My ac stopped blowing cold. The compressor turns on when I turn the ac on. When I pressure tested the low line port, it showed it was too high to add any recharge. 2001 jetta wolfsburg 1.8t....
View 2 RepliesThe AC on my car (2002 Jetta 1.8t) quit blowing cold. Did some troubleshooting and...
1. Checked Freon- level was ok
2. Noticed cooling fans were not coming on with AC button pressed and ignition on. Fans also not coming on when car up to temperature, but gauge never went above normal. Seems strange considering I live in Houston and it was 95+ out.
3. tested fans with direct power and both high and low are fine.
4. jumped terminals 1,2 and 2,3 on plug for cooling fan switch and fans turn on high and low...so thought must be bad cooling fan switch.
5. Replaced cooling fan switch and still no fans or ac when AC button is pressed and ignition on.
6. replaced Fan control module. Still no fans.
7. Checked Freon once more...and although it was in the ok range decided to add a little more. (was in the middle of ok range, and a cheap gauge)
8. Compressor kicks on, along with cooling fan. End up using the 1 can I had and now have cold air and fans that come on when hitting the AC button with ignition set to on position.
I thought the mkiv cars would always turn on the fans when AC button is pressed with ignition on? Or does the compressor also need to be charged?
'01 Jetta IV GLS AC not blowing cold air:
1. Blower works on all 1,2,3,4 settings
2. Cabin Air Filter Clean
3. When AC button pressed, I see the Compressor turns and noted the clutch also engaged.
4. AC Fan near Radiator comes on
5. Blend Door seems to be working fine - fixed the problem of spitting foam without opening up the heater box.
6. Since the above electrical parts seem to be working, I suppose it could not be a relay issue.
So I bought a 2004 Jetta with the 2.0 engine yesterday. I got the car pretty cheap and was told that the issue with the A/C was because it was low on freon. I've never owned a Volkswagen before, but I assume A/C units are all similar. So I go to put in some freon into the low end of unit. I get about half of a 12 oz can or so in and I hear a loud Psst or shooting of the propellant. I look down and it looks like the the side of the compressor shot the oil filter with the coolant. I'm not sure if I sprung a leak of if it was just a valve that releases when there is too much pressure. I've only driven it for about 10-20 mins since and I can still occasionally hear the Psst sound. It is 96 degrees in my area if that makes a difference or not?
Some other information, I noticed that the compressor kicks on, but only for like a second or two and then it shuts off for about 15 seconds or so and then repeats itself. What could be wrong?
99 Jetta VR6... 190k
So the heat doesn't really work on my car- and its getting cold outside.
I read the DIY on fixing the resistor pack, but there is a lot of hooptiness to my ride, (not sure if that's the issue).
All the fan control speeds work, but the most I ever get is vaguely warm air- it never gets fully hot.
The temperature gauge does not work most of the time- it does occasionally (but randomly) work as expected.
The defrost doesn't work either due to an issue with the AC (it keeps blowing the fuse for the AC compressor- like, right away)
There's a multitude of issues happening here I know, but need to narrow down the suspects for the heat, that would be very useful.
Ok here is the issue, my girlfriend owns a MK4 '99 Jetta. Through the search I was able to figure out why she is having so many issues with her door locks and how they can be fixed on the cheap..thats awesome. But here is the problem. She was driving down the road the other day, A/C working...then suddenly it stopped blowing cold. Fan is still working, just blows hot air. She said it started blowing warm suddenly and hasnt been getting warmer through out the past days or anything.
With the hood popped and the a/c on, you can see that the compressor isnt engaging. The car makes a noise like its engaging the compressor, but nothing is happening that I can see visually. Seems as if the compressor is not getting the signal to engage. It sounds like its trying to make the compressor kick on about every 5 seconds or so. Basically that initial clicking sound that your hear RIGHT before the compressor comes on when its working normally.
We have checked the fuses and no luck with those, all look good. Seems like its an electrical issue to me. What this may be? Bad pressure switch? Low pressure in the system? I know the car has had the compressor replaced before...and the clutch seems to spin freely when the car is off.
The A/C does not blow cold. The Compressor clutch does kick on and stay on The passenger side fan kicks on only (I think the driver side is toast but i need to test it to confirm) The system has 45psi on the low side
I did not check the high side as I don't have a gauge for it but will get one if I need to test that. So my thoughts are that my expansion valve is toast which is what expands the hot liquid and turns it to cool liquid so the A/C gets cold. I think this because it seems all of the other components work.
I have a 2000 Jetta that doesn't blow cold AC. Here are the details:
- When the AC is turned on, air does blow through the vents. Each setting (1-4) does blow harder than the previous.
- Both front fans spin and are working
- The AC compressor clutch never engages
- All fuses (two inside the car and the one above the battery) have been replaced and test good.
- When the AC is on full blast, the voltage coming from the AC compressor wire shows ~9.3V for about 5 seconds, then jumps up to about ~11V for less than a second, this repeats over and over and the clutch never engages.
What the next logical troubleshooting step would be? I've read about this possibly being the fan control module (maybe) and also read about testing the AC compressor using an external 12V power supply, but am not sure where to go from here.
I have a mk4 gli and the a/c is not blowing cold, or remotely cool. When I turn on the a/c the engine drops rpm's like it is engaging, or whatever, but doesn't get cold. I checked under the hook and it sounds like something is trying to come on every 10 seconds or so...it's like the engine jumps or something. The fan on the passenger side is coming on if that means anything but the driver side doesn't when a/c is turned on.
View 4 Replies having the issue where there aircon refuses to work even if the system is gassed up and leak free, and the compressor seems to be functional but not powering up. Before spending loads of cash on controller units, swtiches etc, your problem might be a dodgy connector under the battery tray.
As I have bought another Golf that appeared to have this issue, I took some photos this evening while I fixed it, hopefully this will be of use to people?
To start with, I had a look at my old Golf, which I knew had already been repaired. under the battery tray I found the repair. I put new tape on as the old tape was showing its age, so it shows up quite nicely - it's the blue tape!:
and a bit of a close up:
So now I knew what I was looking for, I had a look at my new Golf:
Which, I cut out, soldered the ends together, heat-shrink wrapped, then covered with some more trusty blue tape and zip tied it all up to try to minimise further chafing (the blue tape on the left is another part of the loom that looked like it needed a bit of tidying up):
A drive around this evening shows the aircon is now blowing a lot colder than before (previously it was blowing hot air after 5 minutes). I'll be testing it properly on a hot day, but I'm 90% certain I've nailed it.
I am trying to narrow down what could be the issue to my 2002 vw Jetta VR6 air conditioning. It is blowing air but the air is not cold. If I need to add refrigerant, where I can find the low pressure valve so I can do this on my own with one of those store bought cans.
View 2 RepliesNo AC... Its not the fuse box on top of the battery, I recently already changed that. The air coming out is not cold at all, so I checked the pressure, and it was even higher then it was supposed to. After letting some pressure out, still no cold air. What could the issue be? Should I maybe bleed the system?
Also, its a 2001 GLX so I have climatronic....
So my alternator went bad last week so I replaced it. Tested it yesterday and it was charging fine and drove it to work. I got the esp light on after driving 10 miles everytime I start it. So I go start it and it turns over slow but starts. Before I got to a friends house I was getting on it from a stop pretty hard and noticed the ac stopped blowing cold air. I go to leave a few hours later and it barely turns over and died shortly after moving. Took a while to jump it and the battery light blinked the whole way home. THEN, I go inside and hear something about 5 minutes later and my stereo is on! Also ABS light is on. Could a dead battery do all this?
View 1 RepliesI have a weird problem. Sometimes when i slow down to make a turn or stop at a stop sign my car just dies...that's it...it just turns off...but i turn the key and it starts right back up...the weird part is that i've had the car for a year and it only does it about once a month??? I took it to the dealer and...big surprise...they said they couldn't find anything wrong with it...it doesn't turn off while I'm driving on the highway or anything...only does it when i slow down to make a sharp turn or when i stop at a stop sign and go again... I might just trade it in for an Audi A4. I have a 2001 Jetta 1.8t...
View 24 RepliesI recently replaced my driver side axle due to the inner CV joint boot being ripped. Its a 2001 Jetta VR6 with 173,000 miles on it and I have been driving it with a ripped boot for about a year and finally decided to replace the whole axle last night. I replaced it with an aftermarket axle (was on a budget) and the job was fairly easy. Since I did it late at night I was too tired to take it for a test drive so I waited until today. When I was driving it all was well until I took a right turn and I could hear a very distinct clicking sound coming from the driver side wheel well, it is constant throughout the turn.
The noise is only present when taking turns above 20mph and it sometimes even occurs when driving in a straight line. Take note that I have not had an alignment done yet since I had replaced the axle. The car is lowered about 2 inches on Raceland coil-overs that are pretty old and I think they are shot. But like I said the car has NEVER made this sound until I just recently replaced the axle. I am at a loss of what it could be and I am trying to sell the car currently so I would like to get this problem sorted out as soon as possible!
The A/c stopped blowing cold on my 06 Passat 2.0t. I checked the pressures on the low side of the system and it was 100 psi with a cold engine and 130 when hot. Obviously this is too much. It seems as if the compressor is always engaged even when the a/c is off (every part of the a/c pulley is always spinning the little nut sticking out of the center of the pulley spins as well not but im not sure if that's how it is when the compressor isn't engaged).
View 17 RepliesSo my Ac is not blowing cold at all. I can hear the compressor cycling. I filled the sys with freon. Still not cold I am pretty sure I have a leak but wouldn't it still blow cold? What do I need to check to fix this? The temps are getting in the upper 90's and 100 s I need Ac bad...
View 14 RepliesI have a 2012 truck that the AC wasn't blowing cold air this summer so I took it in and they said nothing was wrong... Took back in and they replaced vent control... worked a little bit. Fall came and my windows fog up and really never clears up so I take it in and they said it is blowing hot air but I told them that isn't the problem but the moister in the cab is the problem. I feel I'm getting the run around.
View 9 RepliesWhen I turn on my air conditioner it just blows air, not cold air just air. If I turn it to heat it also just blows air, not warm air, just air. The fan settings all work fine but the air coming out never changes temperature. By the way, If I bypass the compressor clutch relay with a paper clip, the AC will kick in. I refilled the coolant in the AC system too but it won't engage without bypassing the relay. Plus, the heater is not "kicking in" either. I did recently install a new wiper motor but I am not sure if that may have contributed to the air issue that is happening now.
View 7 RepliesThis week was our first nice week of the year. Monday I got in my truck at lunch time turned the a.c. on and it blew ice cold. Today my truck sat in the sun all day and I got in it and turned the a.c. on. I noticed instead of the normal "click" you hear when the clutch engages in the a.c. compressor I got a wine and wimper kind of noise. The system never cooled the air after this happened. Is the compressor shot? Is it safe to drive or is the compressor going to tear itself up and send metal pieces thru the system?
View 7 RepliesWhen the weather gets cold, (lower than 45 deg. F) my Jetta does not want to stay running. It turns over and starts just fine but it does not like to stay on. When I turn the key to the #2 position I can hear the fuel pump fire up and pressurize the system. I always attempt to start it after that, and after 1-2 seconds of running, it seems like it chokes itself out. I have the new coolant temp. sensor (green top), my MAF has been replaced, all spark plugs are new with the correct gap (approx. .030"), new air filter, I run 93 octane fuel.
The worst part is, once the car is warmed up (After forcing it fuel and starting it over, and over, and over again) it runs awesome! I have had this problem since I bought the car (about 2 years ago). The owner told me about it and mentioned that he has never been able to figure it out either (trips to the dealer included). I have been dealing with it for 2 years, but it is getting much worse. Over the past 2 days I have not been able to get my car to stay on long enough to get it to move.