Golf IV / Jetta IV :: 2004 1.8T Randomly Stuttering And Dying
Feb 19, 2015
I'm getting used to just expecting a problem with this car every 3 months or so. Anyway, I have a 2004 1.8T GLI which lately has been idling and then stutters and dies. The first time it happened it turned right back over and started driving. So I drove it home and cleaned up the battery terminals and it didn't seem to have a problem since. Now about a month later I was just parked and turned it over.
It was on for about 1 second and then it stuttered and died. I can hear the starter engaging and turning the engine, but it won't turn over. I also checked the battery levels and its showing 12v so I don't think it's electrical? From scanning forums here it seems like the two prime suspects are spark plugs or the fuel pump?
Also checked the fuses and none are burnt. I could see it being the fuel pump because that would explain it randomly stuttering and dying. Also the car is at 149k miles and that is the original pump. Wondering if maybe it being at 1/4 tank isn't working either? Going out to buy a vagcom and see what codes it throws!
View 2 Replies
Advertisement
My sons 05 F150 is randomly dying during low idle. We removed and cleaned the TB and cleaned the MF sensor. For example, if he is coming up to a stop or slowing down, the truck will die, but starts right back up. So far no CEL and truck seems to idle and run fine, just ever so often will die.
Anything to check on the 5.4s
View 3 Replies
I have a 2004 6.0 that has been pissing me off to no end lately. I has a random dying/no start problem. If it idles for ten minutes, it'll die sometimes. And if I drive it and shut it off, it won't restart sometimes. I just drove it three hours on Friday, shut it off and it restarted immediately. Drove it around town all weekend and it started fine every time.
Now driving it home and stopped for fuel 45 minutes in, and it won't start. I have all sensor readings in spec except for I have no ficm sync while cranking. I have about 5k miles on new hpop, injectors, ipr valve, icp sensor, oil rail rebuilds, stand pipes, ficm and engine harness and injector harness. No codes either. If it sits for a couple hours it'll start fine. I've wiggled as many wires as I can and it still won't start. I have rpm while cranking on my edge too. Don't know if that would rule out crank sensor or cam sensor.
View 7 Replies
My wife drives a 2004 2WD Explorer with the 4.0 SOHC motor. We have had a problem now for over a year and a half of it randomly dying. There is not telling when the engine might die besides the fact that it happens when you let off the accelerator to brake or make a turn. It only happens at slow speeds. At a stop light or stop sign usually. The car will always start right back up. It has been to a couple of Ford dealerships and they haven't been able to diagnose the problem. The check engine light is on and it is giving the code p0456. This code definition is an EVAP small leak detected. Probable causes for the code are:
1. Defective, loose, or missing fuel cap.
2. EVAP Canister broke, hose cracked or not connected.
3. Purge or vent solenoid defective.
4. Vacuum leak at engine.
I don't think it's the fuel cap that would be making the car die. I used carburetor cleaner (I know its not the safest ) and sprayed on the vacuum lines that I could find to try and diagnose a vacuum line leak but nothing seemed to effect the engine. Do one of the other probable causes from p0456 could be causing the dying or could it be something else???
View 6 Replies
I recently had my alternator and battery replaced due to my truck dying out randomly on me, tested the alternator and failed, replaced battery, and still got the same results, battery gauge seems to drop quickly, what could be going on, I have been told to replace the fusible link that goes from the battery to the alternator....
View 1 Replies
So I have a 2004 jetta GLI (1.8T) with forge splitter valve and short ram intake. I went and got my codes pulled and all 4 cylinders misfiring and random misfires. I replaced both coil packs and spark plugs. check engine light popped up again after about 20 miles and same thing. I just bought the car so I'm not sure how long it has been running with these misfires. I just got the timing belt replaced. I know it could be off a tooth. (Wouldn't a code pop up though for it?) How could I check that. And I also took my MAF sensor off as well and no change. Heard it could be clogged cat, any way to check? I've also cleaned the throttle body. It runs fine when I'm driving, just a rough idle.
View 15 Replies
I bought a cheap golf in february. It's an akl engine (1.6sr). Everything was fine on the way home. The car then wasn't used for like a month or two, and was stored outside. When we started using the car it gradually got more and more stuttering. At first it was just a slight stutter when accelerating, but now it's horrible. It will stutter and hesitate like crazy when accelerating or under load, but will cruise just fine at normal rpms. So far I have changed the air filter, fuel filter, spark plugs and a bad spark plug wire, but nothing has worked. I bought a vag scanner but couldn't find any codes. The idle isn't too bad but not perfect. What the problem can be?
View 10 Replies
1.6 FSI .. Very long story short, the engine is running like crap, idle is jumping up and down. Almost no power, its stuttering and so on and so on. Well I talked to a mechanic and he found out the problem, a throttle vacuum. (kinda like choke) he explained it as.
The part was ordered, and arrived. Me and my dad tried changing it and we met some struggles. After looking at it closely and trying different things we kinda gave up.
Here is the part that is broken, it adjusts the amount of fuel when its cold vs. hot
We concluded we needed to take the whole intake to access it ?
View 2 Replies
2004 gli , 1.8t , 136k , 6 speed
The car started misfiring after exiting the freeway, at the light it felt like it was gonna cut off. The brake pedal is stiff like the car is off. When it's idling is when it's most noticeable. It smoothed out after 2nd gear at like 35mph but still not right. The pedal thing has never happened before but I knew the sputtering was the coils, so I had it scanned and sure enough. 5 codes.random misfire.. random misfire all four cylinders.. so I bought 4 and replaced the old ones.. Changed the Sparks as well. No change.. The cel came back on..still idling rough.. What it could be.
View 5 Replies
04 jetta 1.8t
apr tune 1.6v
neuspeed 4bar fuel pressure regulator
3" turbo back
APR TIP
This is the second time this happened to me. First time was about two weeks ago where i was just driving and the car stalled. Tried to start but it sounded like it just wasn't getting fuel. Brand new battery, terminals are clean) Got it started and it was revving high like a cold start, normal but why after driving for 30 mins? EPC light came on also which was strange along with the CEL, a buddy checked the code and it was for the secondary air injection pump. (I have not had that go off in a while. Code po4011 secondary air injection. Had this issue a while ago with that code when i did a short ram intake. Tuner cleared it so i can pass emissions. ) Now today it died about 2 miles from my house. Same thing but no CEL. EPC light came on and car was revving high, luckily 3 cars behind my buddy was there and he give me a push into the gas station. Once again it wanted to start but i felt like no fuel. waited a few minutes and it started right up again until it almost died in my drive way. Cluster comes on when it dies. ignition is good.
My big question is the stalling part and the EPC light coming on, then the car revving like it is a cold start but not stopping? and i need this car to be working.
View 11 Replies
My car battery keeps draining when my car is off, lights off, everything is off....... the only thing that ive figured out is that if i pull the fuse to my radio, it wont die, but sometimes if i dont pull the fuse it still wont die......
View 15 Replies
I have a mk4 jetta 2.0l with about 130,000 miles. The issue with my car is that is has a rough idle and dies out completely when I put the car in neutral. I currently have codes 16839- EVAP system leak detected, 16487- Mass air flow sensor, 17978 - Engine start blocked by immobilizer, and 16795 - secondary air injection system incorrect flow detected. The secondary air pump was taken off the car before i bought it, so i do not think that code is responsible. Also all of my spark plugs and wires are new. I think the issue is either with my maf sensor or with a vacuum line. I have tried cleaner my maf and also unplugging it, and the car still has problem. Unfortunately i do not know where all of my vacuum line are. I have only checked the two the go into the sensor on towards the firewall. The one has vacuum, but the one coming for the egr valve did have any vaccum even when i tried with my other line on it. Im not sure if this is the issue, and if it would cause my car to die.
View 6 Replies
This is on a 2001 golf, 5 speed, ALH.
Just went for a drive the other day and the ABS light started to flicker on, and then it was accompanied by 3 loud beeps, which I understand is the ABS warning.
Then the gauges all died like I turned the car off, but the engine was still running. No limp mode, no stumbling, nothing.
The needles then bounce back to where they should be, and various lights on the dash flicker, oil pressure, battery, etc. Not any pattern to them, they all just kind of blink on and off randomly. Then it will stop and run fine for 20-30 minutes (longest I have driven it like this)
Sometimes when I put the key in the on position before starting it, the gauges will do the same thing, without the beeping, and it is like I am cylcing the key on and off several times, needles on the fuel and temp gauge bounce between zero and their actual reading (other gauges don't move because I'm at zero rpm and zero mph)
I have replaced fuses 11 and 15, checked battery voltage with the car off, idling and at 2000 rpm, 12.3 volts with the car off, 14.3 with it idling and at 2000 rpm
The cheap code reader at the parts store gave me a P1650 code, which is intermittent communication error on canbus (paraphrasing) which makes sense for the symptoms, but I know on these cars sometimes a totally different system in the car can interfere elsewhere.
I am going to check/clean grounds, what else should I be looking for?
View 2 Replies
Battery kept dying. Had the battery tested. Bench tested as OK but kept dying. Replaced the battery with a new OEM. In a week, that battery was dying too. Alternator was putting out 13V but would dip down to 11V. Also did a parasitic current draw test. Car is only drawing 20mA at rest. Replaced the alternator with brand new. New alternator putting out 14.4V. Battery keeps dying. Still no parasitic current draw.
I did two things right around the same time I started having the issue. I put in a new head unit. I already had an aftermarket head unit and I simply upgraded. I know this isn't the issue because I ripped the thing out completely, including wiring harness, and I still kept having a problem. The other change I made was going from a MFSW to a 3-spoke. I removed the MFSW relay and switched the pins in the column so that the horn and airbag work properly. I tried the cruise control and it doesn't work. When I try to turn on the cruise control, it blows the horn fuse. Replaced the horn fuse and I just don't use the cruise.
What I'm wondering is if I messed up the CCM when I did the steering wheel swap. I've read that bad CCMs can kill batteries. I'm not having the typical faulty CCM issues. The only issues, besides the battery dying, are that the unlock on the keyfob will stop working at random, and the "door ajar" light on my dash flickers at random.
View 24 Replies
Only electrical mod that was done was the fog light mod so I can turn them on when I want... Is it possible that even if the fog lights are off, that they are pulling some juice from the battery ? In the last 6 months my car has died 4 times, ever since the fog light mod.
View 20 Replies
I have a MKIV R32 and the other day I was driving with the A/C on, blowing cold air when randomly the air turned hot and hasn't blown cold yet. I took a look at the refrigerant levels today and they show a full charge along with the low-side refrigerant tube to the compressor getting cold but no still no luck.
The compressor is on so I don't think that's at fault, what else could there be? Something electrical maybe?
View 7 Replies
My Mk4 2000 Jetta 2.slow has been acting up, a week ago I went to pick something up from my fathers house and a minute later I cam back to start it to only have the idle strange,it as well the throttle being all sorts of weir till it cut out and I had to push it into the drive way. I has the coil pack tested, and it was measured to be right where it needed to buy. I then bought starting fluid and after spraying it into the air intake it started. I had it running till it cut out and had to redo it again. Then when driving home again after putting more in it stopped, I was able to start it again keep moving for another ten second before having it stop again. I am receiving no check engine lights, alternator is good and as wel as the battery.
View 10 Replies
My issue is on my 1999 Vw Golf MK4 2.0 L Automatic is that today I was heading home from my Moms house. I noticed a fuel smell coming from the engine . I was making a turn to head west then the car suddenly turned off while still in motion.. I let the car die completely turned it back on and it eventually turned back on .The check engine light was on I then headed home I also noticed while in 4-5 RPM the car would not have that much pressure . Like it wanted to shut off again .. I was doing some research from similar issues like mine . Someone said to replace my EGR Valve and my Speed sensor.
View 1 Replies
2005 1.8t gti. so my left blinker bulb went out and it was acting normally for a burnt bulb but then my right blinker started to randomly come on and stay on, my blinker arrow on my dash will stay on but very dimly and when i go over bumps it will click on and off and sometimes stay on then shut off when i go over another bump.
View 2 Replies
I got my jetta over a year ago, and during that time I've accidentally left the lights on a number of times. But just a few days ago it started making a tone when I leave the lights on. Is there some way to turn that feature on and off, or was something wrong that mysteriously healed itself?
View 3 Replies
I recently replaced my SAI pump rivets with stainless bolts so everything is nice and tight. However, the pump will randomly cut on and run for a few seconds while driving... i notice it usually when I come to a stop, such as at a stop light. I would assume this is because there is an air leak somewhere in the SAI system... sound likely? Maybe purge valve? I haven't yet had it pressure tested in case there is something I can easily to to rule out most potential sources.
View 8 Replies
