Elantra XD (2001-06) :: High Oil Temp And Still Overheating After Replacing Thermostat
Nov 24, 2012
So my 2005 elantra gls has been having overheating problems. A few weeks ago, it overheated one day driving around town for about 30 minutes. I kicked on the heater and made it home. I went out the next day and didn't see any problems. Everything went fine for two weeks, then yesterday the problem happened again. I read about the thermostat often failing, so I did some research on that and replaced it today.
For replacing the thermostat, I followed the lower hose and found the housing, removed it and took out the old thermostat. Removed the old gasket, cleaned around the connection, dried it off. Then I put the new thermostat in , put some gasket sealer down and putthe new gasket on. Finally, put some more sealer on the outside of the gasket and put the housing back on.
After replacing it and immediately turning on the car, I got a High Oil Temp code. I cleared the code and let the car idle for while. After about 15 minutes I went for a drive around the neighborhood and then took it out on the highway for about 10 minutes. It started overheating by the time I got home. I turned it off and when starting it again I get the High Oil Temp code.
Is it possible that I didn't do something correctly with the thermostat. If not, what else could I look for and could I have bumped/damaged the oil temp sensor?
View 2 Replies
Advertisement
I replaced my battery. Once I connected my new battery, my fuel and temperature gauge started working strangely. They would either be high, then go low, then go back high. My interior lights, clock, and radio stopped working. Could it be a relay? I checked all the fuses with a test light and they all looked good.
View 1 Replies
My 2013 Elantra twice now has almost overheated. About a month ago i had the software patch related to the cooling fan done. Since then, twice the temp almost hit max and the warning light came on. Both times i had driven it in 80 degree weather with 3 short trips to various stores. Both times the air conditioning seemed to stop working and the gauge started to rise to max. The second time i turned off the car and restarted it and everything returned to normal. If it happens again i will check to see if the cooling fan is on. It seems to me that turning it off and on to fix would be a software glitch. The car has 30000 miles on it.
View 5 Replies
I have a 2006 Jeep Liberty 3.7L that has a temperature gauge on the dash that reads an overheat when driving. The oil looks normal, there is no white smoke, no bubbling from reservoir. I have replaced the following:
Radiator
Thermostat
Water Pump
Coolant Temperature Sensor
Coolant Reservoir Tank
I am not leaking any coolant and the reservoir level has been fine. I have let the vehicle idle for 20+minutes, with no overheat. When I drive it around, the temperature gauge will read an overheat. When I stop the car and pop the hood, the engine is not overheated and both rubber hoses to/from radiator are flowing the coolant. The only thing that will bring the gauge down is turning on the heater full blast. Could this be the gauge itself being bad? Could it be a short in a wire somewhere? I had thought maybe a head gasket, but have no symptoms of a head gasket.
View 9 Replies
I have a 2016. I'm waiting on some aftermarket headlights and they will look great with LED drl/high beam. Have you installed them in this location ? I'm worried about fitment with the led being too big to fit in there.
View 23 Replies
I recently had the engine light come up on my Hyundai Elantra 2003. I read the code with my cheap little code reader with the torque lite (free) app on android. It threw the P0128 code which means a faulty thermostat.
Here's the web link to all the details on the code: [URL] ....
I have checked the coolant level and its good. The strength of the coolant is good to -40 Celsius. The engine fan is not running at all. I recently changed the thermostat. I'm leaning towards faulty ECT. The car takes forever to blow hot air too. It has done weird readings in the past with the temperature gauge in the cab.
I just bought a infrared temperature reader of Amazon and want to check the temperature where the water comes out of the engine past the thermostat and compare it to the reading on the torque app readings. I'm thinking it won't match.
View 15 Replies
I have an 01 mailibu that keeps overheating. I have replaced the water pump (twice) and had the thermostat replaced. The water pump and thermostat were replaced about a month ago. Last night while driving, i noticed the temp getting higher, so I turned on the heat, and instead of hot air, it was ice cold. What it could be?
View 2 Replies
My 01 passat is telling me to check my coolant when it's working fine and its not overheating I think it might just be a sensor because my check engine light is on and it's reading thermostat.
View 6 Replies
I am having some trouble with my 4R100 overheating.
Truck is a 2001 F250 XLT 7.3L with 244k miles on it. According to previous owner, the transmission was replaced around 185/190k but there was no paperwork to prove it.
I recently had a leak from one of transmission lines coming into the bottom of the radiator (the one on the passenger side). I replaced it and topped off the little bit of fluid that leaked out. Last weekend I installed a temp sensor in the transmission and hooked it up to my pillar gauges. The first few days driving with it, the temp was at/around 180 degrees, 25-30 degree outside air, unloaded on the highway averaging 70-75mph.
Today on the way home, the temp got to 180 after 35-40min of driving then continue climbing. I pulled off the highway after 1.5hrs and the temp was almost at 210 degrees. I let it idle for 5-10min and the temp didn't change. I turned it off and let it sit for 15 min. Upon starting it back up, the temp had dropped to 180. I continued driving and the temp climbed back up to 210 within 35 minutes. (65-75mph, 24 degree outside temp, unloaded). Once off the highway I averaged 35-45mph on the back roads to my house. The temp started to drop back towards 180 degrees.
Before I start throwing money at it, and installing a 6.0 cooler etc. I am thinking there is something else wrong here. I am going to look at new lines and replacing/repairing the bypass valve on the transmission. I am driving 2hrs to work each way and thats when the temp really starts to go up. The fluid doesnt smell burnt, its still nice and red. I am going to try and flush the lines this weekend and see if something is plugged/caught. I ordered an inline filter today and will put that in with a new hose from the transmission to the radiator (old one is rusted).
View 2 Replies
I have a 2001 Nissan Frontier Crew Cab XE with a V6 (without the supercharger). I bought it on Halloween night with only 42,000 miles. It now has 112,000 miles on it. I moved from Georgia to Kentucky and heard that I needed to have the cooling system flushed/filled to prevent it from freezing in the winter time. I then noticed that it would periodically "overheat." The temperature gauge would climb up to the line just below the "H" and then I would turn on the heater.
I read online about a "bleeder valve" on top of the intake manifold. I loosened it, squeezed the radiator hoses to get all of the air out and then tightened the bleeder valve. I then let it run until the thermostat opened, revved it up to 3,000 to let all of the coolant flow. Now, at various time with no specific reason, it will run fine and then just "decide" to overheat.
I can drive it on the interstate for fifteen minutes, park it in front of my house and then have to "tack it up to 3,000" just to get it cool. I've changed the thermostat and had the water pump tested. Neither of them are faulty. My mechanic vacuumed out all of the air from the system with a special tool the dealer recommends using and it still does the same thing. What's going on with this vehicle?
View 7 Replies
My '01 Grand Cherokee Limited is overheating. I have changed the thermostat and ran a leak test. I am not having a leak. The temp drops when I turn on the A/C or heater. I went back to the shop that changed the thermostat and leak test. They said it was the fan control and I have to go to the dealer to reflash the program for the fan control. I made the mistake of asking the dealer to reflash, instead of having them check on the overheating problem. I'm planning on going back to the dealer to have them diagnose the issue.
View 16 Replies
My temperature has been randomly dropping, them back to middle, and recently my engine was overheating because I'm guessing the fans didn't turn on, because I'm also guessing, the engine didn't know it was overheating?
Anywho, during my replacement, I made sure to get rid of the pressure, and the car was cold. I tightened the cap again, but when I took the sensor out, all the coolant spewed out.
Now if I understand this correctly, do I have a leak? I figured the leak I had was coming from the temp sensor as it is.
Here's some pictures for those who'd like to see ....
View 4 Replies
I have a used 2002 hyundai Elantra gt that I've owned since the 4th. I bought this car and everything was fine but I had to put a new battery in it because the previous owner was taking hers. A week after replacing the battery the car died, I thought maybe it was a bad battery so I replaced that one also and the car ran for about 2 days and then died again. I replaced the alternator last Monday and again the car ran until this past Thursday. I took the alternator back and had it tested and it failed. So I went to a different shop and had an alternator tested before purchasing it and it passed. Put the alternator in but the car won't stay on longer than 30 min.
View 5 Replies
Today I replaced my thermostat and thermostat housing. I happened to be unfortunate and cracked my dipstick tube (probably should be replaced at 135k miles anyways). I know I can get it at the dealership, but it's pretty far out of my way and wouldn't mind just ordering it from ecstuning or something.
View 4 Replies
I have a question regarding a overheating problem I have with my 99GLS V6. I had the dealer do a timing belt, water pump, thermostat etc on my Passat about a year ago. I also have coolant leak in the metal pipes under my intake, which I haven't had a chance to tend to yet. I noticed recently that my car overheats and there was alot of pressure built up in the hoses. If I remember correctly, the thermostats are designed to fail in the open position. So I am wondering because of the leak, what's the chances that my thermostat could have failed in the closed position? I'm hoping its just air in the system and lack of coolant is causing this. It's been more than a year so I'll have to cough up the dough for this one.
View 10 Replies
I have a 2004 Honda Civic Lx and I was driving one day and I look down to see if I was speeding or not (easy to do) and I see that the thermostat is almost all the way to the red line. So I pull over to a store and check my fluids. The oil was low so I put two quarts in. There are no signs of leaks anywhere. I also topped off the coolant. Ever sense the care has been fine so could of it been the low fluids?
View 5 Replies
I have a 2004 Grand Prix and it is displaying the symptoms of overheating but the temp gauge is not going above normal operating temp. I replaced the thermostat twice, and after driving for about 10-20 mins coolant comes out of the overflow. I'm at a loss, I'm thinking temp sensor(?) But I don't want to keep throwing unnecessary money into it. The fans work fine, the heater blows as it should.
View 8 Replies
My engine started overheating, and because I was stuck on a bridge during rush hour (George Washington Bridge in NYC), I couldn't get stop the car. I drove it for approximately 30 min (slow crawl), and this happened: [URL] .....
Yes, I know how stupid it is, but there was not even a shoulder to pull over to the side. The only good thing is that this happened pretty much soon as Igot off the bridge, and not on the bridge.
Hose by the radiator cap (is that the overflow hose?) popped out and spewed steam for good 5 minutes. The car did not start at this point. I left the car by the gas station after the bridge, and came back later on in the night. It started and I was able to drive it home (about 10 min away) at crawl speed without it reaching the red zone.
Today, I just did the oil change, topped off on the coolant, and also replaced the thermostat. But the engine still overheats (to the red). The upper radiator hose is burning hot and the bottom radiator hose is not. Also, the fan is working, but it blows out pretty hot air.
View 12 Replies
I changed the radiator and thermostat, changed the coolant, and my fans work. however, whenever i take the car for a short drive, the temp goes up. I stop the car and shut it off, it steams near th coolant tank. it sounds like its almost boiling..
View 5 Replies
I drive a 2005 elantra drives smooth until when the temp rises to the middle of the gauge and then it idles more with a racking noise from the engine it happens fast when I drive with the A/C on in the afternoon I have a new radiator tank now.
View 6 Replies
I know many of the vendors for the Gencoupe will install lower temp radiator thermostats to keep the engine oil temps down.
What would the effects of this be on our turbo's? Grimmspeed makes a 140* thermo for the gc's and I believe it's 20* cooler than stock for them.
Would this to something we could do to protect from detonation and run the engine a little cooler during the hot summer months?
View 6 Replies
