I am trying to narrow down what could be the issue to my 2002 vw Jetta VR6 air conditioning. It is blowing air but the air is not cold. If I need to add refrigerant, where I can find the low pressure valve so I can do this on my own with one of those store bought cans.
View 2 RepliesThe AC on my car (2002 Jetta 1.8t) quit blowing cold. Did some troubleshooting and...
1. Checked Freon- level was ok
2. Noticed cooling fans were not coming on with AC button pressed and ignition on. Fans also not coming on when car up to temperature, but gauge never went above normal. Seems strange considering I live in Houston and it was 95+ out.
3. tested fans with direct power and both high and low are fine.
4. jumped terminals 1,2 and 2,3 on plug for cooling fan switch and fans turn on high and low...so thought must be bad cooling fan switch.
5. Replaced cooling fan switch and still no fans or ac when AC button is pressed and ignition on.
6. replaced Fan control module. Still no fans.
7. Checked Freon once more...and although it was in the ok range decided to add a little more. (was in the middle of ok range, and a cheap gauge)
8. Compressor kicks on, along with cooling fan. End up using the 1 can I had and now have cold air and fans that come on when hitting the AC button with ignition set to on position.
I thought the mkiv cars would always turn on the fans when AC button is pressed with ignition on? Or does the compressor also need to be charged?
I have a 2000 Jetta that doesn't blow cold AC. Here are the details:
- When the AC is turned on, air does blow through the vents. Each setting (1-4) does blow harder than the previous.
- Both front fans spin and are working
- The AC compressor clutch never engages
- All fuses (two inside the car and the one above the battery) have been replaced and test good.
- When the AC is on full blast, the voltage coming from the AC compressor wire shows ~9.3V for about 5 seconds, then jumps up to about ~11V for less than a second, this repeats over and over and the clutch never engages.
What the next logical troubleshooting step would be? I've read about this possibly being the fan control module (maybe) and also read about testing the AC compressor using an external 12V power supply, but am not sure where to go from here.
I have a mk4 gli and the a/c is not blowing cold, or remotely cool. When I turn on the a/c the engine drops rpm's like it is engaging, or whatever, but doesn't get cold. I checked under the hook and it sounds like something is trying to come on every 10 seconds or so...it's like the engine jumps or something. The fan on the passenger side is coming on if that means anything but the driver side doesn't when a/c is turned on.
View 4 Replies'01 Jetta IV GLS AC not blowing cold air:
1. Blower works on all 1,2,3,4 settings
2. Cabin Air Filter Clean
3. When AC button pressed, I see the Compressor turns and noted the clutch also engaged.
4. AC Fan near Radiator comes on
5. Blend Door seems to be working fine - fixed the problem of spitting foam without opening up the heater box.
6. Since the above electrical parts seem to be working, I suppose it could not be a relay issue.
having the issue where there aircon refuses to work even if the system is gassed up and leak free, and the compressor seems to be functional but not powering up. Before spending loads of cash on controller units, swtiches etc, your problem might be a dodgy connector under the battery tray.
As I have bought another Golf that appeared to have this issue, I took some photos this evening while I fixed it, hopefully this will be of use to people?
To start with, I had a look at my old Golf, which I knew had already been repaired. under the battery tray I found the repair. I put new tape on as the old tape was showing its age, so it shows up quite nicely - it's the blue tape!:
and a bit of a close up:
So now I knew what I was looking for, I had a look at my new Golf:
Which, I cut out, soldered the ends together, heat-shrink wrapped, then covered with some more trusty blue tape and zip tied it all up to try to minimise further chafing (the blue tape on the left is another part of the loom that looked like it needed a bit of tidying up):
A drive around this evening shows the aircon is now blowing a lot colder than before (previously it was blowing hot air after 5 minutes). I'll be testing it properly on a hot day, but I'm 90% certain I've nailed it.
No AC... Its not the fuse box on top of the battery, I recently already changed that. The air coming out is not cold at all, so I checked the pressure, and it was even higher then it was supposed to. After letting some pressure out, still no cold air. What could the issue be? Should I maybe bleed the system?
Also, its a 2001 GLX so I have climatronic....
My ac stopped blowing cold. The compressor turns on when I turn the ac on. When I pressure tested the low line port, it showed it was too high to add any recharge. 2001 jetta wolfsburg 1.8t....
View 2 Replies02 JettaVr6 auto tranny- car was running perfect, no CEL. Now all of a sudden the fuse keeps blowing out- what exactly is running off this fuse?
View 1 RepliesSo my alternator went bad last week so I replaced it. Tested it yesterday and it was charging fine and drove it to work. I got the esp light on after driving 10 miles everytime I start it. So I go start it and it turns over slow but starts. Before I got to a friends house I was getting on it from a stop pretty hard and noticed the ac stopped blowing cold air. I go to leave a few hours later and it barely turns over and died shortly after moving. Took a while to jump it and the battery light blinked the whole way home. THEN, I go inside and hear something about 5 minutes later and my stereo is on! Also ABS light is on. Could a dead battery do all this?
View 1 RepliesI bought a 2002 gti mk4 with about 127000 miles on it .I did not know the turbo fans were blown out , they were sitting in my down pipe next to my catalytic converter . So I replaced the turbo myself , and 2 hours later the fans fell out of the new turbo , what might be the problem ? why it keeps blowing.
View 7 RepliesI have a 2002 GTI 1.8T with the AWP engine and tiptronic. There is a fuse in the picture below that blows as soon as the car is started. It is located next to the brake booster on the firewall. It does not blow when the ignition is turned on, just when the engine actually starts. I'm not throwing a check engine light, pulling a scanner code or noticing any of my electronics not working. I took a 20 AMP fuse out and replaced with another 20.....and have since blown 5 of them trying to diagnose the problem.
View 10 RepliesLow ac line is cold
Fans kick on
Compressor clutch kicks on and spins with pulley till I turn ac button off
Added r134
Changed pressure switch
Changed ambient temp sensor
Car is just manual ac control and car blows at 80 degrees.what else could it be?cars 02 gti 1.8t
I just got this car it a 2002 jetta glx vr6 12v 5 spleed. It has a miss new plugs wires gas and used coil pack. It misses especially when cold check engine light on says cam sensor changed it and still same thing if I clear the code it comes right back.
View 1 RepliesI am having an issue with my 2002 GTI 1.8T. I have tried searching for an answer to this, and found a couple things saying maybe it could be the secondary air pump but wanted to get more opinions before I go shell out money to chase this problem.
When I start up the car in the morning after having it sit overnight, the car does the normal thing where it increases rpm's to about 1100 to warm it up. During this a loud "whistling" noise can be heard. Once the car is warmed up a little bit, the rpm's decline to about 900, and the whistling sound goes away. When this happens though it almost sounds as if a valve or something is closing causing the noise to go away.
Also, I am unsure if this is related to this, sometimes when I am driving, I will be accelerating and the car seems to stop accelerating as strong as it was, boost goes down from around 8 or 9 psi to about 4 and I seem to lose power as if I had let off the gas some. When I put my foot further down the car accelerates harder again and boost goes back up.
I have already changed spark plugs, cleaned MAF sensor, and run the 3m 3 part engine cleaning kit through it.
I have Golf MK4 1.6 16V BCB '02 and problem while engine is running on idle. Engine works at 1100 rpm (doesn't matter is it cold or warm engine) all the time.
Dashboard turns CHECK ENGINE and EPC lamps and says : "engine workshop". At the beggining of problem VAG-COM diagnostic found this error:
17953 - Throttle Valve Controller: Malfunction
P1545 - 35-10 - - - Intermittent
But after I've changed my old throttle body with new one VAG-COM diagnostic haven't reported any error (no permanent error) and idle issue stays.
While engine is running and Check engine and EPC lapms are turned on diagnostic reports this error:
17961 Barometric/Manifold pressure signals: Implausible Correlation
P1553-35-10 ----Intermittent
After engine is turned off diagnostic doesn't report any error!
Beside of changing throttle body, I've changed ECM, MAP sensor, temperature sensor, EGR valve, . Also checked intake manifold and hoses if is it leaky (doesn't leak anywhere), and timing belt is ok and checked complete wiring installation!!!
I have this weird problem where my cars blows air at all speeds but the AC and heater doesn't work, what it could be? Maybe blower motor relay?
View 1 RepliesAfter changing my CD player, my heater blows out cold air (not icy cold but cold like you have put the thermostat on low heat) all the time but my temperature gauge is perfectly normal! Its right in between cold and hot.
View 3 RepliesA/c is fully charged. Could be blowing cold one second, and blowing hot humid air the next.
View 5 Replies02 Camry with 202k. Recently my car has been blowing cold air only when it's on heat. Then it will start to overheat causing me to stop and pull over and I see little smoke come out. Also it has been leaking antifreeze and when I make sharp turns or come to a stop I can hear water or something behind the dash...
View 5 Replies2002 Passat v6 - climatronic control...
I have just cold air blowing at idle and under load. I have read posts and checked the following: temp remains at 190, heater coil hoses-both are hot and removed the dash to see if the flapper door (red arm) was moving-it is. Any other things I can check?