Toyota :: Intermittent Power Loss?
Mar 6, 2012
My 1991 mini-motorhome, built on a Toyota pickup chassis with the v-6 engine & 5-speed recently developed a "hiccup" immediately after having the ignition distributor, rotor & wires replaced along with new belts, hoses, valve adjustment, etc. No work was done on the fuel system. Every once in a while (15 minutes to an hour or more, never more frequently) the engine will lose power for about 1/4 of a second, followed by a "thunk" as the slack in the drive train is taken up. It's easy to ignore except when I'm laboring up a mountain in third gear when the "thunk" becomes an alarming "bang". Other than that, it runs beautifully. Check engine light is not on. I haven't been able to associate the hiccup with load, speed, temperature, or anything else. My mechanic has no idea what it could be, and it didn't misbehave when he drove it. What's going on?
View 2 Replies
Advertisement
I have a F350 that has intermittent power loss.
View 14 Replies
I have a 2000 Excursion. This weekend, I noticed some intermittent failure of the power steering where it seemed like the pump was not engaging and then would all of the sudden. Deciding to try to head off a failure, I got a reman unit from Oreilly and installed it this morning. It was fine when I tested, had good brakes and went locked to lock quietly without fuss. Let the house and within a mile, I lost steering and brake assist. I stopped and turned around, but what I am noticing is that at idle, I have no power steering, but when the RPM's are up, I do.
View 3 Replies
Intermittent loss of power (could be describe momentarily stuttering) with momentary illumination of the check engine soon light. Its only happened a couple of times. Maybe about a year ago (I changed the fuel filter after it occurred). It occurred again about a month ago and then again yesterday. About a month ago I had a friend with a scanner look at the codes and he said there was only one and it was for low fuel pressure. Its been maybe 5k since I changed the fuel filter.
The truck is driven intermittently, maybe 5k or 6k a year, and usually parked with a full tank of fuel. What areas I should look at to correct this? I got my stock 2001 F350 4x4 manual transmission in 2004 with about 157k miles. Today I've got about 228k miles.
View 6 Replies
Ok I have an early 2004 F250. Recently changed out the #8 injector and then had to replace the ICP Sensor. Was running great then while driving down the road just died all of a sudden. Would start right back up with no issues. Continue driving and I am getting intermittent power loss. Also noticed that when it would lose power suddenly the glow plug light would come on.
Codes are P0102, P0113, P0272, and P1000.
P0102 Mass or Volume flow circuit low input
P0113 Intake Temp circuit High input
These are just soft codes not setting a light off. MAF is plugged in and I will check wiring here later after work but could this be causing my intermittent issues?
View 13 Replies
I just bought a 2004 F350 6.0 cclb 6 speed with 260k on it. The previous owner seemed to have taken good care of the truck. It is basically stock with the exception of the blue spring mod, and a sinister diesel coolant filter. Anyways, I brought the truck home and it ran great. Now I have an issue that needs to be addressed.
The issue: I am experiencing a intermittent loss of power, stall, or stumble when engine is cold. After sitting all night the truck will start fine and idle fine. But when I try to accelerate and bring engine RPM up the engine will stumble and lose all throttle response, when this happens the WTS and WIF light flash. Sometimes it just stumbles, sometimes the truck will actually die and then restart. The issue seems to go away after the engine has reached operating temp.
I did some research on the issue and it seems there is actually a TSB out from ford for this issue. It explains that some 2003-2004 6.0's might have wiring harness chaffing issues. This is what the issue I am having seems like to me (shorting harness). I looked up codes on the truck and there is an active code (#8 glow plug circuit fault). I did a short visual inspection of harness and didn't see anything out of the ordinary. But i wonder if it would be worth changing both sides of the glow plug harness?
View 2 Replies
2001 1.8T ... using oil 500ml/100km
- Blowing smoke-intermittent
- Power loss-intermittent
Some jelly white stuff in oil may not be related... Service techs looking at turbo....
View 2 Replies
I've been having a problem over the past month with my base 2014 Elantra (33k miles). Sometimes when I go to start the car there is a complete loss of electrical power. One of a couple of scenarios will occur:
1) Key Fob will not unlock/lock doors:
*There is no power to anything (no dash lights, interior lights, car won't crank).
2) Key Fob will unlock/lock doors:
* Either all interior lights will be on and when I attempt to crank everything shuts off (no dash lights, interior lights, etc)
* Or Clock and radio are reset, car starts fine
* The battery checks out as far as voltage/charge.
* There are no visible fuse issues.
* There are no check engine lights.
I have had it in the dealer the past 4 days and they haven't been able to reproduce the issue. So far I have been able to eventually get it to start by opening and shutting doors, which would lead me to believe it is a loose connection somewhere, but again the dealer hasn't been able to diagnose anything.
View 2 Replies
My 01 VW Jetta with 181690 miles started having intermittent loss of power a year ago:
1) it never conks out;
2) it loses power on the highway at 70 or in town at 25;
3) engine is usually hot, about an hour into a trip, but now does it cold, too;
4) weather doesn't matter: dry or wet;
5) check engine light flashes while it happens
6) it feels like it's running out of gas but isn't.
Mechanics have tried the following: Note: every time I brought it in to be looked at, the symptoms above were happening :
1) March 2013: replaced coil pack and it ran fine until Sep;
2) Sep 2013: ran Dx on check engine light: "arching all over the place" so replace spark plug wires;
3) Dec 2013: got oil changed
4) Jan 2014: ran Dx and was told crack in piston;
5) Jan 2014: got second opinion and told wrong spark plugs were used (single electrode vs triple electrode)-replaced all spark plugs; got car inspected and had oil changed again as it was dirty;
6) Feb 2014 mechanic is stumped, but found an article about clean oil and changed the oil again. Oil was down almost a quart.
View 8 Replies
I’m having an issue with my 2004 Hyundai Elantra cutting off, and what to check for next. Basically I have a very intermittent issue where the car seems to lose electrical power for a split second (or possibly total loss of gas – as in, it doesn’t seem to be misfiring, just seems to totally lose all power). If it happens when I first start the car up, the car will start up for a second and then cut off. It also happens randomly when driving at any speed, and when it happens while driving, it just goes out for a split second, and then cuts back on and I can keep driving, so the RPMs Rev up for a second as a result when it kicks back on, but then goes back to normal. But it is completely intermittent, as in, some days it will not do it at all on my 30-min drive to work. I even went a whole week without it happening. But this week it has come back. Some days it will do it 3 times, some days 20 times. Some days its hard to get my car started, because it keeps cutting off when I start it. But so far after I try around 5-10 times it will start up and keep going. Also, this may indicate nothing, but when it goes out for that split second, I can hear a click, or electrical sounding click coming from the dash/instrument panel area. Which is what makes it seem electrical in nature, but I could be wrong, could be a spark/gas thing.
This has been happening it seems no matter what the weather is outside (its been anywhere from the 20s to 60s here in the last few weeks) and it doesn’t seem to matter if the car is warmed up or not. Also, so far the check engine light has not come on, so it makes me think it might not be a sensor, since those will usually trigger the light when they start going bad. Also, when the car is running, it runs perfect. Idles perfect, drives perfect, no misfires, no hesitation, etc. The ONLY problem is it cutting out. Also, it doesn’t seem to matter if the fuel tank is full or half empty. I had read in one place that if the vapor recovery charcoal canister gets full of gas, it will vent liquid fuel instead of vapor, which can result in car cutting off or running rough, but this usually only happens when fuel tank is full. So I suppose it could be this, but I doubt it.The car has 180k miles. Iridium plugs have 60k on them. Wires have 60k on them. Original fuel pump and fuel filter. I wouldn’t think it would be the filter since when it runs it runs perfect. I guess could possibly be the pump having an intermittent issue. Trying to avoid replacing that for now unless I knew it was the problem.
What I’ve done so far:
•I made sure the battery cables are tight and clean at the connection
•I checked as many grounds as I could find, they all seem good
•Alternator puts out a perfect amount of voltage
•I swapped the ECU main relay and fuse with another relay and fuse in the fuse box that were identical
•I swapped the Fuel Pump relay with an identical one in the box
•I replaced the Crankshaft position sensor
•I cleaned the Mass Airflow sensor (though it looked spotless)
•I looked around for any vacuum hoses that were disconnected. Didn’t find any
•I’ve tried resetting the ECU (unplug battery for a while) and I thought that fixed it at first, but then it came back a few days later. And now resetting ECU seems to have no effect.
Some possibilities of what it could be:
•Fuel pump intermittent issue?
•Camshaft position sensor?
•ECU problem?
•Catalytic convertor going bad?
•Some other sensor going bad?
•Possibly the vapor recovery charcoal canister is full of fuel as described above
•ignition coils – but I doubt it since you’d usually get a misfire/engine light when those go bad (from experience)
•Fuel pressure regulator – but I doubt it, based on the symptoms. Seems like I’d have other symptoms.
I’m not convinced of any of these above, and some of them I wouldn’t know how to check (like for a bad ECU). What it might be? Getting nervous driving 75mph on the interstate with someone behind me and the car cutting out. Luckily so far it doesn’t cut completely off when I’m up to speed with someone behind me!
View 11 Replies
Alright, my '06 SV6 AWD has a major problem...I'm about to blow it up! But seriously, I've had an issue for a few weeks now with intermittent acceleration/hesitation problems. Basically it started as a rare occurrence and is happening more often now. Yesterday, it did it consistently for 20 minutes on one trip around town. 1 hour later, it didn't happen noticeably at all on the way home. It happens while accelerating, usually from a stop, but also sometimes when cruising at highway speeds.
The car does not stall or stumble. Everything sounds fine and smooth, but when accelerating from a stop, the car will stop accelerating and the speed slowly drops off. Pushing the accelerator down further to the floor does nothing for several seconds, then the power returns and the car responds to whatever position the pedal is in. If you haven't pushed further it continues accelerating where you left off. If you've got it to the floor, it takes off quickly. When cruising at speed, you don't notice anything until you start slowing down, and the pedal reacts the same way. NOTE: The engine does not rev up when this is happening. It's not like the tranny is slipping.
It really seems like a fuel delivery problem and not transmission. It has all the normal symptoms of a failing pump. And about 2 months ago, I had the fuse for the fuel pump melt (not blow). These problems didn't happen immediately after, but they did happen a few weeks after that.
That said, I have noticed that when cruising I occasionally hear a light clunking noise that sounds like the rear diff engaging. I assume this is just due to play in the drive train. I also had to recently do the expensive versatrack fluid flush and fill to get rid of the diff groan. But I still feel like it's probably fuel related because the engine doesn't rev up.
Here's what I've done so far:
1. Checked the wires at the problematic C305 connector. I already had to completely redo that connector several years ago as the PO had removed the connector and directly twisted all wires together covered the with tape, and filled hole with silicon. BTW, GM does sell all of those harnesses with length of wire, connectors, and heat shrink covers for reasonable $$. Anyway, found 2 wires with insulation slightly shaved off. Neither was for the fuel pump, everything else still looked good.
2. Checked voltage at the gray fuel pump wire just after the new harness (about a foot before the fuel pump). And checked the ground at the same location. Haven't checked at pump connector because I don't want to drop tank just yet. Both were fine with almost no resistance on power between that location back to the fuse box. So, it doesn't look like a bad or shorted wire unless it is in that short length up to the fuel pump that I cannot access w/o dropping the tank.
3. Checked fuel pressure at the fuel rail. The pressure when primed and idling is a consistent 60-62 psi. I know the manual states 60psi as the max. Maybe this has something to do with it?? Perhaps my cheap actron pressure guage is a bit off or perhaps the pressure regulator is bad. Could this cause the issue.
4. Checked for DTC's with code reader. No active or pending codes.
The other things I think could be the cause based on internet research:
1. Accelerator Pedal Position (APP) sensor
2. Throttle Position Sensor (TPS)
3. PCM
4. O2 sensor
The problem is that all of those things tend to set a DTC from what I've read. I still think the fuel pump us going bad and the pressure was fine because the problem is intermittent. I just don't want to spend the $$ on a new pump to find out it was something else.
Tomorrow, I will have access to a scanner that can log 10 seconds of data from the computers while driving. I think that might shed some light if I can get the problem to happen when recording. I'm not familiar with fuel trims and the lot.
View 3 Replies
I have a 2001 T&C, 3.3L, 4-Speed tranny and around 116K Miles. On occasion, I totally lose power steering for about a second or two. It acts like the engine has stalled and I have to muscle the steering wheel. There no belt squealing, no pump noise, and the serpentine belt is relatively new. PS Fluid level is good. It seems to happen at idle RPM.
Of all the caravans I've had, this is a first.
Now, I'm OK with it as long as I don't let anyone else drive it. I know what to expect, and I can muscle the steering when necessary. Once this happened to my on a highway offramp and I was able to control it with no problems. I suspect it is a problem with the rack, maybe?
My question is this: Is this an indication of something going terribly bad, like the total loss of steering control?
View 3 Replies
Bought my Santa Fe GLS less than 2 months ago and ran fine. Last week, went to store no problems and then went out 5 minutes later, put it in reverse and it stalled. I go to the store, and it lacks MAJOR power.
Now, if I leave it alone for a while it will normally start right up. While idling, everything seems fine. Then my "ghost" takes over the vehicle making it less responsive to the gas pedal. Also, at 3000 rpm, it sounds like its skipping a cylinder. When reading the gauge, it skips between 3000rpm to abut 2800 rpm.
View 6 Replies
I bought my outback a few months ago from a dealer/mechanic who had fixed the car after it was totaled. So it has a reconstructed title, but it was hit in the back, so all the engine parts were unaffected by the crash. Since I have had the car I have experienced intermittent loss of power steering ability. Sometimes it's nearly impossible to parallel park or turn a corner gracefully, and other times, within the same short trip, the steering will be completely fine and smooth. I have had the issue looked at about three times now by different mechanics. Each time they have either replaced or tightened the belt, which temporarily fixes the problem. But within a few weeks it always comes back. Is there something not keeping the belt tight, or could the issue actually be in the power steering pump?
View 3 Replies
I just got the spark plugs changed in my Ford F-150 the other day for a misfire problem. Misfire is gone now. But, as I was testing the truck to see how it performed after the spark plug change, I noticed that as it was raising speed with my foot to the mat, the engine felt as if I was slightly letting off the accelerator and then slowly pushing the pedal back to the floor. It loses power as if you're getting ready to slow down for something and then slowly the power comes back and it does it off and on throughout a WOT run from lets say 40-75 MPH.
2007 Ford F-150 SuperCab, Lariat, 4X2, 5.4L 3V.
View 1 Replies
After I drive a while I get a ticking , loss of power very briefly, white puff of smoke. Could it be rod bearings? Timing belt just replaced.
View 1 Replies
I did STFA, but no love. Cruise quit, EPC light on, Intermittent power loss. I checked all the fluids (ok), cleared the codes and drove it. all the stuff came back. I have a 2004...
Vag says:
Thursday,04,May,2006,19:20:22
VAG-COM Version: Release 512.4-UD
Chassis Type: 7L - VW Touareg
Scan: 01 02 03 05 06 08 09 11 15 16 17 18 19 1C 22 29 32 34 36 37
39 46 47 55 56 57 64 65 68 69 6C 6E 75 76 77
[Code] ......
View 8 Replies
I have a 1994 Oldsmobile Cutlass Cruiser 3.1 with an intermittent engine power loss during acceleration. Usually it occurs just after leaving a stop sign or light once or sometimes twice in a row. It is not a hesitation - it is a very abrupt loss of power. I've kept up on the standard maintenance very well and the car has 80,000 miles, so I would not suspect spark plugs, wires, or fuel filter. It does not have a tachometer, but I am 99% sure the transmission is not slipping or jumping out of gear, but that the engine is actually loosing spark or fuel. This problem is very intermittent, but it has triggered the check engine light a couple of times. The check engine light does not stay on, and when I took it to my mechanic he said to keep driving it until the light stayed on or the problem was more easy to replicate. Right now, if a mechanic went for a test drive, there is a good chance it would not show any symptoms. My mechanic did mention that it may turn out to be an ignition module.
View 3 Replies
Background- 2000 Ranger, 3.0L 2WD 170,000mi. This truck is not my daily driver, i try to drive it once a week.
I've never had this issue before... I drove all over town yesterday; multiple stops, no issue. Today i go to do the same thing and upon accelerating out of the driveway i lose all power for about 3 seconds. I get power back for about 3 seconds then lose it again. This continues for as longs as i'm driving. Also, no CEL. I go back to the house to look things over, can't find anything staring me in the face really.
Truck idles fine and the issue is not present when i run up the RPMs in park. I've been reading some other threads about similar issues and most replies begin with checking the regular maintenance stuff i.e. TB, MAF, IACV, pcv, etc. It seems like a complete loss of fuel or spark...but only when in gear with constant throttle???
View 14 Replies
I have a 2007 LS460 L. It has recently started losing electrical power in fraction of a second intervals. The map data sometimes works or displays an error on the screen. The radio has been functioning but now is also starting to flash off intermittently. Now when this happens it feels like the engine dies and ALL electrical is off and then power resumes. This affects steering, engine power and brakes. My wife drives this car and loved it until now.
View 6 Replies
When I take off from a start it will intermittently stumble or hesitate, seems to be around 1500 rpm. have also noted it at higher speed while cruising. its more like a momentary power cut than a miss fire.
So far I have done the following
new fuel filters
clean MAF
new PCV valve
new spark plugs
check all hoses and plugs etc
injector clean
checked techstream for codes. there is one for a heated O2 sensor but dont think thats it.
2002. SC430
View 3 Replies
