:
1) Swapped light bulbs between the two lights. It is not the bulb.
2) Swapped fuses between the two lights. It is not the fuse.
Even stranger, when I remove the fuse to the dim headlight, the light stays on. My guess is that I have a short somewhere in the wiring. I took a brief look at the connection between the socket and the wiring and everything looks good there.
View 1 Replies
I have a 2002 Caviler. Somewhat recently the car has been not staying at a constant temperature. It will rise above the middle (where it would always just stay at until recently) a notch and then go down a notch below the middle. I have never replaced the thermostat and I have had it around 8 years and the car has around 60,000 miles. Did replacing the thermostat fix them?
View 7 Replies
I am having issues with my 2002 chevy cavalier.
The car occasionally surges forward while idle and revs up to 1500 rpm approximately occasionally when the air conditioner is on... if the brake is not applied I move forward.. the lurches are continuous every 3 seconds or so.
I am getting a code for an evap leak.. I have replaced the purge solenoid valve, gas cap, and checked all connections with no luck... slightly decreased gas mileage has occurred.
A little bit of a slick substance has been leaking from the car.. it has the consistency of water, but leaves a slight brown tinge on concrete.
View 3 Replies
2002 CAvalier 2.2 automatic with 123'000 miles. I was asked to look at this car for a slipping trans problem.
I drove the car about 3 miles and in 1st and Reverse it feels normal, even on a steep hill, but once it shifts into a higher gear the trans slips and you can go only about 15mph.It is shifting, because if you move the shifter into a lower gear while traveling....you can feel it downshift.
There is a code of P0502 Vehicle speed sensor. and there is no Trans fluid visible thru the filler cap on the trans top.
Previously someone else worked on this car for the slipping trans....changed some sensors....but couldn't fix the problem. The owners don't know what parts he replaced. He works for a Tire outfit and I've known him to lean towards used parts a lot.The previous mechanic convinced them that it needs a new Cluster. I presume he means instrument cluster.
I have a feeling that he just threw parts at it hoping that something would stick.
I presume that he replaced the VSS, and it didn't cure the problem.Come to think of it....the code could be from before the other persons work. I should have cleared the code and test drove it again.
I'm looking at dropping the pan, replacing the filter, refill the fluid, and replace the VSS
My questions: Could a instrument cluster have anything to do with the shifting problem.
Is the level of trans fluid supposed to be above the ledge under the filler cap, or is there a "full level" plug in the side of the trans. If he replaced the VSS with a new one....and the fluid level is good....whats my next step.
View 15 Replies
02 JettaVr6 auto tranny- car was running perfect, no CEL. Now all of a sudden the fuse keeps blowing out- what exactly is running off this fuse?
View 1 Replies
The 7.5 a/c fuse blows every time the a/c button is pressed. replaced the a/c relay but problem persists.
View 3 Replies
Fuse 29 was blown when I got my truck, automatic headlights and overdrive lock didn't work. I replaced the fuse, the lights came on and overdrive locked out but when I shifted into park the doors locked and the fuse blew. How the door locks are related and why they would lock when shifting to park?
View 2 Replies
I have a 2002 GTI 1.8T with the AWP engine and tiptronic. There is a fuse in the picture below that blows as soon as the car is started. It is located next to the brake booster on the firewall. It does not blow when the ignition is turned on, just when the engine actually starts. I'm not throwing a check engine light, pulling a scanner code or noticing any of my electronics not working. I took a 20 AMP fuse out and replaced with another 20.....and have since blown 5 of them trying to diagnose the problem.
View 10 Replies
I have a 2002 f350 7.3 PS that every time I touch the brake pedal it blows the #6 fuse(trailer tow brake/turn signal). I need to use my trailer.
View 14 Replies
2002 F450 7.3 Turbo
Ok first problem : Starter Motor fuse kept blowing and I spent weeks trying to figure it out. No luck. so wired up a push button just to get the truck started, its a work truck so it was needed asap.
2nd problem : he truck stopped starting completely. Wont start in Park or neutral and after a NEW STARTER (because I thought the solenoid on the starter was bad I replaced it) Everything work correctly for one start with the key. After the second time trying to start it blew the starter fuse again. So I tried the straight wiring to starter. still nothing. I was wondering if there are any shims or anything at the transmission housing to correctly position the starter. I am thinking that maybe the gear is stuck or gets stuck sometimes. when I straight wire the starter it does nothing but the wire gets hot so I know its pulling.
View 3 Replies
Windshield wipers, and washer were suddenly not working the other day, so I discovered a blown fuse. Put a new one in, and it immediately blew again. So there is definitely something grounding out, and I am suspecting the wiper motor itself because so far I have not been able to find any wires shorting out, but before I go to the trouble of pulling the motor out and testing it, or replacing it.
Truck is a 2002 F350CC 7.3 TD. Wipers were working fine the other day before I pressure washed it, which is why I really suspect the wiper motor itself.
View 3 Replies
My car dies when I come to a stop unless I gently press on the gas pedal while holding done the brake. What can cause this?
View 4 Replies
Car won't start after filling up with gas. I have tried a new fuel filter, new gas tank cap, checked for pressure on fuel pump. We have gottenit to start (but barely) when either hit gas tank with hammer or shake the back of the car, otherwise you have to set and wait 15-30 minutes before it will start and when it does it smells very weird (like it's flooded but an extra strange smell with it). I have seen a similar posting on here and someone suggested it might be a purge value problem. In talking with someone at auto store they didn't think this was the issue. I do have my check engine light on all the time and when checked the code , it said oxygen sensor. My two other Cavaliers have also had the oxygen sensor problem but it never did this with that code.
View 9 Replies
My daughter says that the AC on her 2001 Chevy Cavalier cuts off when she is idling.
View 4 Replies
I have a 2004 Chevy Cavalier. I am having some issues with it.
When it first starts it idles really hard. The RPMs are up and if will try to accelerate without hitting the gas. This stops after the first minute.
The second part is that when stopped, but in drive, it idles hard. It does it though when the AC is turned off. You can see the RPM gauge go above and below the normal 500 RPM. If you turn the AC on then it levels out. It will occasionally idle hard with the AC on, but rarely and not as much.
The car drives well and is not overheating.
View 3 Replies
The cold air box is a black plastic box that sits forward of the engine/valve cover. It connects via black plastic tube to the air filter box on one end and to the engine on the other. I took it off it. 'Lo and behold it was full of oil.
View 1 Replies
