Golf IV / Jetta IV :: 2000 AC Not Blowing Cold
Jun 24, 2015
I have a 2000 Jetta that doesn't blow cold AC. Here are the details:
- When the AC is turned on, air does blow through the vents. Each setting (1-4) does blow harder than the previous.
- Both front fans spin and are working
- The AC compressor clutch never engages
- All fuses (two inside the car and the one above the battery) have been replaced and test good.
- When the AC is on full blast, the voltage coming from the AC compressor wire shows ~9.3V for about 5 seconds, then jumps up to about ~11V for less than a second, this repeats over and over and the clutch never engages.
What the next logical troubleshooting step would be? I've read about this possibly being the fan control module (maybe) and also read about testing the AC compressor using an external 12V power supply, but am not sure where to go from here.
View 7 Replies
Advertisement
I have a mk4 gli and the a/c is not blowing cold, or remotely cool. When I turn on the a/c the engine drops rpm's like it is engaging, or whatever, but doesn't get cold. I checked under the hook and it sounds like something is trying to come on every 10 seconds or so...it's like the engine jumps or something. The fan on the passenger side is coming on if that means anything but the driver side doesn't when a/c is turned on.
View 4 Replies
'01 Jetta IV GLS AC not blowing cold air:
1. Blower works on all 1,2,3,4 settings
2. Cabin Air Filter Clean
3. When AC button pressed, I see the Compressor turns and noted the clutch also engaged.
4. AC Fan near Radiator comes on
5. Blend Door seems to be working fine - fixed the problem of spitting foam without opening up the heater box.
6. Since the above electrical parts seem to be working, I suppose it could not be a relay issue.
View 1 Replies
having the issue where there aircon refuses to work even if the system is gassed up and leak free, and the compressor seems to be functional but not powering up. Before spending loads of cash on controller units, swtiches etc, your problem might be a dodgy connector under the battery tray.
As I have bought another Golf that appeared to have this issue, I took some photos this evening while I fixed it, hopefully this will be of use to people?
To start with, I had a look at my old Golf, which I knew had already been repaired. under the battery tray I found the repair. I put new tape on as the old tape was showing its age, so it shows up quite nicely - it's the blue tape!:
and a bit of a close up:
So now I knew what I was looking for, I had a look at my new Golf:
Which, I cut out, soldered the ends together, heat-shrink wrapped, then covered with some more trusty blue tape and zip tied it all up to try to minimise further chafing (the blue tape on the left is another part of the loom that looked like it needed a bit of tidying up):
A drive around this evening shows the aircon is now blowing a lot colder than before (previously it was blowing hot air after 5 minutes). I'll be testing it properly on a hot day, but I'm 90% certain I've nailed it.
View 5 Replies
I am trying to narrow down what could be the issue to my 2002 vw Jetta VR6 air conditioning. It is blowing air but the air is not cold. If I need to add refrigerant, where I can find the low pressure valve so I can do this on my own with one of those store bought cans.
View 2 Replies
No AC... Its not the fuse box on top of the battery, I recently already changed that. The air coming out is not cold at all, so I checked the pressure, and it was even higher then it was supposed to. After letting some pressure out, still no cold air. What could the issue be? Should I maybe bleed the system?
Also, its a 2001 GLX so I have climatronic....
View 4 Replies
My ac stopped blowing cold. The compressor turns on when I turn the ac on. When I pressure tested the low line port, it showed it was too high to add any recharge. 2001 jetta wolfsburg 1.8t....
View 2 Replies
The AC on my car (2002 Jetta 1.8t) quit blowing cold. Did some troubleshooting and...
1. Checked Freon- level was ok
2. Noticed cooling fans were not coming on with AC button pressed and ignition on. Fans also not coming on when car up to temperature, but gauge never went above normal. Seems strange considering I live in Houston and it was 95+ out.
3. tested fans with direct power and both high and low are fine.
4. jumped terminals 1,2 and 2,3 on plug for cooling fan switch and fans turn on high and low...so thought must be bad cooling fan switch.
5. Replaced cooling fan switch and still no fans or ac when AC button is pressed and ignition on.
6. replaced Fan control module. Still no fans.
7. Checked Freon once more...and although it was in the ok range decided to add a little more. (was in the middle of ok range, and a cheap gauge)
8. Compressor kicks on, along with cooling fan. End up using the 1 can I had and now have cold air and fans that come on when hitting the AC button with ignition set to on position.
I thought the mkiv cars would always turn on the fans when AC button is pressed with ignition on? Or does the compressor also need to be charged?
View 13 Replies
So my alternator went bad last week so I replaced it. Tested it yesterday and it was charging fine and drove it to work. I got the esp light on after driving 10 miles everytime I start it. So I go start it and it turns over slow but starts. Before I got to a friends house I was getting on it from a stop pretty hard and noticed the ac stopped blowing cold air. I go to leave a few hours later and it barely turns over and died shortly after moving. Took a while to jump it and the battery light blinked the whole way home. THEN, I go inside and hear something about 5 minutes later and my stereo is on! Also ABS light is on. Could a dead battery do all this?
View 1 Replies
My brothers car is a 2000 VW Golf 2.0 that recently started starting rough in the morning, when the motor is cold it will struggle to even turn on and will act like its only running on like 2 or 3 cylinders for a second and most cases stall, he is having to pump the throttle to get it to even stay cranked until it all sudden just starts idling fine and it idles perfect but still acts boggy if you try to rev it right away as its warming up, after about 10 seconds of it idling the motor can be revved perfectly fine and you can turn the car off and it will start back up immediately..
View 1 Replies
I own a 2000 Jetta VR6 5 speed. Car has over 300,xxxkm on it, with documented maintenance including chains within the past 12k. Car has intake, 2.5" resonated exhaust, stock software.
I have recently noticed that the car has a cold start issue. Its winter here in Canada, so in the morning when i go to start the car and let it warm up for a couple minutes, the idle is choppy at first and then evens out at around 900-1k rpm. If i try to blip the throttle, or even hold it (half way or WOT) the car just wants to bog out, EXTREMELY rough idle. It will eventually, after about 2 mins of idling, go away and i can drive.
I have absolutely no issue with allowing the car to idle for a few mins to warm up, but i know for a fact that whether a car is cold or not, it should be able to rev freely.
I also have horrible fuel milage. I use 91 octane, and average about 250-300km per tank. 70% city 30% hwy driving.
The following parts have been replaced in the past 1200 to try and resolve the issue
OE Mass air flow sensor
OE spark plugs
BREMI wires
OE Bosch front O2 sensor
I have scanned the car several times, which led me to change the parts i did. Only had a CEL once and it was for the front O2 sensor which i just replaced. Any other codes were for random multiple and a cat efficiency fault. Again those were fault found off a GFF test done at VW, they were not enough to trigger a CEL, but i still changed the parts.
View 3 Replies
I'm having the same issue as many others with the heat blowing cold air. I have read through the other post ad tried the blend door, actutator, vaccine lines, control ***, and both lines going in and out are hot to touch when warmed up. I am now lost!
View 10 Replies
I took my 2000 V6 Passat into the shop because my heater vents were blowing cold. They tested the system and told me the following:
The hoses leading to the heating core are warm, but no warm air is leaving the heater core, indicating that it's plugged up with corrosion. They testing the coolant fluid and found that the incorrect coolant had been put into the system and that the fluid was carrying an electrical charge that must be corroding the aluminum portions of the system. In addition, the engine temp sensor is kaput and never goes up.
They offered a garden hose flush the heating system for a few hundred bucks, but warned that it is only 50% successful. They recommend replacing the heating core.
View 2 Replies
After changing my CD player, my heater blows out cold air (not icy cold but cold like you have put the thermostat on low heat) all the time but my temperature gauge is perfectly normal! Its right in between cold and hot.
View 3 Replies
My battery died yesterday and after I got my car jump started the check transaxle light (exclamation point) came on and my A/C stopped blowing cold air. I checked all of the fuses and they are all fine. What could be causing this?
View 4 Replies
I just bought a 2000 f250 diesel truck and am having problems with the ac. When I first turn on the ac it blows very cold and works perfectly but after about 5 or 10 minutes it will start blowing warm and slightly humid air for probably around 5 or 10 minutes and then suddenly the very cold air will come back. This cycle repeats over and over again and I'm not sure what is wrong.
View 5 Replies
Today I got in the car and turned on the ac, got no air blowing. Turned the ac off and the heat up, still nothing. I assume the blower is shot or maybe the fuse? I could hear the vents switching from top to bottom as I changed it but no air coming out. Where would the fuse be? What to check? Engine cooling fans replaced last year and working.
View 1 Replies
This is on a 06 GTI. Yesterday my AC just stopped blowing cold. I checked the fuses did not find any that were bad. Belts are new, compressor is spinning, not sure if the clutch is engaging, can't hear anything clicking etc. Upon further investigation it is doing some weird stuff. Fan speed works fine, blows air but no cold air however if I try and get hot air (the heater) there is no change in air temp. If I turn the "ECON" button on and off no change. If I turn on the front defrost then I get Hot air but that is the only way I can get any temp change hot or cold, nothing will make it blow cold just to clarify. Last odd thing is if I crank the heat up to max I get no airflow from anywhere!? What is going on?
View 2 Replies
What are the normal things to look for to troubleshoot an A/C system? I do not have much experience with A/C's. I do not hear the compressor kick on, and it is blowing hot air. I know the fans should be on but both of them at the same time as soon as I turn the A/C on? I was thinking it's not the freon because it will lose its cooling over time not all of a sudden not work right?
View 24 Replies
I have a MKIV R32 and the other day I was driving with the A/C on, blowing cold air when randomly the air turned hot and hasn't blown cold yet. I took a look at the refrigerant levels today and they show a full charge along with the low-side refrigerant tube to the compressor getting cold but no still no luck.
The compressor is on so I don't think that's at fault, what else could there be? Something electrical maybe?
View 7 Replies
02 JettaVr6 auto tranny- car was running perfect, no CEL. Now all of a sudden the fuse keeps blowing out- what exactly is running off this fuse?
View 1 Replies
