Golf IV / Jetta IV :: 2000 GLS Run Fine For 10 Minutes Then Will Stall - ECU Replacement
Feb 2, 2015
I took my 2000 Jetta GLS 2.0 5 speed it a certified mechanic shop that I have used before. This scan show a speed sensor (which I already replaced) and the ECU. He said that the ECU is discontinued and that he could not do the repair.
The car will run fine for 10 minutes then will stall, wait 5 minutes and it will run again for 5-10 minutes stall and repeat the process. Question, what is involved with swapping the ECU with an identical numbered one from a junk yard? Also could swapping out my headlight assembly have any effect, this started to happen shortly after the new headlights were installed.
View 6 Replies
Advertisement
My brothers car is a 2000 VW Golf 2.0 that recently started starting rough in the morning, when the motor is cold it will struggle to even turn on and will act like its only running on like 2 or 3 cylinders for a second and most cases stall, he is having to pump the throttle to get it to even stay cranked until it all sudden just starts idling fine and it idles perfect but still acts boggy if you try to rev it right away as its warming up, after about 10 seconds of it idling the motor can be revved perfectly fine and you can turn the car off and it will start back up immediately..
View 1 Replies
My wife drove the car to work, and it ran good. She got a check engine light, but it was not on when I got home from work. I started the car and it idled fine for a couple of minutes and then it stalled. I check the codes and there was nothing locked in. There was a pending coding P0321. I am not sure what a pending code is, but I assume not enough to trigger the check engine light.
After work each night this week I tried troubleshooting but I have not gotten anything accomplished. Each night the car would start fine but if I turned it off it would not start until many tries if at all. It turns over strong but won't start. I drove it around the neighborhood today and it stalled and wouldn't restart.
The fuel pump primes. When the car won't start the fuel pump relay clicks constantly. Is this normal? I replaced the fuel filter because it has been 50k miles. Is the crank shaft sensor the problem? I hate to throw money at parts that aren't the problem when I can't get a code to trip the check engine light.
View 4 Replies
I'm really bad with cars but I'll try to be as specific as possible.
Car: 2002 VW Jetta
Basically the car will just stall out of nowhere while driving (not stopped at a light), I would say usually about 10-20 minutes after I started driving. After this, when I try to start it, it makes that noise like it is trying to start but the actual ignition doesn't happen. it usually takes me about 15 minutes to start it up again.
In addition to this, when driving, the RPM seems to randomly drop off often, and the car also jerks frequently, especially when I press on the pedal quickly.
View 5 Replies
My 2001 Accent doesn't give me any power when its cold in fact when I try starting it when its cold, the car will start and then after 1-2 min would violently (may be that's a little too strong a word to describe it) shake and then stall. This happens about 1-2 times and then the car finally starts.
If I drive my car uphill (not a very big), after heating it up, car would just start moving along slowly (or stall) even on the first gear and full gas. And sometimes while driving the car loses all power. It just trudges along no matter how much gas I press,
I no nothing about cars, so I am not sure if I conveyed my problem correctly. I just hope that the problem is fixable and wont cost me my entire salary to fix.
P.S: I always thought that the problem was me and that I couldn't drive a manual. Today a friend of the mine, who has been driving manual for 20 years also had the same trouble.
View 4 Replies
The car will start and run for about 10 seconds and stall. The engine has been completely rebuilt 20k miles ago. The timing is perfect and the car makes 190psi on every cylinder
I should point out that it is NOT the immobilizer. it has been checked over and over and verified to not be the immobilizer. Here is everything that has been done.
- New fuel pump
- fuel filter
- fuel pump relay
- fuel pressure regulator
- fuel injectors
- fuel pressure has been verified
- spark plugs
- ignition coils
- crankshaft position sensor
- cam position sensor
- MAF sensor
- throttle body
- CU has been tried in another Jetta. worked fine
- gauge cluster worked fine in other Jetta as well.
- brand new battery
- alternator checked and passed
- grounds checked, all fine
The car has been scanned with VCDS. Here are the results:
6 Faults Found:
01330 - Central Control Module for Central Convenience (J393)
53-10 - Supply Voltage Too Low - Intermittent
00955 - Key 1
09-10 - Adaptation Limit Surpassed - Intermittent
01331 - Door Control Module; Driver Side (J386)
53-10 - Supply Voltage Too Low - Intermittent
01332 - Door Control Module; Passenger Side (J387)
53-10 - Supply Voltage Too Low - Intermittent
01333 - Door Control Module; Rear Left (J388)
53-10 - Supply Voltage Too Low - Intermittent
01334 - Door Control Module; Rear Right (J389)
53-10 - Supply Voltage Too Low - Intermittent
Here is a video of what the car is doing.
I am able to rev the engine but it dies quickly afterwards. vacuum pressure looks completely fine on the boost gauge.
My roommate has a 1.8t jetta as well so I have access to his car for trying things with.
View 3 Replies
So I have been trying to get all the issues fixed on this car, and I think I'm getting close. I just gave the car a tune up, minus a new coil pack. (2.0 engine) I've fixed the broken hose on the secondary air pump and all my error codes appear to be gone. However, when I start my car on humid mornings, the car struggles to stay running. Once the car is up to a certain temperature, the car has no problems. But while it is cool and struggling to run, the check engine light will come on and flash. I heard that it could be from a crack in the coil pack that allows moisture to come in. Does that sound right? I would hate to put a new coil pack if I don't need it yet.
View 2 Replies
So I was waiting in line at a drive through, because Fast Food is the breakfast of champions. And suddenly my Oil Light started blinking. It beeped, then blinked. It didn't stay on solid.
So I figured I was suddenly low on oil. I then noticed my engine temp was pegged to the max. So I abandoned my Egg McMuffin (Not an easy choice by the way) and I pulled out of line into a parking spot and shut down my engine.
I gave it a few moments to cool down and checked the oil level. In the past my oil light has come on if I was low on oil and a 1/2 quart or so was all I needed. But after 20 minutes of cooling down, I checked the oil level and it was fine. Not even close to low.
I made some calls, talked to some people, ate a McMuffin and checked the level again. It was still good. So I restarted the car now that it was totally cooled down. It warmed up fine, right to normal temp, no overheating, no oil light and all seemed well. So I drove it home (About 12 miles) without issue.
Also, Prior to this issue (within a couple months) I switched to Synthetic Blend. And it may just be a coincidence, but my AC also failed about 3 days ago.
View 3 Replies
weird thing happens in my 2.0 manual jetta. every 1500ish miles, when coming to a stop, it feels like my car is about to stall but its not in gear.The trip milage will reset, radio will turn off, dash will dim, but no CEL. Since then key fob doesnt work (replaced fob batteries), and my DRL are off. still cold starts no problem (figure its not the battery), trying to figure out if i can get closer to what needs a fix before tearing into something unrelated.
View 3 Replies
I just got done with a complete engine rebuild on my 02 1.8t jetta, had everything hooked back up and went to start it for the first time and it wouldn't. I went back looking for loose connections, nothing. Worked and banged my head for a day or two, I had fuel and spark but couldn't get it to fire. Finally I "choked" the intake to see if it was getting too much air and it fired right up. I unplugged my map sensor giggles and it starts up perfectly. I then hooked everything back up and what do you know it starts up and runs fine, but if I plug the sensor back in it kills the motor after about 10 seconds of running and won't start until I unplug the map again.
Car runs and drives but wont boost over wg pressure but that's probably because sensor itself is unplugged. I just wanna know what could cause it besides the sensor itself being bad. I ordered a new one waiting for it to get here (hoping it fixes the problem).. And I'm talking map (manifold absolute pressure) not maf (mass air flow), just in case people are confused.
View 4 Replies
2002 Jetta GLS 1.8T (engine stock except diverter valve) 171k miles
It's done this a couple times now. Both while raining out/high humidity. Prior to this, I could hear the pump "growling". Sounded like maybe starting to go. You could hear it prime when opening the door or turning the key forward but would stay sounding like that even when the car was started. Without the radio, you can hear the pump running.
1st time- The car will crank without issue but never start. I let it sit a few minutes, turned key, heard it prime,tried again, started right up like there wasn't an issue and I couldn't hear the pump this time while the car was running.
2nd time-The car will crank without issue but never start. I let it sit for an hour, opened door (couldn't hear prime), checked fuse 28 (good). Figured wth, let's try anyways. Turned key, couldn't hear prime, started right up. WTF. cold idle normal (1000-1200rpm), light revs to 3000 ish normal. Turned off car, let sit for a minute. Turned key, heard prime, car started without issue and I couldn't hear the pump again while the car was running.
My dad is thinking to replace the pump right away. Is there anything else to try? The relay is working... at least sorta. With the somewhat intermittent issue, where to start? Either way, relay or pump, I will be replacing fuel filter.
View 3 Replies
My 03 GTI 1.8 is having start issues. It cranks up fine, but it sputters to a start. It doesn't idle high and fall down to the 850 mark like normal, it just lugs itself into low idle. I have to then throttle it until it stops sputtering and I have a smooth rev. Then after that, the car runs fine. I can stop it and start it up again fine when it's warmed up. I have checked multiple things already.
-The Ignition coils are in excellent condition
-Spark plugs are normal, but not exactly perfect
-Fuel pump works fine
-Battery was tested and is clean and good
-Throttle Body is clean (at least to the eye, Im cleaning it next)
-Oil was changed when I changed the sensor along with filter.
I should mention I changed the crankshaft position sensor a month ago. The block at least from under the car is filthy, but I don't know if that affects anything.
I had a check engine light, so I got its codes read (I'm out rn, but when I get home I can show you) and decided to just take it to a shop. When I took it, the light went away, decided to start as normal, and the shop just charged a huge fee for the diagnostic and nothing was fixed. I really need to know what to do with this, I daily it every day and its starting to bother me a lot now.
View 16 Replies
I just bought a 2002 Jetta 2.0L with automatic trans and about 98000 miles on the odometer.It drove fine on a short test drive. It drove fine on a 45 min drive home after which I parked it for a short while (about an 60-90 mins.) Then I tried to restart it . It cranked fine but would not start. After 3 or 4 attempts I let it rest for a min and then it started. And the CEL came on.
This was a few days ago. Today I finally got a chance to scan it with these results:
VCDS Version: Release 15.7.3 Running on Windows 7 x86
[URL] .....
Address 01: Engine Labels: 06A-906-032-AVH.lbl
Control Module Part Number: 06A 906 032 FR
Component and/or Version: 2.0l R4/2V G 4070
Software Coding: 00003
[Code] ....
I'm new to MK4's and I'm at a bit of a loss as to where to start. It looks to me like there's a problem with both the fuel pump relay and the crank sensor. But what to make of all the short to ground codes. Could they be caused by a bad fuel pump relay?
View 4 Replies
Is this a warm stall issue and if so what is the actual solution to it ?
- Car is warm it will stall out at times after start . Giving it some gas will save it from stalling
- When dead cold it will have a very sluggish start
New plugs and coils. New fuel pump fuel filter & regulator . New crank sensor . Throttle body cleaned as well as maf. evap leaks all sealed up too. battery is good too
Very frustrating. Only solution would be to leave it at a shop for at least two hours so they could do live scans. But I'd rather not pay two hours of labor for nothing.
[URL] ....
View 8 Replies
I have a 2.0 auto city golf. The wife claims when she's sitting at a light the temp gauge drops to nothing, it sounds like it stalled and starts to roll back and then comes back to life when she pumps the gas. Every time I drive it it's fine.
View 2 Replies
My sunroof opens and closes correctly. but when in the closed position it will be sunken into the cabin of the car a few MM not sealing to the body of the car tightly. how do I fine tune the sunroof to sit flush with the body when closed? some kind of adjustment screws?
View 4 Replies
At times my windshield wipers stall halfway up my windshield or move really slowly. Other times absolutely fine, I already checked both battery terminals and niether were the issue. What's the best way to get to the wiper motor to check the connections. Or does it sound like a ground strap issue elsewhere on the car.
View 5 Replies
I just posted how happy I have been with my 2004 GTI 1.8t, then something strange happened. I was coming up to a light at night, turned on my turn signal and hit the brakes. The engine stopped abruptly and then began running fine without a restart. It was only for a split second. The lights went out, car died and began to run again very quickly. I noticed later that the clock had changed to the wrong time. I have noticed that lately at night the headlights dim slightly when I brake. That's the only clue. New battery, Alternator checks out fine.
View 5 Replies
330,000 km on car. I drove 45 minutes when battery light came on on and car engine stalled when making a left turn (fuel light had just come on too but not empty) and restarted on own, drove 10 minutes and it stalled again, so I pulled over and restarted. Drove 45 minutes home. No issues since. Shop says 10 year old battery and alternator are testing fine, though they suggest replacing alternator as it may be going. Could there be other electrical issue since the issue is more intermittent? Car would not stall immediately if alternator failing I would think - should run on battery for a bit and not restart. Drive maybe 400km per month and it sits for 10 days at a time.
View 4 Replies
I have a 1995 f-250 7.3 liter diesel engine. Truck starts fine and runs good for a while and then it will stall. I pull over and after a couple of attempts it will start and run fine for a while. I have changed the fuel filter and put fresh fuel in but it still stalls.
View 7 Replies
My neighbor has a Astro van
1999 4.3l automatic
He is having his van run for about 25-30 minutes and then stall out and die. It will not restart unless you wait about 15min or so and do it again. It reaches 195 and runs find for at least 10 min after reaching temp.
63psi on the fuel.
no security light.
DTC is misfire on cyl 4 but may be due to a wire not being tight. I will check it out.
I am not sure where to go from here. Tested a new MAF and no difference. I am thing next maybe ignition switch or fuel pressure regulator.
View 14 Replies
