Ford - E350 :: Occasional Stall That Occurs When Engine Is Warm And Slowing To A Stop
Sep 23, 2012
I have problem with an occasional stall that occurs when the engine is warm and slowing to a stop. I have a 1994 fuel injected E-350 460ci motor home. The engine runs great 90% of the time. When cold or sitting the vehicle will start and idle great. After warming up 5-100 miles occasionally I will slow down to stop, the rmps will fluctuate from 400 to 750 rpm as will the vacuum then die. The engine will start up fine but idle roughly wanting to die again during this period. Once the rpms are above 1000 and put into gear the engine will take off and accelerate great. This stalling tendency will last about 15 minutes (if I stop) then appear to go away and not reoccur during that trip.
At high speed and hill climbing the engine does great. It has occurred once on each of my last 4 trips. I have had suggestions about: the fuel pump, fuel pressure regulator, and possibly the crank sensor. I'm trying to figure the best sequence on working this problem up. It might be tough in that the problem seems to go away after about 15 minutes regardless if the engine sits or is run.A few more notes: the rpm and vacuum are great and steady until the problem kicks in. Last summer a shop replaced: the computer, alternator, spark plugs, egr valve, and fuel filter. I think the parts were just replaced till the problem resolved. The problem (unrelated) seemed to be resolved after the work was done though.
View 1 Replies
Advertisement
I currently have a 2006 B6 w/ approx. 95k miles on it. A couple months ago I had my catalytic converter replaced at the dealership and then about a month ago my car started having issues with stalling.
Symptoms:
-Car drives normal - no loss of power or anything, but then will randomly stall when coming to a stop or slowing down, taking my foot off of the accelerator. After it stalls the red alternator light comes on. Check engine light comes on and off - lately on most of the time.
-The issue has gotten progressively worse recently, but for the past month it has been inconsistent. Sometimes I can go an entire drive and not experience it and then other times it will stall nonstop. Lately, there have also been a few times where it's taken a few tries to start it, though this is recent as before it restarted perfectly fine.
-Recently, the car has started exhibiting symptoms at highway speeds as well, occasionally brief episodes where it will begin to jerk and shake. Usually stops as pressure is applied to the gas pedal.
-Also, have issues with the parking brake... the switch seems to have randomly broken in the center (no clue how) and I keep getting a parking brake fault. Not sure if this is related or an entirely separate issue.
I took the car to a very reputable independent VW/Audi shop and after several days they still have been unable to locate the issue. Based on the codes the MIL was sending the first visit, they replaced the low fuel pressure sensor and the cam position sender. Neither fixed the problem. So, now I have to decide where to go from here... They took off the labor and only charged me for the parts.
View 4 Replies
I have a 06 Passat with a V6 with 80K on it. Recently I have been getting intermittent stalling at start up, only when the engine is warm(but once on a really hot day). The car will rev slightly and stall. After several attempts, it will start, and then it runs fine. VW service said no error codes and didn't offer much more.
View 10 Replies
New here but long time lurker. I have a 2006 e350 with 6.0, bought it from a friend not long ago. The work that has been done to it the last 50,000 miles is as follows.. New hpop, all new injectors, egr delete, sct tuner, stand pipes and dummy plugs. I had it for a week and would get a no start hot once in a while. This issue had become worse and the truck started to stall as the RPMs dropped. Reading here i replaced crank sensor and the stalling stopped but the no start hot continued. I took it to a local diesel repair shop and they did the following..
Use a test ipr (no change), replaced ipr pigtail (was cracked) air test (leak under pass valve cover) replaced stand pipes and dummy plugs on this side. They said no leaks and I was good. Truck worked as its supposed to for 1 day and the no start hot issue reared its head again. Took it back and now they say the hpop is bad. The pump that was put in about 50,000 miles ago was a bostech? do these go out? Sangauge reads good ficm, but seams ipr doesn't climb that quick.
View 14 Replies
I have a '95 Ford F150 with a manual transmission and when I come to a stop light, the engine will either idle down more then it should then go back to normal or it will idle down and then stall out. And when I accelerate, I have to gun the engine for it to go forward or it will stall out again. I replaced the fuel filter and cleaned the air intake area and it still happens.
View 2 Replies
My mom gave me a 2004 f150 lariat with a 5.4l and were having an issue with the engine when coming to a stop the engine wants to stall out and runs like a bag of hammers and sounds like its going to explode then i give it a shot of fuel and it runs fine for a a while and then does it again. I brought it to the local dealer and he said it was either the vct or the cam phaser bank 2 so i changed both and it still does it just wondering before I keep getting intake cam sensor code retarded and a bunch of other codes but we replaced the cam sensor already.
View 2 Replies
Are the mounts on the engine not tight enough? It feels rather strange. My dad's Ford Explorer doesn't do that. I feel like I'm driving a car with a manual transmission that needs to have dogbone bushings and mounts upgraded. How do I bring this to dealership's attention without appear like a complete loony? They like to give the "Could not duplicate" response when there is an obvious symptom.
View 10 Replies
A bit about my truck : 2001 F250 CC SB 4x4 175k miles
Wicked wheel, 6637 filter, DP tuner, Summit 5" exhaust, pressure regulator somewhere in the boost circuit to fool the computer a bit....
Every few times I drive the truck it will stumble and maybe even stall. The issue feels something like a CPS problem, although I've swapped out a few CPS to see if I by chance had a bad one in the engine as well as a bad one in the glove box. No changes. I was driving home from work one afternoon and it was running particularly bad. I stopped off at a local garage (who doesn't work on diesels and was reluctant to plug in....but did because he's a nice guy).
He plugged in with his snap-on tool and came up with P0603 and P1211. The P0603 seems to be nearly inevitable with a tuner. Check P1211 sounds like it could be an issue with a number of things, but I tried to attack the free and cheap issues first. I dropped my tank and had a look inside. I was hoping to find a squirrel wrapped around the sending unit, but there was a disappointingly small amount of crud. I cleaned it up and put it back in, then changed my fuel filter. No improvements.
So I decided to get with the program and buy AutoEnginuity. Got it. Even did some reading in class and did the initial homework assignment on page 2 or 3. Seems like the best thing to do it hook up, set up some parameters to monitor, and drive around recording until the problem happens. But.........what parameters do I want to monitor? I don't want to overtax the OBDII bus with too many requests such that my data looks like crap.
A few other things............ In the last year I swapped out the valve-cover gaskets & harnesses with an all-in-one molded setup. About a month back I replaced the exhaust back pressure sensor and tube.
View 14 Replies
My "pride and joy", is sitting at the dealership. The car has been hesitating on acceleration, occasional it would also stall. According, to the dealership a faulty gas tank is the culprit. The tank has been ordered. Hopefully, i"ll have the car back in two weeks. What parts were replaced, to fix the problem??
View 24 Replies
My 2006 Sonata V6 (88k miles) has an occasional power steering loss. It has only been noticed right after slowing down from highway speed. Total loss for a few seconds then comes back. No dash lights or noises, just cant steer - then can. Did all required maint. until 60k then just oil changes by me. Have read other forums about fluid flush, but that was for noise and I don't have any noise. This has happened with and without the Electronic Stability Control turned on. Other than that, runs great. MPG is about 25 or so (wish was 30 or so).
View 9 Replies
Got Tiguan 2011 46000 miles on it. Just serviced intermittent no start and occasional stall after start.
Dealer replaced High pressure fuel pump and fuel pump control module. So far so good.
Seams like common issue.
View 3 Replies
My 1996 Dodge Grand Caravan has developed a curious problem. It intermittently stalls, sometimes when slowing down, sometimes when going up an incline, sometimes on straightaways. Once stalled, it often won't start again until it has sat for 20-30 minutes. Then it starts right back up again and drives perfectly normally until the next time that it stalls-which can be days or hours. The problem is definitely getting worse--six times today. Warmer temperatures seem to exacerbate the problem. Again, the engine runs very smoothly up to the point of the stall. My mechanic was unable to replicate the problem and his diagnostics showed everything to be normal.
View 5 Replies
I have an issue with my cruise control that only occurs when there is warm/hot weather, or if my car has been sitting in the sun for an extended period of time. The issue does not happen in the Fall or Winter, and generally not in the morning after my car has been sitting in the garage overnight. The issue that occurs is that sometimes I can turn on my cruise, set the speed, and then seconds or minutes later it'll just cancel the cruise speed without me doing so or hitting a pedal. Other times I cannot even turn on my cruise control, or the cruise light keeps flashing on and off. I've checked the fuse box and everything looks fine there, but I couldn't specifically find a fuse labeled for cruise control.
View 2 Replies
So, I have a 97 f150 with a 4.6 that idles low, around 5-600 all the time, and stalls in warm weather only. I just cleaned the IAC to no avail..
View 8 Replies
I have a '99 E350 Ford van, V10, with 300K that runs like a charm until I slow down to stop. It begins to surge which will stop when I shift to neutral. I went to the local parts store and put it on their code reader. It only read 'left bank lean'. Nothing else.
View 5 Replies
What is happening is that air will stop blowing through the vents randomly. We will be trucking a long with either a/c or heater on and all of the suddon it will stop blowing. I know the blower is on because I can toggle between vent and defrost. It will blow out of the defrost but will not through the vents. It can be anywhere from 1 to 10 minutes and all the sudden it will start blowing through the vents once again. It just doesn't blow through the vents. This is a 1992 E-350 with a 460 in it.
View 3 Replies
I've got a 1982 automatic chevy 454 engine with only 46,000 miles on it (in my Winnebago RV). It runs just fine except each time I step on the gas pedal from a stopped position for an instant it sounds like the engine is about to die and then it starts going. Is this a major engine problem or something that requires minor adjustments? I want to sell the RV. If it's going to cost a lot to fix, I'd rather lower the price of the rig.
View 6 Replies
We have a 1999 4Runner with the V6 engine, auto tranny, and 230k miles. For going on a year now the engine will occasionally stall when at idle…usually happening at stop lights. The engine starts right back up. This may occur once every other month or once a week for several weeks. Stalling has occurred with warm engine and cold engine, during raining/damp period and when dry. Never has the check engine light come on or has it generated fault codes. Dealer can’t find anything wrong. We’ve replaced Air Idle Control Sensor (OEM), Throttle Position Sensor, Mass Airflow Sensor, and cleaned the throttle body. Plug wires and timing belt were replaced a couple of years ago. Other than this one issue it runs great. What to try next.
View 4 Replies
A warm startup on my 2007 Explorer causes an RPM spike and subsequent stall (half of the time) on the way back down. I've tried a fuel additive, Ford ran codes with no problems...
View 6 Replies
The boss has an 08 Sport Trac, V8, 4x4. It has the hard bump when slowing to a stop. I've read here that there is a TSB to reprogram the transmission. Called a dealer in Ft. Worth to schedule appointment. Service guy say there is no TSB. Looking for a copy or number or anything on the TSB?
View 7 Replies
I have a 2005 Ford Escape XLT 3.0L V6 which I bought 6 weeks ago. It has 103,000 miles on the clock. I mainly use it for going to school and getting around town etc but on Sunday I had to take my parents back. It's a round trip of 230 miles. Weather was sunny. Traffic on the Expressway so a lot of slowing down, stopping, setting off cycles but no issues. On the way home, about two toll plazas from my exit on the I90, I noticed that the engine sounded and felt like I was driving in a higher gear than that required for the speed I was doing (5 mph). It's an automatic (which I'm not used to as I've always driven manual) so I don't make any gear changes but if I'd been in a manual, it felt like I was in 2nd when I should have been in 1st. Does that make sense?
Anyhow, so I managed not to stall at the toll plazas but when I exited, the engine stalled 3 times (twice at intersections and finally when I pulled up outside my house). There is no problem starting the car after this has happened. I called my local autoshop who said to bring it in Tuesday so I didn't drive it Monday. Tuesday morning, it felt exactly the same when I was slowing down for traffic, intersections, turnings etc. The autoshop had it 3 days and couldn't find anything wrong with it. There is no data stored on the computer to show any of this happened and it has driven fine for them when they've taken it out. Beyond frustrated! I know what I heard and felt. Someone mentioned the overdrive staying on but I don't know what that means.
View 3 Replies
