Saturn - Vue :: Crank Then Start After 5 Minutes - Fuel Pump?
Sep 26, 2016
vue would crank, not start. 5 min later it started. done this 3 times in 1 month. changed original fuel filter. am leaning towards fuel. vs spark. no codes. I see pump assy's for $175. or a pump alone for $30. if I remove tank and pump assy, would there be any issue with changing pump alone? not paying shop so its my effort the last gm pump assy I did had a working pump but corrosion on leads to pump inside tank. I replaced assy because I had already bought assy.
View 13 Replies
Advertisement
I have a Saturn LW3 station wagon. For the past few months it has randomly failed to start (it cranks/turns over but it acts like it is never getting any fuel). I took it to a good mechanic but he could not replicate the problem. The mechanic did a scan and there were no error codes. I waited until it happened again and I had it towed to the mechanic. Finally it would not start for him either. He explained to me that he tested it and inexplicably no power was getting to the fuel pump. He also explained to me that it was not the relay (I forgot the reason he gave for this, but like I said, he is a good mechanic). He was baffled but needed to get to other cars that were ahead of me. So the next day he went to check it out and it started right up.
View 3 Replies
I have a 1996 Lumina 3.1. For the last few years, every now and then I would turn on the key, all electrical systems, lights, windows, radio, etc. would work but it wouldn't turn over. If I waited about 4 minutes it would start perfectly and it wouldn't happen again for up to a month. Last week it did it and after I waited and tried it again it turned over once then everything went dead. A mechanic (friend) installed a new battery and it started. He took it to his shop and installed a new computer. Everything read fine, but now when you turn on the key it will turn over fine but not start. Leave the key on and wait about 2 minutes till you hear the fuel pump start and the engine will start fine. If you stop for a few minutes it will start but if you stop for more than 5 or 10 minutes you have to wait for the fuel pump to come on again.
View 7 Replies
1999 Jetta 2.0L manual trans
One day out of the blue the car would not crank or start. Checked and found that fuse #14 was blown and would blow the instant another fuse was inserted. Checked all the typical locations for wiring issues usually associated with the comfort module because it had all the symptoms of a faulty module (the power windows did not work and the fuel pump didn't pressurize the system when the driver door was opened, the alarm didn't set, automatic door locks also inoperable).
I checked the dome light, trunk hinges, rubber boot between doors and body and found nothing. Put a jumper wire into the neutral start relay and was able to crank the car. I then replaced clutch safety switch, neutral start relay and installed new (junkyard) comfort module and the car cranked up, started and everything was working normally again...for about 3 weeks. Then it did the exact same thing again. Fuse #14 was blown again and would blow the new fuse as soon as it touched the terminals in the fuse box.
I reinstalled the jumper wire in the start relay in order to be able to drive the car for the last week, and then last night out of the blue the car would crank, but not start. I turned the engine over several times and could hear the fuel pump pumping and even smell fuel, but no start. 3-5 minutes later after random tries to start, the car stumbles to life as if it wasn't getting fuel, and then drove 10 miles home with no issues. I returned the 'faulty' comfort module Monday and got another one but haven't installed it yet because I fear the same thing happening with this one as the other one.
Last night after I got the car home, I plugged in the comfort module and everything worked like it was supposed to. Can a faulty fuel pump damage the control module? I'm trying to get to the bottom of this and fix the problem and not the symptoms so I'm looking into anything that could potentially cause the problem.
View 3 Replies
I know this has been an issue for awhile and many may know about it but many probably don't. The issue is dirt and salt debri etc get packed behind the Fuel pump driver module rot it out and without warning you have a crank no start or worse it dies going down the road then you and the family are stranded or worse while towing on a trip. I made a video on how it happens and how to fix it with the solution Ford came up with. It is worth checking even if you don't seem to be having any issues yet......
View 5 Replies
I have an 04 Ford Explorer XLT 4.0 Flex Fuel. There has been loss of power to fuel pump. Relay and fuse both good, replaced the inertia switch...still nothing. Could a FPDM (fuel pump driver module) have anything to do with this issue? Or what should I check next? I am definitely at a loss as to what the issue could be! I know it is fuel related because I used starting fluid and it started right up and run for just a few seconds, so that should rule out ignition I think.
View 3 Replies
Sometimes after running my 94 Limited, it doesn't want to start - it does crank - like it's not getting fuel. I have found the work around and want to know if it would be fixed by replacing the fuel pump relay.
The symptom is just after starting, it starts to run poorly, and then dies out, then will not start at all. I use to keep trying to start it for 20-40 minutes and suddenly it seemed to work.
It seems the work around is to turn the key to on for about 5 seconds and then turn it off - then it starts and runs as good as ever.
So, is this a symptom of a bad relay? I thought I'd start there because of the cost of the relay is fairly cheap. 1994 Explorer Limited 4x4?
View 14 Replies
I own a 2003 Limited with the 6.8 V10. I drove the truck on Sunday and all appeared to be fine, gas gauge was setting just under a half tank. When I went to start it yesterday, it would not start. Strong crank, no start. I checked my fuse and it was fine. Fast forward to this morning, since I had kind of depleted the battery with attempting to start, I put my little jump start pack on it and gave it a whirl. Truck started fine but the gas gauge was sitting on empty. I had five gallons of gas in the garage so I added that to the tank then drove to the local gas station to add more fuel. I put another 10 gallons in the tank so it should have roughly 16 or 17 gallons in the tank. Gauge shows 3/4 tank but miles to empty is right around 175 miles which would seem right with 17 gallons in the tank. I suspect the fuel pump. I don't really want to spend $500 on the Motorcraft unit but was wondering if the group believes the Delphi or the Bosch units are quality replacement parts?
View 7 Replies
1996 Dodge Grand Caravan, 3.3 L engine. When the outside temp is a good range (50 degrees F & above) there is no problem starting. But when it gets below 40 deg. F and really chilly outside temp, I still have strong battery power, but when I switch on the ignition, I don't hear the normal fuel pump activation swirl sound and does not crank - simply silent click. Then I can wait when the outside temp improves and cranks up no problem.
View 6 Replies
Black Beauty finally gave up. Replaced battery, replaced fuel pump relay. Would only run with starter fluid sprayed into the air intake. She'll crank but not start. Here she sits at the dealership.
View 14 Replies
I just got delivered a 7.3L from down south. Batteries were dead so replaced both. Fuel was a couple notches above red line (much closer to red line than 1/4 tank) so I added about 7-8 gallons.
It will crank forever and ever...Won't start.
With starter fluid it starts but not strong enough to pump the pedal and rev it up to keep it idling.
I know s-fluid is bad but if I continuously spray with key turned forward it will run but as soon as I let go of key it shuts off.
20 degree weather and it was delivered to a parking lot so I cannot plug it in.
Was told to check filter cap, turn key, and see if it fills bowl with fuel....if not then it is fuel pump. Someone else mentioned that it could be bad crank position sensor? Does this sound like fuel pump?
View 2 Replies
1995 Ford Explorer, 4 ltr. engine, pushrod. Will not start. Replaced fuel pump, fuel filter, every relay, pressure regulator, and the crank position sensor. I realize there's a whole bunch more parts under the hood, but I am ready to give up. Before the fuel pump would not run. Reason for replacing the parts. Now it won't stop running and you can feel the fuel by-passing at the pressure regulator. When checking the pressure at the rail I get zero !! I used a tire pressure tester for this. And, like I said no pressure. This vehicle has around 170,000 miles on it.
View 8 Replies
I was on my way to work and my car would not start after I stopped at the gas station. One of the people at the station gave me a jump start and I continued to work. I asked one of my co workers to give me a jump to get home and when I started the car there were sparks and a bit of smoke from the battery. We hooked it up right and it will turn over but not start. The fuses are all good, the dash lights come on (service engine soon, check engine and security). We replaced the battery, and the coil assembly (I think that contains the ICM, but not sure). I called the mechanic I normally use and he said it was probably time to buy a replacement car. My friend (the one who hooked it up wrong) thinks it might be fixable, he has some mechanic experience and stated we are getting no spark and the fuel pump will not engage. We hooked up a car scanner to it and it was unable to communicate.
View 6 Replies
I have a 2006 Saturn Ion coupe and it occasionally won't start after a cold (below 32 degrees) night. What happens is on certain mornings, I'd go and start the car but the engine won't turn. The radio plays, the dome lights go on, the engine just won't turn, at all. The funny thing is without me doing anything else, when I try it after around 10 minutes, it starts right up and runs fine the rest of the day. Could the 10-minute wait be indicative of a frozen fuel line that's been thawed by the addition of gasoline when I press the gas pedal to start to car? Or is it something to do with the electrical system?
View 5 Replies
So it has happened twice now that gas will NOT go into the tank on my 2001 Saturn L200. The pump immediately shuts off and gas spills out. From some research I believe there is a kinked hose but where and why did this happen 2 months ago and then now after several fill ups between. The first time it happened the problem fixed itself after sitting for a day, I guess I'll find out today if that is the case.
View 3 Replies
I got my a fuel injector cleaning on my Saturn at the dealer. They sent me on my way with the car smelling like gas. After days of driving with the smell of gas, the service engine light on, and the car stalling I took back into the dealer. Now they are telling me that the fuel pump is broken and they want me to pay for it. This does not seem right. What happened. This seems to me something that the mechanic messed up...
View 9 Replies
I have just replaced a fuel pump on my 98 neon and it started up and then shut off after about 5 minutes. there is electricity running to the pump just not kicking it over what could be the problem
View 9 Replies
We will start with the history. I recently purchased this car knowing of a long list of issues which have been worked out for the most part. The related piece would be random misfires which I believed were based on a faulty Ignition Coil (common on this 420a [2.0 NA] motor.) I have replace the coil but the issue persists.
Now what is happening is after about 20-30 minutes (or miles) of driving the fuel pump will overheat and the car will stall. I can get it to turn back over most of the time but it will stall out if attempting to drive. I have to leave it sitting for about 15 minutes to be able to move it.
What codes am I getting from the CEL? Nothing. (No CEL)What have I tried so far? - Fuel pump has been replaced- Fuel filter has been replaced- Fuel lines have been verified (no noticeable leaks, unwanted bends, pinches or breaks)(I also verified that this is not an issue with the PCV valve or EGR [electric in this car] valve)
I know... I thought relay or wiring also - but all lines and the relay are cool to the touch so they are not overheating. 1998 Eclipse GS....
View 8 Replies
So, before we diagnose further, i have my fuse #43 pulled because that has been the only thing that somehow magically makes my car run when its not plugged in. I believe I've been dealing with a bad distributor and haven't come up with the funds yet to mod it for a v6 mustang coilpack.
BUT as the title describes, this just started happening today. The cluster wont turn on, fuel pump is cranking over, and the starter will whine as it cranks but no spark. Is the distributor getting that bad or am i looking at something worse?
View 2 Replies
Ii have a '98 sc2 and its been sitting in my yard for a while. It started out one day when i got in it, turned the key and then it turned over but wasn't starting. We hooked it to a computer and it showed no bad signal so we bought a new computer for my car and that didn't work either. We changed the coil packs and the crank sensor and still nothing.
View 2 Replies
Just replaced fuel pump and now it turns over but won't crank. I have checked the fuel rail. Pressure is fine. Checked coil pack I'm getting spark. Still won't crank. Checked inertia switch it wasn't tripped. What next? 2003 Ranger edge...
View 1 Replies
