Santa FE SM (2001-06) :: 2003 2.7L V6 Not Starting Or Cranking After Heavy Rain
Jan 27, 2013
Several weeks ago I made another thread because I was having crankshaft position sensor problems and essentially that was due to a short on the sensors wires which had become exposed. I replaced the sensor and it still did not work until later trying another brand which solved the problem.
I also changed all six spark plugs, wires, and plenum gasket with OEM parts. I was able to get to the back three plugs by following this tutorial with the guidance of a friend who is a mechanic. After getting this done, the car has run way better and smoother.
However, today it has been raining heavily and I needed to run an errand so I went to my car and turned the key but nothing happened. All the dash lights turned on and appeared normal. My radio works, lights work, etc; but I can not get the car to crank at all. I hear the fuel pump turn on and everything else sounds normal, but still no crank. There are no sounds from the starter at all, it is silent when I try to get the car to turn over.
I took a look at the car and the coil pack seems dry, the plug wires are secure, plus we had put di-electric grease on all those connections. The negative terminal on the battery has a solid connection. I even tried jumping the car to see if maybe it was due to the battery, but again nothing happened.
This has only happened once before when it was raining, before I had changed the plugs and wires, but I was able to get it to crank over after about 4 minutes of waiting and contemplating getting a tow. I took a look at all the fuses and they appear to be intact.
View 11 Replies
Advertisement
I have a 2003 Santa Fe with 187,000KM on the clock. The mechanic noted on it's service that there is a heavy oil leak and suggested it might be the valve cover gaskets or the timing cover. I had the valve cover gaskets replaced by a friend, but unfortunately the car is still leaking oil - presumably from the timing cover. The driveway is covered in oil, the car smells while being driven and needs topping up with oil. I have kept the car going for a while like this, but am uncomfortable with it.
The mechanic suggested there is a possibility it could be a water pump causing the leak and the repair on this would be super expensive, but they can't tell until they're inside.
View 2 Replies
Last May I had the distributor replaced in my 2001 Nissan Xterra. Since it was replaced my car has shut off while I am driving three different times, separated by weeks to months, and only in heavy rain storms. When the car does shutoff it takes up to 15 minutes until it will start up again. In each case, once the car restarted it did not shutoff again. I recently noticed a correlation to heavy rain because I did not have any problems all summer long ( I live in Oregon where it never rains in the summer) and then last week in a heavy rainstorm the car shutoff while I was waiting at a red light.
View 4 Replies
I have a 2001 Escape I bought new so many years ago. It only has 90k miles. The other day I drove it to work running fine. It rained REALLY hard that day and when I came out to go home it would barely start, missing really bad. Limped it home and into my garage where I examined it for water under the hood. Nothing. Started pulling things apart, nothing on the engine, around the coils, in the spark plug conduits, etc., dry as a bone. Let it sit for a couple of days and no change. Replaced the coils just for grins. Drained the fuel from the injector assy, looking for water. Nada. Verified spark, fuel, compression. Still, very difficult to start and when it does it's only running on cyls 1,2 & 3 because I can disconnect the coils on 4,5,6 and it makes no difference.
View 6 Replies
I have had a 2000 f250 crew cab for little over a year now. Two previous times, after heavy rains, the cabin light would blink on and i would get a buzzing sound under the dash. I would solve the annoying buzzing sound by opening and closing the door. After a few times, it would work, but my clock and radio could go on without the key in the on position. The next time i used it, no problems... so i put that worry in the back of my mind.
This morning it rained really heavy, sideways type of rain. I opened the door and noticed a small puddle on the vinyl floors right where my left foot goes. OH,oh i thought, but the truck turned over and ran like normal. I picked up a heavy load of hickory in the bed and hopped back in and noticed my speedometer jumping from 0- 30 when I was going about 35. The OD light was blinking, but the transmission shifted normally. I got up to about 1700 rpm and the speedo was barely jumping at 53-55. I make another stop to unload the wood and go back home and i get an intermittent buzzing sound on the way home and no speedo. OD light would start blinking before i hit 2nd gear. I also noticed the odometer not working (speedo related, right?)
I got home and took the fuse relay cover off and found that if I would remove the #1 relay "plug" (black square box 5 prongs) that dreaded buzzing sound would go away, checked it out , plugged it back in, buzzing back on. The clock light still stays on and radio will turn on without the key. I think that water obviously leaked in over something electrical and i have been searching this and other forms for a couple of hours. I am within a couple of weeks of saving up enough to buy the gauges, exhaust and possible DP Tuner and now this happens?
View 14 Replies
On the wifes Santa Fe 2.4 AWD every few starts it seems to crank over longer than it should. It will usually crank right up like it is supposed to. Every few times it may take 3-4 seconds of cranking before it will fire.
The car runs great, averages over 30mpg per the computer. No codes. I don't have a clue what it could be.
View 3 Replies
The key in my 2003 Hyundai Santa Fe is rotating freely without starting the car. The Accessories are always on and I had to disconnect the battery to prevent drainage. I removed the lock cylinder and found a small camshaft like part that seems to be loose and broken, one piece of it seems to be broken in the switch. Is there anywhere I can get this camshaft like part? I searched but can only find either the lock cylinder or the switch. See the attached pic for the part I am talking about.
View 3 Replies
2002 elantra gls 125k miles, Automatic
I have a very intermittent problem starting the vehicle first thing in the morning ( this has happened twice this week, but only 5-6 times in the past year or so). It will crank and sound as if it just about to start, but not quite fire. After 5-10 mins of cranking, shifting into and out of gear, rocking vehicle (not sure what actually causes it to start, if anything) the car fires and runs just fine, starting normally until the next "event".
Plugged it in and got no codes.. The only difference I can see is that every time this has happened recently the car has been parked in a parking garage at work on a minor incline for about 13 hours.
View 5 Replies
1996 f150 sometimes it starts sometimes it don't. It is cranking over the starter is in gauging as well as the fuel pump I can hear it.... It's getting spark and I replaced the starter solenoid.
View 5 Replies
Just bought this 1999 7.3 drove it a couple days now and got to walmart today. shut it off to go inside and came back out. turned on key waited for wait to start to go off. cranked the motor over but it didnt fire. i tried it again and nothing. oil is full, oil pressure is good while cranking. no rpm reading on gauge while cranking. no check engine light. batteries are literally brand new two weeks ago. Cam sensor?
View 4 Replies
My 2003 F-250 (gas V8) will always start right up when it is cold. However, once it has warmed up, it often will not start. Cranks fine, but not even wanting to start (like someone pulled all the plug wires) and has left me stranded until I wait for 3+ hours for it to cool back down. Doesn't trip the check engine light, but seems to be due to the engine being hot. What this could be?
View 7 Replies
I had the head gasket replaced along with all the other gaskets that come in the kit. new radiator, water pump, thermostat and thermostat gasket. blew head gasket at 78,000 miles. So now that has been taken care of, slowly everything else is going bad. recently, i pulled up in front of someones house and my suv turned off. When I tried to start it again it made a clanking sound and would not start. AAA'd it home and pulled the timing cover where the source of the sound was coming from. Seen the tensioner pulley loose and the belt loose. got it back on tdc and still does not start. the cranking over sound is lagging and sounds whiny. thought maybe was out of gas so i got gas and now when i try to start it it still is winding but it backfired and there was smoke behind the upper intake and still wont start. It wants to start, but doesn't.
View 11 Replies
This past winter I started having trouble with my '06 Santa Fe where I would turn the key to start my car and nothing would happen. No cranking, no clicking, no sound. My lights turn on fine, radio, everything else works just fine. Sometimes it won't start for 30+ minutes, and sometimes I'll just try a second time and it'll start up right away.
Last winter when this happened my check engine light came on and so I took it to the dealership and they said it was the crank position sensor that needed replaced. For whatever reason I didn't get it fixed and have been driving my car with no problems whatsoever for 10 months or so, until this weekend when my no start issues started again. The check engine light is on again and it's the same code for the crank position sensor.
I believe I will definitely get the crank sensor fixed this time, but could the issue possibly be anything else? Bad starter? Ignition switch? My mechanic can't give me a definite answer because every time I take it to the shop it starts up just fine for him.
View 6 Replies
I bought a 2004 Santa fe with the 2.4 engine not running. It will not get spark, it is getting fuel I can smell it strong after cranking...It has a new crank position sensor, I took the timing cover off to verify. Whoever put the sensor on cut the wires and soldered/ heat shrink them back together obviously because they didn't want to remove the timing belt. It Also it has a new ignition failure sensor, all fuses are good, there was a spare computer in the vehicle which I tried still no luck. I took loom off and looked at the harness and can't find anything.
View 8 Replies
I have been experiencing an intermittent problem with the power steering on my 2002 Santa Fe. It seems to happen in the rain or when driving through puddles...the power steering seems to lock up for a short period, usually lasting only seconds. It has only been a nuisance so far, but it could be a major safety issue if it happens at the wrong time.
- 112K miles
- PS Fluid looks full
View 7 Replies
I have a 2003 BMW 525i. A couple of years ago, after a heavy rainstorm, I found water in the footwell of the backseat behind the driver’s seat. I took my car to a mechanic and he mentioned the door’s vapor barrier and the vapor barrier was resealed. Again a heavy rain storm, back to the mechanic and the vapor barrier was resealed. This has happened three times and I feel that there is a problem somewhere that has been overlooked by my mechanic. Normally, my car is garaged, but when out of town, my poor car is at the mercy of the weather.
View 2 Replies
High mileage santa fe 190K+ miles. Will only start while cranking. Dies when key is in "on" position. Fuel pump runs/cycles normally when turned to "on" position. No obvious vacuum leaks. No intake obstructions. Vehicle will cont to run using starting fluid. Vehicle starts, idles and runs (somewhat poorly) with MAF unplugged. Fuses appear ok (although the fuse cover/fuse index is lost). Stranded at rural property with limited tools and average abilities.
View 3 Replies
Friend has '04 LS and he says that after a heavy rain, his LS will only go about 25 mph. Water is getting into something but where? This lasts for about 2 weeks and then all is OK. Water is finally evaporating, I assume, and problem goes away.
View 4 Replies
My car is suffering after being stood out in heavy rain - which there's been a lot of recently. When I go to unlock it there is no response and starting requires using the key to be turned left first. Keyless entry doesn't work. All electrics are dead until the car starts. When it's not raining everything's OK again.
View 2 Replies
There has been on/off heavy rain in northern nj the past week, and i noticed two nights ago that when i am turning it sounds like i have a waterfall in front of the dash. if i am making a right i hear water running towards the left and vice versa. I already searched and found one article pertaining to a "sloshing". the problem: it didnt have a solution.
View 6 Replies
My 1990 Honda Civic DX died in heavy rain. Diagnosis: Need new alternator. Got it. Car immediately started surging loudly whenever idling. Took it back to the shop. 3 mechanics huddled for 3 hours and couldn't figure out what was wrong. Quick fix: Deactivate IAC. They said I should be good for a couple of months. Took one 25-mph drive around the neighborhood. Car ran very rough; panel under steering wheel jolted loose. Made it home but now car won't start. Battery is fine. Wonderful Firestone manager is willing to look at car again. I'm broke after the alternator on top of paying the IRS in April and really want to keep my generally reliable car (only 255,000 miles), at least through the hot South Florida summer.
View 10 Replies
