Ford 7.3L Power Stroke (1999-2003) :: Driver Side Door Panel And Liner Off


May 19, 2015

I've taken the driver's door panel off, and unpeeled the liner. Now that the door is naked and exposed, I'd like to fix several things at once, rather than wearing the adhesive liner out by sticking and unsticking several cycles.

Here's a short list of some potential fixes I foresee taking care of while in there, how to :

1. The door ajar light. Mine went out over a decade ago, and the gallon of WD40 I sprayed into the latch did NOT fix it. In fact, it turned it from an intermittent issue into a permanent problem. I'd like to fix it now, as I miss having a light at night when the door is open. How do I fix it? Links, part numbers, tips, pictures, videos, search terms... all info welcome.

2. Bottom door rust. I don't really have much, but I see very faint hints of paint bubbling under the lower door weatherstrip barrier, which I have also removed. I've read about two schools of thought on preventative maintenance.

A. Pour oil or grease into the bottom of the door.

B. POR15 paint in the bottom of the door.

So basically, oil or paint? Obviously, one can't paint if one does oil, but on the other hand, some say that paint... especially thick paint like POR15, can actually do more harm than good by trapping moisture in the bottom pinch flange, or by creating craters or tunnels where water can burrow and then get trapped, rotting the metal away. What are your thoughts and experiences on this? I'd prefer a solution that minimizes the number of times I have to unstick the interior liner from the door.

3. I'm doubling the lower door weatherstrip with a combination of the older and newer designs. Ford sells the weatherstrip with clips attached, but neither those clips, nor the original clips, are really effective for what I'm trying to do. I've already done the rear doors, and made it work with the original clips, but they are brittle, and I lost a couple to breakage. Today, I broke three clips pulling the old weatherstrip off of the door.

I can't find these clips anywhere locally... I've tried every variety the auto parts and auto body stores sell, and Ford doesn't sell these clips separately from the weatherstrip... and even if Ford did, they OEM clips are not long enough to hold the double deployment of old and new styles of weatherstripping.

In searching this issue, it appears that a lot of people have broken these clips, which stands to reason with plastic in baking inside a hot door for 15 years. I'm sure I'm not the only one who would benefit from finding a good source of automotive clips.

4. Mirrors. I'm finally getting around to this, and this is what motivated the door panel removal in the first place. I need the dog bone harness that converts from a round connector to the flat style connector. Specifically, I need part numbers 1C3Z-14A411-AA and 1C3Z-14A411-BA. Ford didn't originally sell these dogbone harnesses separately, but included with the purchase of newer style outside rear view mirrors in case the translation harness was needed. Sometimes it was, sometimes it wasn't, so there would often be these unused harnesses left over.

5. Jimmy Jammers. Will they cause more harm than good? Does a better alternative exist? Thinking of installing these while I"m in there, but worried the door will be damaged worse as the thief tries to fight their way in. And, with body on shell doors, there appears to be much easier ways to break into an SD anyway, so part of me thinks, why bother

View 14 Replies

Advertisement

Ford 7.3L Power Stroke (1999-2003) :: Driver Side Back Door Won't Open

My driver side back suicide door won't open. It is the top latch that is not disengaging. I think I heard something loose in that door over the past month. Am I going to have to take off the inside panel to fix it?

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: Extended Cab Driver Side Door Won't Open

I can't figure out the problem with my extended cab door. Driver's side doesn't open with either door handle.

View 13 Replies

Golf/GTI VI :: Driver Side Front Fender Liner Missing Access Panel

If the driver's side fender liner is supposed to have an access panel cover? I was swapping out my side markers today and noticed that my passenger's side has one but not the driver's side. Didn't think to check for something like that during delivery although from looking at the one from the passenger's side, it doesn't seem hard to believe that it could have fallen out due to spirited driving.

View 3 Replies

Ford 7.3L Power Stroke (1999-2003) :: Different Battery Box For Driver Side?

Is there a different battery box or better battery holder for the driver side without all the air filter housing stuff. I had an AFE Big boost filter and when I modified the stock battery box it still had the bottom section of the air filter compartment well after about 4-5 years I was cleaning the filter today and there was a hole rubbed in the filter from moving around and the pre filter is getting holes wore through it. So I cut the air box part off so now the filter will sit on the fiberglass stuff on the fender well. I ordered a couple of the new Blue Donaldsons from RiffRaff to replace the Big Boost filter. The modified filter box looks kinda like a hack job because all I had was a cut off wheel and the plastic got hot and now I have melted buggers all over it. I thought I saw somethin a long time ago about a battery holder out of a van that was just the bottom plate but can't find it anywhere now.

View 8 Replies

Sierra :: 2003 GMC Fuse Panel Inside Driver Door On Dash Not Getting Power

My sister has a 2003 gmc sierra and the 12 way body plug in the fuse panel inside drivers door on dash isn't getting power. Where that section of fuse box gets power from? The rest works its just the 12 plug???

View 1 Replies

Ford 7.3L Power Stroke (1999-2003) :: Leaking Power Steering Under The Wheel Arch On The Driver Side

Initially had indications of a leak under the wheel arch on the drivers side.

About 3-4 months back replaced both PS lines and the leak stopped - briefly (maybe a couple a weeks).

Now the leak is back, but what's interesting is I lose more ATF fluid on a single long haul run than I do running round town for 3 weeks. I can't work out where the leak is coming from to identify what else to replace - short of just buying a pump and reservoir and replacing them as I've already done the hoses.

My turbo cooler pipe was hard up against the old PS pipe where it entered the side of the reservoir until I did the replacement hoses. Now I have it out the way but I'm wondering if it's caused some unseen wear or damage.

If I just do the pump to see if that works are the reman units any good out of Autozone or O'reilly's?

View 9 Replies

Ford 7.3L Power Stroke (1999-2003) :: Oil Leak Near Driver Side Up Pipe

Small oil leak looks like coming down by drivers side up pipe. I don't think it's the turbo o rings. Better not be. But could be I guess. Anyways. It runs down somewhere by the up pipe down onto transmission. I'm not loosing tremendous oil or anything.

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: 2002 - Oil Leak From Driver Side?

I have a '02 7.3 that has developed a severe oil leak in what seems to be a small line that runs from the drivers side head to the HPOP on the passengers side.

it seems to be leaking at the braket that secures it to the head on the drivers side.

what is this line called and where can i find one A.S.A.P?

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: Driver Side Key Lock Recessed?

'99 F250 SuperDuty. Tumbler is recessed and the key slot is horizontal rather than vertical. I suspect the spring fingered clip has fallen off.

View 2 Replies

Ford 7.3L Power Stroke (1999-2003) :: Drip Leak On The Driver Side

It is still a drip, but is getting worse, for several weeks. May be power steering fluid. I have not found the source. I think it is after the truck has run and has fluids operating under pressure.

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: Small Leak Under HPOP Driver Side Near The IPR

After cleaning entire valley on my 2001 f350 with 7.3 I have found what appears to be a small leak under the hpop drivers near the IPR. HPOP lines are clean and dry. Possible for IPR to leak at 120k miles and what will need to be done to fix.

View 2 Replies

Ford 7.3L Power Stroke (1999-2003) :: How To Remove Driver Side Rear Rotor

I noticed my rear brake smoking on the truck really just the rear driver side. I had replaced the pads and caliper and rotor a very long time ago. What I think happened is the parking brake got hung up somehow. The wheel was extremely warm and the reason I noticed it was not only the smoke but I felt some sort of wobble or almost out of alignment issue.

When I got home I noticed the smoke and extreme heat. I removed the caliper and the pads look still "new" and evenly worn. I did bleed the caliper just to make sure no air, I even put a spacer in the caliper and my wife applied the brake and they closed appropriately. Then I was trying to get the rotor off and no success. I did adjust the parking brake but I am not sure if you move it up or down to loosen it up?

I have used PB Blaster to try and loosen it up, rubber mallet while I turn it (although it does not turn easily at all), I sprayed it inside where the adjuster is hoping it would seep down between the shoes and the hub. I heated the hub up with a little torch - no success. I was thinking of using a wood piece as a butter and hammer from the inside out on the rotor but fear that will warm the rotor itself.

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: Can't Undone Harness On Top Of Driver Side Valve?

I have what might be a big problem, the main harness on top of the drivers side valve cover I can't get undone, the bolt holding it together is stripped or the nut who knows? wondering if there is any way to take it apart otherwise.

View 11 Replies

Ford 7.3L Power Stroke (1999-2003) :: Driver Side Brake Line Cut At Inner Fender

2003 Ford excursion 7.3. Above the drivers side front tire, the hard inner plastic made contact with the hard line above the frame.. Cut the line. I can't tell if this line is 1 piece towards the reservoir since its hidden from my quick inspection. Looking for a schematic on replacing this line?

This happened after my wife took the truck back to the sugar bush.. She must have been hitting jumps or something

View 2 Replies

Ford 7.3L Power Stroke (1999-2003) :: Oil Leak On Driver Side And Whole Engine Compartment Is Wet

I'm having a problem trying to locate what I assume is an oil leak. It is on the driver side and the whole engine compartment is wet on the side up on firewall beneath the master cylinder. And the whole underneath is wet also axles and leaf spring and can't find where it's coming from. I have sprayed it down with degreaser to try to pin point the leak still no luck. Truck has 236k on it also new hpop and turbo pedestal and checked the valley and its dry. Right now I'm at a loss. I'm leaning towards oil cooler but would a leaking oil cooler cause whole side of engine compartment to be covered?

View 9 Replies

Ford 7.3L Power Stroke (1999-2003) :: Ticking Noise Coming From Driver Side Of The Engine

So I have a ticking sound that has me puzzled. I thought it could be coming from the drivers side of the engine. This weekend, actually on Monday I decided to do the hot re-torque on the diver side. I warm up the engine for about 15min and have at it. I had put this off for weeks because it has been way too hot. Dam it was still too hot, I was sweating buckets. I had to stop several times to clear the sweat off my head my eyes my shades .I torqued everything to spec and nothing moved.

I went to 125 inch lbs and I got movement on the rear two injectors. I gave them about 1/2 a turn and stopped. I put everything back together, I used hair spray form the 99 ct store. It seemed OK. Fast forward to Tue. I needed to be sure so I went for the boost leak test. Here is my concern. I was going to test to about 30 PSIG, but I ended up at about 40 psig and I forgot to disconnect the MAP sensor! How likely is it that I damaged the sensor, and how can I tell? She is pretty stock and does not have a boost fooler to protect the sensor. Nothing popped and I did not leave the the HP on very long.

View 5 Replies

Ford 7.3L Power Stroke (1999-2003) :: Thumping Sound Under Driver Side Floor Board

I have not had much fun with the front end of my 1999 4x4 7.3 diesel dually. Well I replaced the ball joints with moogs over the winter. Just recently I my truck has developed a thumping sound that I can feel under my driver side floor board. The weird thing is that it does not do it all the time. But yesterday I noticed it for a more extended amount of time.

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: Driver Side Battery Is Missing With The Cables Snipped

I purchased a 2000 7.3 dually 4x4 and the driver side battery is missing with the cables snipped.

I noticed the headlights do not function, neither do the brights, the air does not blow. Is this related to the missing battery? Someone said they are on same circuit and dont do separate tasks.

Still starts runs drives fine...

View 6 Replies

Ford 7.3L Power Stroke (1999-2003) :: 2000 - Oil Coming Out Of Sensor On Top Of Engine On Driver Side

I have a sensor on the top of the engine on the driver side that has oil coming out of it. I think it is called an IPC but I want to make sure before I go buy a new one. It sits right behind the power Steering pump. I am replacing the Power steering pump and hoses so I thought I would replace that as well. Also since there is oil in the connection what is the best way to clean the connection electric parts cleaner? By the way this is a 2000 7.3 4x4 ....

View 11 Replies

Ford 7.3L Power Stroke (1999-2003) :: Driver Side Rear Brake Metal Line Cracked

I had a brake line crack on my way home yesterday(that was interesting..) It was the drivers side rear metal line from the splitter to the rubber hose. I went to autozone and was like ok easy enough this line is the same length and appeared to be the same diameter. bend to fit and all was well or not.. the fitting on the end was a different thread pitch and size. 1999 f250 4wd if it matters....

View 4 Replies





Copyrights 2005-15 www.bigresource.org, All rights reserved